2016 Volkswagen Tiguan

In August 2015, VW launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clock spring. VW’s recall indicated that debris entry into the steering wheel hub can result in the contamination and ultimately failure of the clock spring in 2010-2014 MY CC, Eos, GTI, Golf, Jetta, Jetta Sportwagen, Passat, and Tiguan models. The contamination of the clock spring by debris, such as human hair, can cause the flat ribbon cable to tear. This results in the loss of the electrical connection to the front driver air bag and any steering wheel mounted controls. The clock spring is designed so that the flat cable inside will break with minimum force to prevent it from impeding movement of the steering wheel. The loss of the electrical connection to the front driver air bag results in the immediate illumination of the air bag warning light and prevents the deployment of the front driver air bag in a collision of sufficient severity. A torn clock spring also causes audible grinding noises from the area of the steering wheel/driver air bag or steering column while steering. The failure of the clock spring does not impair vehicle control or drivability (steering, brakes, acceleration). In November 2017, the Office of Defects Investigation (ODI) opened Recall Query RQ17009 after receiving complaints that alleged the failure of the clock spring in the subject models. While the majority of these complaints involved vehicles excluded from the original recall, several complaints involved vehicles that had received the remedy for Recall 15V-483. On April 18, 2018, ODI upgraded the investigation to Engineering Analysis EA18003 after receiving additional complaints concerning the recall remedy and scope of Recall 15V-483. During the investigation, VW identified certain 2015-2018 MY vehicles that share a common steering wheel clock spring with the vehicles covered under Recall 15V-483.  VW began using a different clock spring design starting with the 2019 MY Jetta. This new part is not compatible with previous model years due to the communication properties between the clock spring and the vehicle, including the air bag control module. In October 2018, VW released Warranty Extensions AWA-18-18 and VWP-18-11, which established a 15-year, unlimited mileage coverage for the Steering Wheel Clock Spring for vehicles included in the scope of Recall 15V-483. For certain 2010-2018 MY vehicles outside of the recall scope, a 10-year, 120,000-mile coverage was given. Vehicles repaired under these warranty extensions receive replacement clock springs at no charge to the consumer. In early 2023, VW updated AWA-18-18 (now AWA-23-01) and VWP-18-11 to upgrade certain vehicles and model years from the 10-year, 120,000-mile coverage to the 15-year, unlimited mileage coverage option. These warranty extensions cover vehicles with recall remedy failures as well as vehicles outside of the Recall 15V-483 scope that exhibited similar failures. In view of the circumstances, including the high detectability of the subject failure and warranty extensions issued by VW, ODI is closing this Engineering Analysis. NHTSA reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Steering failure all of a sudden safety concern steering became very difficult the steering wheel became stiff and felt really unsafe. Red light for the steering turned on.

NHTSA ID

11771991

Incident

Sep 1, 2026

* Purchase Date: January 23, 2016 * Current Mileage: Approximately 71,500 miles For the past several months, my vehicle has experienced continuous engine oil loss. The oil level drops approximately one gallon every two months, and the engine oil warning light has illuminated on multiple occasions. Because of this recurring problem, I brought my vehicle to Volkswagen Glendale on April 23, 2026. After inspecting the vehicle at the Glendale dealership, I was informed that loose oil pan bolts were the cause of the oil loss. Based on this diagnosis, I took the vehicle to three different local auto repair shops for additional inspections. All three repair shops independently diagnosed the issue as being related to the engine and stated that if the engine is not replaced, the engine oil loss problem will not be resolved. I returned to Volkswagen Glendale on June 27, 2026. During this second visit, I was informed that the oil leak was coming from the oil pan area and that components including the oil pan, bolts, sealant, oil level sensor, and gaskets required repair. The technicians raised the vehicle and carefully inspected the entire underside. They reported that there was no visible engine oil leak and no evidence of oil escaping from the oil pan. I took the picture that there is no visible engine oil leak at the repair shop. I am deeply concerned that: * I am concerned about having to continuously add engine oil (1 gallon every two months) because the vehicle keeps losing oil. *I am concerned that the engine may seize due to low oil levels, which could cause the vehicle to break down while I am driving. Specifically, I request: Due to this engine problem and the ongoing engine oil loss issue, I respectfully request that the engine be replaced to resolve the problem and prevent potential safety risks. After reviewing the information above, could you please provide me with the claim number? I would appreciate your assistance. Thank you.

NHTSA ID

11749882

Incident

Feb 19, 2026

UNKNOWN INCIDENT. I had a 2016 VW Tiguan with just over 80k miles (approximately 80,200 mi). On 1/6/2026 about 10 min after driving home from the gym, I heard a small explosion from the garage where my car was parked. The garage was filled with smoke and large flames were visible from under the front end of the vehicle. We called 911 and tried to put it out with a fire extinguisher but it continued to re-ignite. The fire burned down our entire garage with all its contents and made it's way into the home completely destroying our laundry room and adjoining bathroom. I had no previous issues with the vehicle, no warnings or check engine lights.

NHTSA ID

11718115

Incident

Jan 6, 2026

The contact's friend owns a 2016 Volkswagen Tiguan. The contact stated that while driving at various speeds, the power steering assist failed with several unknown warning lights illuminated. The vehicle was taken to a dealer and a diagnostic test was performed. The diagnostic test showed that the vehicle and determined that the steering rack, wheel speed sensors, and engine cooling fans needed to be replaced. The contact's friend declined the repair, and the warning lights remained illuminated. The vehicle was then taken to an independent mechanic who discovered that coolant was leaking into the engine and discovered various engine leaks. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 88,000. The VIN was invalid.

NHTSA ID

11697115

Incident

Sep 28, 2023

Mileage

88,000 mi

I’ll be driving for 2-10 minutes and power steering cuts out. Wheel will jerk a little and alarm will sound with the alert light remaining red through remainder of drive. Sometimes it will not work at all while driving, but I’ve found the it usually works for the first few minutes until I speed up a little more.

NHTSA ID

11695657

Incident

Oct 18, 2025

My car has never been in an accident. One day while turning into my driveway, I heard a large clicking sound. Since then, my airbag malfunction light is on and my car horn does not sound/work. All steering wheel controls are broken. This has been an issue for about 6 months. I've been waiting on a recall impacting my specific VIN/year/make/model, however I am being informed that I will need to pay out of pocket to have this major safety concern taken care of. I will be taking this car to the dealership this week in hopes to have a repair quote that I will have to save a significant amount of money over an extended period of time to complete.

NHTSA ID

11694522

Incident

Jan 21, 2025

As I was driving on the Long Island Expressway at 50mph, there was a sudden VERY loud explosion that sounded like a gun shot. I thought perhaps a tire had blown out but then I heard air rushing by. My sunroof had spontaneously exploded!

NHTSA ID

11689263

Incident

Sep 23, 2025

Subject: Known Carbon Buildup Issue in 2016 Volkswagen Tiguan TSI – Request for Recall and Accountability To Whom It May Concern, I am writing to formally express my concern and request action regarding a well-documented and dangerous issue affecting Volkswagen TSI engines—specifically, severe carbon buildup. I am the current owner of a 2016 Volkswagen Tiguan TSI, which I purchased in April 2025 with approximately 84,000 miles on it. In June 2025, I had to have the intake manifold replaced due to carbon buildup—a repair that was still covered under warranty. However, shortly after, I was informed that the vehicle now requires a full engine decarb and replacement of all four fuel injectors, at a total cost of $3,296. This raises several serious concerns: •Carbon buildup this severe at such low mileage is not typical wear and tear. It indicates a design flaw in the TSI direct-injection engine. •My extended warranty provider refuses to cover the repair, citing that it is a maintenance issue—conveniently shifting the responsibility away from the manufacturer. •This type of engine failure can result in dangerous performance issues, including: •Sudden engine misfires •Loss of power while accelerating •Poor fuel economy •Stalling or hesitation while merging or turning •Catalytic converter damage •Potential long-term engine failure I am stunned that this is not considered a safety issue worthy of recall, especially given the number of reports online and in service centers regarding this exact problem. The symptoms of carbon buildup can easily result in on-road danger to the driver and others. What’s most disheartening is that Volkswagen has long been aware of this flaw, yet no recall or extended warranty has been offered for affected consumers. I previously owned a 2015 Passat and was a loyal VW owner—but now, as a single mother, I am expected to pay nearly $3,300 for a repair tied to poor engineering and design, not misuse or neglect.

NHTSA ID

11674768

Incident

Jul 19, 2025

Prevent Sporatic Misfire Faults.

Checking engine oil level.

Reprogramming Control Module process

Engine missfire diagnostic aid

Identifying and Mixing Volkswagen Engine Coolants

Safety Related Inquiry and Reporting