2016 Hyundai Genesis

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

steering locks up at times

NHTSA ID

11754245

Incident

Aug 1, 2026

The steering rack malfunctions or fails. When driving at high speeds, the steering wheel gets stuck after being turned. It does not return to center and has to be yanked or forced back to center. There are hundreds of people that have mentioned this online about this Genesis model. This is a major safety issue, as jerking the wheel back to center can cause an accident, and if the wheel gets really stuck, it could cause a major accident. The issue has been confirmed by numerous reports and columns online. For my specific car, an independent service center confirmed the issue after test-driving the car. It has not been inspected by the manufacturer. There are no dash warnings, lights, or codes that indicate the issue. Hyundai should be paying to fix this safety issue. People are driving these cars who can't afford to get it fixed, which is putting others in danger as well.

NHTSA ID

11747998

Incident

May 11, 2026

The contact owns a 2016 Hyundai Genesis. The contact stated that after parking the vehicle in a nearby parking lot, upon returning, there was heavy black smoke coming from under the front passenger’s side seat. Upon further inspection, the contact burned his right hand while attempting to check for the source of the fire. The vehicle was taken to a local dealer while the black smoke was present, where it was diagnosed with a possible wiring harness failure and the vehicle remained with the dealer for further investigation. The vehicle was not repaired. In addition, the contact stated that the method of how the smoke was extinguished was unknown. No medical attention was sought. A Police report was not filed. The contact stated that as per the insurance provider, it was unknown if the vehicle was a total loss. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000.

NHTSA ID

11746437

Incident

May 15, 2026

Mileage

70,000 mi

Oil pressure switch in engine fails to accurately read oil pressure due to a lack of voltage, needing replacement. Causes driver to be unable to read proper oil pressure, leading to a possibility of fire through extreme overheating and friction-induced mechanical failure if the oil pressure is too low and unable to be read. The part has not been inspected by the manufacturer in any capacity, but it is a known issue with the Hyundai 3.8L V6 GDI engine. The oil pressure lamp will display at low RPMs and when at idle. A known fix it replacement of the sensor.

NHTSA ID

11732788

Incident

Apr 21, 2026

My 2016 Hyundai Genesis started flashing a code stating “Check PSB” only a week after buying the car. PSB means Pre-active Seat Belt. The seat belts somehow interlink with the fuel pump. My car has a faulty fuel pump module, causing the PSB warning to flash, even when the vehicle is in motion. It also causes a loud humming coming from the rear of my car, as I accelerate. I’ve done research, and it says MANY owners of the same vehicle report the faulty fuel pump module as the culprit, causing the Check PSB. As well as many owners online stating their vehicle has done the same as mine. There is active recalls on the newer years for this issue, such as the 2023. When the same issue is reported multiple times on the 2016s too, there should be a recall. This is a common issue, & quite frankly a dangerous one. If the fuel pump module is miscommunicating with the seat belts, that could cause them to not react in a collision. I have my vehicle scheduled to be serviced in a few days.

NHTSA ID

11727749

Incident

Mar 1, 2026

My car wont start. When I press the start button everything turns on but it wont start. It functions like the car is ready to drive. For example, it says drive to display tire pressure. The start button says the car is on. I can change gears, the radio works, back up camera works but the car didnt start. This happened before when there was a recall to the starter relay switch. Im wondering if its the same thing again. After waiting over 4 hours the car was able to start. Then again today same issue. There are no warning lights or system failure lights coming on to indicate theres any issue.

NHTSA ID

11727417

Incident

Mar 26, 2026

The contact owns a 2016 Hyundai Genesis. The contact stated that while the vehicle was parked, the passenger’s side rear door failed to open from inside or outside or unlock as needed. The vehicle was taken to a dealer, where it was diagnosed and it was determined that the rear passenger’s door handle actuator was fractured. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 80,100.

NHTSA ID

11722431

Incident

Feb 28, 2026

Mileage

80,100 mi

Oil light keep coming on when the car is stopped or at the light and turns off when it's running mechanic says it's an oil pressure switch which is a common problem with this car. I read a lot of complaints about this but Hyundai is not doing anything.

NHTSA ID

11720050

Incident

Feb 20, 2026

The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts. These dangerous inflators have ruptured during deployment, posing a serious risk of injury or death due to metal fragments entering the vehicle cabin. To date, Hyundai is aware of three people who have died while driving a Hyundai vehicle with one of these substandard replacement airbag inflators that deployed in what likely would have been a survivable crash. NHTSA has issued a public advisory urging vehicle owners and service professionals to have vehicles inspected if there is reason to believe that a non-genuine replacement airbag may have been installed. Vehicles with salvage or rebuilt titles, prior airbag deployments, or unknown repair histories may present a higher risk. NHTSA strongly cautions against self-inspection by vehicle owners and recommends inspection by trained technicians.

The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or non‑certified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious injuries and fatalities. Please see attached announcement, provided by NHTSA, for more details.

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.

Some vehicles may exhibit a loss of connectivity or interruptions in the middle of using Bluelink Service functions. This may be due to an irregular disconnection on Verizon's communication network. If you are experiencing issues with remote commands, or other Bluelink services, please see the instructions below to reestablish the connection via the AVN pinhole reset method.

Some vehicles may exhibit a loss of connectivity or interruptions in the middle of using Bluelink Service functions. This may be due to an irregular disconnection on Verizon’s communication network. Follow the procedure in this TSB to reestablish the connection via the AVN pinhole reset method.

Certain 2015 – 2016 model year Genesis vehicles may display various Diagnostic Trouble Codes (DTC) related to the Airbag Control Unit (ACU), which may cause the airbag warning light to illuminate. At Hyundai, we are committed to providing vehicles of outstanding quality and value. In an effort to meet this commitment, Hyundai is extending the warranty coverage for the ACU under this condition to 15 years with unlimited mileage from the date of original retail delivery or date of first use and is valid for original and subsequent owners.