2009 Hyundai Genesis

On October 28, 2013, Hyundai Motor Company (Hyundai) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the braking system of approximately 43,500 model year (MY) 2009 through 2012 Hyundai Genesis sedans (NHTSA Recall No. 13V-489).The Hyundai report indicates that the recalled vehicles may contain brake fluid that does not sufficiently inhibit corrosion on the zinc plating of control valve armatures in the Hydraulic Electronic Control Unit (HECU) module. The DIR indicated that, over time, the build-up of corrosion products may affect operation of HECU control valves, resulting in a low/soft brake pedal with reduced brake effectiveness, which may increase the risk of a crash.In October 2011, the HECU supplier notified Hyundai that the brake fluid used in production plants was causing corrosion of valve armatures in the control module.The supplier changed the coating of the valve armatures in late March 2012 to correct the problem in production vehicles.Hyundai's recall includes Genesis vehicles produced prior to the implementation of the HECU change.In March 2013, Hyundai initiated a Service Campaign (TL6) to replace brake fluid in the subject vehicles with brake fluid with better corrosion resistance properties.According to Hyundai's DIR letter, after PE13-033 was opened, the company noted that some of the vehicles serviced in the TL6 campaign subsequently required HECU replacement.This was an indication that internal corrosion had progressed enough to affect valve operation and brake performance, prompting Hyundai to conduct a safety recall.Hyundai's repair procedures for 13V-489 require brake system flushing and replacement in all recalled vehicles with a new fluid containing the necessary corrosion inhibitor.In addition, for vehicles produced prior to June 1, 2010, dealers will perform an inspection procedure to verify that the HECU is functioning properly and replace units that do not meet the test requirements.Hyundai indicated that, based on analysis of claim data, only vehicles produced prior to June 1, 2010 have been in service long enough to require the additional inspection/replacement of the HECU. Analysis of failure data reported to NHTSA and provided by Hyundai in response to ODI's information request letter for PE13-033 identified 756 complaints and 1,683 warranty claims for 30,114 subject vehicles produced prior to June 1, 2010, resulting in a complaint rate of 25.1 incidents per thousand vehicles (IPTV) and a claim rate of 5.6 percent.The MY 2009 vehicles, with the longest exposure times, experienced the highest complaint (33.5 IPTV) and warranty (7.0 percent) rates.For the 45,639 subject vehicles produced after June 1, 2010, ODI identified 13 complaints and 34 warranty claims, resulting in a complaint rate of 0.3 IPTV and a warranty claim rate of 0.1 percent, indicating that the brake fluid corrosion concern had not progressed far enough to result in significant rates of brake system performance symptoms in those vehicles.This investigation is closed.ODI will continue to monitor complaints to evaluate the effectiveness of Hyundai's recall.The VOQs noted in the Failure Report are: 10569231, 10560898, 10560495, 10559360, 10558279, 10558264, 10556964, 10556631, 10556577, 10556322, 10554988, 10554802, 10554122, 10552958, 10551817, 10551157, 10551110, 10551092, 10550791, 10550773, 10550431, 10549750, 10549634, 10549629, 10549567, 10549402, 10549376, 10549270, 10549228, 10549186, 10549021, 10548903, 10548823, 10548791, 10548737, 10548722, 10548716, 10548705, 10546565, 10544803, 10543663, 10542962, 10541959, 10541741, 10538208, 10537934, 10536652, 105354

Odometer Fraud. The contact purchased a 2009 Hyundai Genesis. The contact discovered a mileage discrepancy after the purchase of the vehicle. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 121,000. It was later discovered through auto check that the mileage was 199,985.

NHTSA ID

11691818

Incident

Oct 6, 2025

Mileage

199,985 mi

Light on the dash showing "airbags" is lighting up for the first time since I've owned this vehicle. I remember there being a recall regarding a switch or something pertaining to the airbags sometime in the past, but not sure if this was the concern (airbag light on dash lighting up).

NHTSA ID

11680903

Incident

Aug 15, 2025

Front subframe is rotted out. And TPMS light is on.

NHTSA ID

11678918

Incident

Aug 6, 2025

Passenger side, rear brake line rusted to the point where brakes failed one morning. Brake fluid leaking from rusted brake line. Lost braking pressure while driving. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, independent shop Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No

NHTSA ID

11603033

Incident

Jul 1, 2024

The contact owns a 2009 Hyundai Genesis. The contact stated that while the vehicle was parked, she observed that the front driver’s and front passenger's headrests had deployed without impact. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage 69,000.

NHTSA ID

11584109

Incident

Apr 11, 2024

Mileage

69,000 mi

While driving the vehicle with approximately 113,200 miles on it, as the original owner, the car engine started to operate erratically. then the check engine light came on and then the check oil light came on and, after a short period of driving, the car stalled out and would not start up. This stalling out happened in a left turn lane of a very busy road. Two men in a vehicle that stopped behind me got out and pushed me off of the roadway about a block away from a dealer. The car was manually pushed into the dealership. The mechanic checked and the oil was full. The car is available, in my garage, for inspection upon request. The number 1 cylinder valve spring was broken and the engine jumped the timing on both sides with $2792.53 to $7,086.78 for parts plus labor to repair. At 86,283 miles, while driving in my village the number 3 intake valve spring broke and was repaired. At 51,574 miles, while driving on the interstate, the number 7 exhaust valve spring broke and was repaired. All three times the vehicle operated erratically. The car was in traffic each time this occurred and my safety and the safety of others were put at risk. I have all the receipts from all three breakdowns including the diagnosis. The engine is apart now and I have the parts list and labor costs from the dealership for the work that needs to be done. Initially I was told by the dealer that I needed to have all 32 valve springs and rocker arm assemblies replaced according to a Technical Service Bulletin. When I protested that they did not do that during the previous repairs the dealer said they would only replace the one that was damaged. That is why there are two parts estimates. I have them both. The check engine light came on just after the engine started to operate erratically and the check oil light came on shortly thereafter. I contacted the manufacturer and they said they could do nothing.

NHTSA ID

11577460

Incident

Sep 12, 2023

I was on the freeway and my car suddenly shut off completely.. engine, dashboard, lights EVERYTHING.. it was off for maybe 2 seconds and then the car Powered itself back up the car did not stop abruptly, so I was thankful for that. I didn’t panic or pull the wheel. I just continue straight and then thankfully it cut back on and then I got off the freeway as I was driving down the street not going more than 1015 miles my car cut off on me again it did the same exact thing everything just went off and then it cut back on mid drive and I have a four year-old toddler and I have been scared out of my life. Something is clearly wrong I need help please , no one can tell me what the problem is

NHTSA ID

11553724

Incident

Nov 5, 2023

The contact owns a 2009 Hyundai Genesis. The contact stated that while driving 70 MPH, the vehicle inadvertently lost motive power. The contact was able to coast to the shoulder of the road however, the vehicle failed to restart. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the ECM. The vehicle was repaired, but the failure reoccurred five additional times. The manufacturer was notified of the failure but was unable to provide any assistance. The failure mileage was 109,000.

NHTSA ID

11535534

Incident

Jul 15, 2018

Mileage

109,000 mi

The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or non‑certified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious injuries and fatalities. Please see attached announcement, provided by NHTSA, for more details.

The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts. These dangerous inflators have ruptured during deployment, posing a serious risk of injury or death due to metal fragments entering the vehicle cabin. To date, Hyundai is aware of three people who have died while driving a Hyundai vehicle with one of these substandard replacement airbag inflators that deployed in what likely would have been a survivable crash. NHTSA has issued a public advisory urging vehicle owners and service professionals to have vehicles inspected if there is reason to believe that a non-genuine replacement airbag may have been installed. Vehicles with salvage or rebuilt titles, prior airbag deployments, or unknown repair histories may present a higher risk. NHTSA strongly cautions against self-inspection by vehicle owners and recommends inspection by trained technicians.

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.

This TSB provides a procedure to diagnose and replace, if necessary, an automatic transmission with Incorrect Ratio DTC (transmission clutch slip in gear above limit) listed on Page 2.

This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side of the wiper blade, which could lead to poor wiping performance and/or possible scratching of the windshield glass. Follow the procedure in this bulletin to properly remove the windshield wiper blade protective cover on all new wiper blades.

This bulletin outlines the basic components of the BG Fuel Test Kit and the procedure to test the quality of the fuel during vehicle diagnosis. Poor fuel quality may lead to cold engine startability issues, hesitation at idle or during acceleration, and/or poor driveability. In addition, prolonged vehicle operation with poor quality fuel may result in damage to the fuel system and formation of engine deposits. The BG Fuel Test Kit can be used to determine the following aspects of the fuel: • Sediment / Water Contamination Inspection • Specific Gravity • Alcohol Content