2012 Volkswagen Tiguan

In August 2015, VW launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clock spring. VW’s recall indicated that debris entry into the steering wheel hub can result in the contamination and ultimately failure of the clock spring in 2010-2014 MY CC, Eos, GTI, Golf, Jetta, Jetta Sportwagen, Passat, and Tiguan models. The contamination of the clock spring by debris, such as human hair, can cause the flat ribbon cable to tear. This results in the loss of the electrical connection to the front driver air bag and any steering wheel mounted controls. The clock spring is designed so that the flat cable inside will break with minimum force to prevent it from impeding movement of the steering wheel. The loss of the electrical connection to the front driver air bag results in the immediate illumination of the air bag warning light and prevents the deployment of the front driver air bag in a collision of sufficient severity. A torn clock spring also causes audible grinding noises from the area of the steering wheel/driver air bag or steering column while steering. The failure of the clock spring does not impair vehicle control or drivability (steering, brakes, acceleration). In November 2017, the Office of Defects Investigation (ODI) opened Recall Query RQ17009 after receiving complaints that alleged the failure of the clock spring in the subject models. While the majority of these complaints involved vehicles excluded from the original recall, several complaints involved vehicles that had received the remedy for Recall 15V-483. On April 18, 2018, ODI upgraded the investigation to Engineering Analysis EA18003 after receiving additional complaints concerning the recall remedy and scope of Recall 15V-483. During the investigation, VW identified certain 2015-2018 MY vehicles that share a common steering wheel clock spring with the vehicles covered under Recall 15V-483.  VW began using a different clock spring design starting with the 2019 MY Jetta. This new part is not compatible with previous model years due to the communication properties between the clock spring and the vehicle, including the air bag control module. In October 2018, VW released Warranty Extensions AWA-18-18 and VWP-18-11, which established a 15-year, unlimited mileage coverage for the Steering Wheel Clock Spring for vehicles included in the scope of Recall 15V-483. For certain 2010-2018 MY vehicles outside of the recall scope, a 10-year, 120,000-mile coverage was given. Vehicles repaired under these warranty extensions receive replacement clock springs at no charge to the consumer. In early 2023, VW updated AWA-18-18 (now AWA-23-01) and VWP-18-11 to upgrade certain vehicles and model years from the 10-year, 120,000-mile coverage to the 15-year, unlimited mileage coverage option. These warranty extensions cover vehicles with recall remedy failures as well as vehicles outside of the Recall 15V-483 scope that exhibited similar failures. In view of the circumstances, including the high detectability of the subject failure and warranty extensions issued by VW, ODI is closing this Engineering Analysis. NHTSA reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.

A couple of weeks now my steering wheel has been locking while I’m driving, sadly I thought it was because I needed to get my car serviced. This morning my steering wheel locked out of nowhere as I was turning and I almost ended up in a head on collision with another car while my kids were in the car. Then my brother did some research and sent me NHTSA link talking about the recalls. This is absolutely dangerous and I need to get reimbursed or something for my SUV doing this. It’s dangerous and can possibly kill someone.

NHTSA ID

11767290

Incident

Sep 27, 2026

Steering wheel gets locked up while driving; power steering fails. The red steering light turns on. This is a problem that happens to several Tiguans. There were no prior symptoms prior to failure. This is extremely dangerous and difficult to deal with while driving, especially on the freeway. please help.

NHTSA ID

11697066

Incident

Oct 6, 2025

I was driving the car and the steering wheel locked out of nowhere A red steering light came on the dashboard. I’ve never seen before

NHTSA ID

11683568

Incident

Aug 27, 2025

The contact owns a 2012 Volkswagen Tiguan. The contact stated that the vehicle was experiencing excessive oil consumption. Additionally, while driving at 65 MPH, the vehicle stalled. The contact was able to pull over to the side of the road. The vehicle was able to restart. The check engine, EPC, and TPMS warning lights were illuminated. The contact stated that the failure had been recurring while driving. The vehicle was taken to an independent mechanic, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was not notified of the failure. The failure mileage was approximately 135,000.

NHTSA ID

11682937

Incident

Jan 25, 2024

Mileage

135,000 mi

The clockspring has failed and there are recalls on similar models of Tiguans of the same year.

NHTSA ID

11653875

Incident

Aug 1, 2024

What component or system failed or malfunctioned, and is it available for inspection upon request? Defective Primary Engine Water Pump, yes. The original primary engine water pump system for a 2012 VW Tiguan 2.0 was replaced under the VW extended warranty in 2020 by an authorized dealer as a the result of the class action suit---please see Water Pump Class Action and Limited Warranty Extension bulletin issued by NHTSA. The replacement primary engine water pump system installed in 2020 has been found to be defective in March 2025 and the primary engine water pump requires replacement a second time -- without a warranty extension and less than five years from the date of service of the replacement under the Water Pump Class Action and Limited Warranty Extension issued by NHTSA. VW is still using defective primary engine water pump systems throughout the warranty period----does the NHTSA have any evidence that VW made modifications to the primary engine water pump system after the bulletin issued by NHTSA? Was it a requirement that VW modify the primary engine water pump system? I have been informed that no changes were made to the VW primary engine water pump that was used to replace defective primary engine water pump systems as a result of the Water Pump Class Action and Limited Warranty Extension. How was your safety or the safety of others put at risk? A defective primary engine water pump is a safety risk because it creates a potential for engine failure. Has the problem been reproduced or confirmed by a dealer or independent service center? The problem has been confirmed by an authorized VW dealer. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? UNKNOWN Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Indicator warning lights on dash--RED.

NHTSA ID

11648866

Incident

Mar 13, 2025

The engine could not be started after 13 years and 103,000+ miles. I had to get the car towed to my garage at night, after several prior trips same day. There were no check engine lights or any other indicators. The engine had newer spark plugs, ignition coils and pcv valve installed as well as chain checked a year prior to this. Had a mobile mechanic come by and inspect the car. He determined that the engine has lost compression and that the oil was low. The spark plugs were soaked in gas because engine could not properly compress and ignite the fuel. After adding oil the problem did not go away. He performed the compression test and confirmed his suspicion about engine not being able to compress the fuel. The most likely cause was the timing chain issue but he could not inspect the chain to confirm due to difficulty of doing it. The engine valves were not moving as expected as well. He could not read any meaningful codes from the car computer. There were no electrical or starter issues, just that engine has lost compression. The car had regular oil changes, break fluid changes and tire rotations. Just two weeks prior to car breaking down it passed emissions test. As far as I know, these vehicles have had issues with timing chains stretching out and VW has sent out a recall about these issues a while back. I don't believe my vehicle was under this recall. This vehicle has had all recalls addressed. At this point I will have to get rid of the car because the cost to fix this issue will be the same or more than the car is worth.

NHTSA ID

11633465

Incident

Dec 23, 2024

The contact owns a 2012 Volkswagen Tiguan. The contact stated while driving at approximately 35 MPH, the vehicle lost motive power and stalled. The contact was able to coast to the side of the road to restart the vehicle. The contact stated that several unknown warning lights were illuminated. The contact stated that the failure was intermittent and had occurred at various speeds. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 14V441000 (Fuel System, Gasoline). The manufacturer was informed of the failure. The failure mileage was approximately 143,000.

NHTSA ID

11608994

Incident

Jul 30, 2024

Mileage

143,000 mi

Prevent Sporatic Misfire Faults.

Reprogramming Control Module process

Engine missfire diagnostic aid

Identifying and Mixing Volkswagen Engine Coolants

Adhesive to bond sensor to Radiator.

Safety Related Inquiry and Reporting