2015 Hyundai Genesis

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

Starter wiring burned and caused a small, localized fire in the engine compartment of the vehicle. Replacement of the starter assembly along with related engine wiring harness is necessary for vehicle operation. After mechanic review, it was determined the vehicle will catch fire upon attempt to start the vehicle. The vehicle was parked near our home when the internal burning and subsequent small fire started. The problem was reported to our nearest Hyundai dealership and the car was evaluated by the dealership to confirm the above. The car was inspected by Progressive insurance as well at the dealership and it was determined it was not included in TSB 24-01-057H recall for this VIN for the 2015 Hyundai Genesis. For this specific issue, there was zero indication this was a possibility.

NHTSA ID

11749032

Incident

Jun 6, 2026

UNKNOWN, The car lose electricity, shutting down by itself, when I press start engine, or when I shut down engine, recently car shuts off while I drive it on highway, it didn't start until I jump start it, also it shows lights of ABS, and brakes auto hold, cruise control not working.

NHTSA ID

11740461

Incident

Mar 11, 2026

I have a 2015 Hyundai Genesis. I had an over heating issue with the car in January of 2025. Took the car to an authorized dealership, and had the repair made.a month later a code appeared on my Dash it read “PSB “. I went to have my vehicles emission’s test and the car failed. I took the car to an authorized Hyundai dealer and they said its most likely the fuel pump module, but wouldn’t know til they examined it thoroughly. After they replaced the fuel pump p module they called me and said that the seat belt positioned went bad and it was explosive. That it’s a safety feature on this model and it was caused by the fuel pump module. If the dealt belt is a safety feature and it becomes defective, shouldn’t it be under warranty? You can’t drive in my state I belted, and if the seat belt positioner is explosive isn’t that a hazard? I think the seat belt , any part of the seat belt should be a warranty item for the life of the car, especially if it’s for safety. I am now being told that there is a $1500 cost in order to fix this item.

NHTSA ID

11734938

Incident

Dec 31, 1969

I took my car in to Tomball Hyundai due to intermittent failure of the headlight switch and the wiper switch when both of these features are set to the ‘Auto’ setting. These are very intermittent issues, but as luck would have it, it was sprinkling on my drive to the dealership on [XXX] and I was able to capture the wiper issue via video on my phone which I shared with the service advisor. Then, fortunately, 2 days later, the service technician was able to verify the intermittent headlight failure. I was aware of a TSB (TXXH) which is meant to address this problem, however, Hyundai issued a superseded TSB a few months after the original, in which they deleted the wiper switch from the service. The 2015 Genesis multifunction switch is sold as a single integrated unit (P/N 93400-3M031), but Hyundai’s TSB 20-BE-009H-1 mandates a "hack" repair that leaves the failing wiper switch in place. It is my assertion that when Hyundai settled a class action lawsuit regarding this switch, they agreed to extend the warranty on the entirety of the Multifunction Switch Assembly (NOT just the Headlight portion of the switch) for 15 years and Unlimited mileage. The Hyundai National Customer Service Case Manager (Roobika, 714-912-2118 National Consumer Affairs) told me that my request of having the complete switch replaced was denied due to the vehicle being out of warranty and having 73,481 miles. *to be clear here - Hyundai HAS agreed to replace the Headlight switch only - their denial centers on the Wiper switch. Eager to find a solution, I suggested that I could cost-share. This was declined as well. I was only given the option of buying the whole switch myself and allowing them to provide the labor to install it. Furthermore, It is technically illogical to perform a warranty repair by disassembling an integrated unit to replace one half while ignoring the failure of the other half—especially when the labor required to access the part is identical. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),

NHTSA ID

11733724

Incident

Apr 20, 2026

Sunroof exploded outwards towards traffic while driving on highway. It caused a loud shot gun sound which cause occupations of our vehicle to panick none the less vehicles behind us got the shattered glass. No warning signs to even look for nor hear. Have called auto places all around us to no avail on getting it fixed. Isn't worth the insurance hike if we cannot even find someone to fix the problem. After research it seems this is a well known problem with a panoramic sunroof. Outside of warranty so we don't know what else to do.

NHTSA ID

11727835

Incident

Mar 25, 2026

The contact owns a 2015 Hyundai Genesis. The contact stated that while stopped at a traffic light or while the vehicle was in drive, the vehicle failed to move, and the engine shut off unexpectedly. Several unknown warning lights were illuminated on the instrument panel. To restart the vehicle, the driver had to shift the gear selector into park and then press the start button. The vehicle was taken to a local dealer, but the dealer was unable to duplicate the failure or determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 120,000.

NHTSA ID

11718710

Incident

Jan 15, 2026

Mileage

120,000 mi

While driving approximately 35–40 mph, the steering wheel locked unexpectedly. My [XXX] child was in the vehicle at the time. I was nearly unable to control the vehicle, creating a serious risk of a crash or fatal injury. The vehicle has a long history of electrical problems including repeated battery failures and a prior transmission replacement. Due to the steering failure, the vehicle is unsafe to operate and has not been driven since the incident. No warning lights were observed prior to the steering failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11715982

Incident

Dec 7, 2025

The vehicle exhibits a severe vibration and shaking at normal highway speeds, most notably around 70–80 mph. The condition is repeatable and occurs during steady freeway driving. The vibration is strong enough that the vehicle feels unstable and unsafe to operate at typical highway speeds. This condition significantly affects safe freeway operation. Due to the severity of the shaking, I no longer feel comfortable or safe driving the vehicle at or above normal traffic speeds, which increases risk when merging, maintaining speed with traffic, or responding to road conditions. The problem has been reproduced and confirmed by authorized dealerships. Multiple inspections and repair attempts have been performed over several months for the same vibration concern. Major drivetrain components, including the rear differential and driveshaft, were replaced, but the vibration remains unresolved. The servicing dealer has stated they do not have a further diagnostic path and are unable to continue addressing the issue. The issue has been ongoing since approximately November 2024 and has not been resolved despite repeated service visits. No warning lights or messages are present. The vibration is speed-dependent rather than engine-speed-dependent. The vehicle remains available for inspection upon request.

NHTSA ID

11715137

Incident

Nov 1, 2024

The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or non‑certified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious injuries and fatalities. Please see attached announcement, provided by NHTSA, for more details.

The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts. These dangerous inflators have ruptured during deployment, posing a serious risk of injury or death due to metal fragments entering the vehicle cabin. To date, Hyundai is aware of three people who have died while driving a Hyundai vehicle with one of these substandard replacement airbag inflators that deployed in what likely would have been a survivable crash. NHTSA has issued a public advisory urging vehicle owners and service professionals to have vehicles inspected if there is reason to believe that a non-genuine replacement airbag may have been installed. Vehicles with salvage or rebuilt titles, prior airbag deployments, or unknown repair histories may present a higher risk. NHTSA strongly cautions against self-inspection by vehicle owners and recommends inspection by trained technicians.

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.

Some vehicles may exhibit a loss of connectivity or interruptions in the middle of using Bluelink Service functions. This may be due to an irregular disconnection on Verizon's communication network. If you are experiencing issues with remote commands, or other Bluelink services, please see the instructions below to reestablish the connection via the AVN pinhole reset method.

Some vehicles may exhibit a loss of connectivity or interruptions in the middle of using Bluelink Service functions. This may be due to an irregular disconnection on Verizon’s communication network. Follow the procedure in this TSB to reestablish the connection via the AVN pinhole reset method.

Certain 2015 – 2016 model year Genesis vehicles may display various Diagnostic Trouble Codes (DTC) related to the Airbag Control Unit (ACU), which may cause the airbag warning light to illuminate. At Hyundai, we are committed to providing vehicles of outstanding quality and value. In an effort to meet this commitment, Hyundai is extending the warranty coverage for the ACU under this condition to 15 years with unlimited mileage from the date of original retail delivery or date of first use and is valid for original and subsequent owners.