2011 Volkswagen Tiguan

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.

Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.

My 2011 Volkswagen Tiguan was included in the Volkswagen clock spring safety recall. According to Volkswagen’s records, the recall repair was completed in 2016. The same defect has now reoccurred: the steering wheel controls, horn, and driver airbag are disabled again due to a failed clock spring. This is a reoccurring safety defect that directly affects the airbag system. The airbag warning light is on, and the driver airbag is currently non‑functional. I contacted Volkswagen corporate, and they confirmed that my VIN was included in the original recall and that the repair was performed. However, they are refusing to repair the defect again, stating that the recall is “closed” and the warranty extension has expired, even though the original recall remedy has failed and the safety defect has returned. Volkswagen also declined to provide a written denial. I am reporting this because the recall remedy appears to be inadequate, and the safety defect has not been resolved. The vehicle is unsafe to drive with the airbag disabled. The clock spring failure disables the airbag, horn, and steering‑wheel controls. The defect matches the symptoms described in the original recall. The failure occurred without any modification or damage to the steering wheel area. Volkswagen refuses to authorize a second repair despite the safety risk.

NHTSA ID

11712684

Incident

Jan 22, 2026

⁠The contact owns a 2011 Volkswagen Tiguan. The contact stated that while driving at 45 MPH, the engine stalled. After several attempts, the vehicle started however the vehicle drove slowly. The contact was able to pull to the side of the road. The vehicle was towed to the contact's residence and then towed to an independent mechanic where it was diagnosed that the engine failed. The manufacturer was notified of the failure. The contact was informed that the fuel pump was previously repaired. The vehicle was towed back to the residence and was not repaired. The contact mentioned that the horn and the instrument panel failed to function. The failure mileage was unknown. 137,000.

NHTSA ID

11632723

Incident

Aug 5, 2024

Mileage

137,000 mi

My Tiguan randomly shuts down or stalls while driving. I have come very close to accidents because It is in the middle of the road where I can't pull over, people coming around a curve behind me that may not have time to brake, specifically RV's and Semi-trucks. It is terrifying. I have maintained my vehicle meticulously and payed thousands in repairs only to be told by dealerships and VW corporate offices that there is nothing they will or can do and that there are no recalls and out of warranty. However...There WAS one in 2014 citing DANGEROUS to drive because of stalling. According to KBB. I don't know what else to do and I am not able to get a new vehicle.

NHTSA ID

11604747

Incident

Jul 26, 2024

This vehicle has already been recalled for faulty clock spring, which renders the airbag inoperable but the clock spring has failed again. This is a common issue VW needs to fix.

NHTSA ID

11488240

Incident

Oct 6, 2022

Clock spring in steering column has snapped. Because if a previous recall, this part is covered under warranty. New clock spring is on back order without any ETA when one will be available. Car horn is disabled and airbags will not deploy if an accident does occur. State safety inspection can not/will not pass as a result of this broken part. I do not have the luxury of renting a car until this part comes in to the US. Per various forums, possibly 6000-8000 clock springs on back order

NHTSA ID

11464124

Incident

Jan 24, 2022

The clock spring is broken in my 2011 VW Tiguan at 114,000 miles. Therefore, the driver airbag on the steering wheel does not work. Therefore, there is a safety issue if one drives the car. The problem is not fixed because there are no parts to fix it. Apparently there is a chip in the clock spring and there are no chips available to manufacture replacement springs. I was told that the part has been on back order since October 2021. I was told that the part may be available in July 2022, but there are no guarantees. Until a replacement part is available, the vehicle is potentially unsafe to drive.

NHTSA ID

11463294

Incident

Apr 13, 2022

Timeing chain skipped a tooth destroyig the engine completely. Yes its available for inspection upon request. The problem has been settled in a class action lawsuit but no recall has been issued for ea888 engines between 2008 and 2013

NHTSA ID

11433271

Incident

Sep 9, 2021

The driver side rear coil spring snapped at 103,000 miles. We just returned from a road trip and are lucky it occurred in the driveway. There was a loud bang when it occurred. The car had to be towed for replacement of both coil springs.

NHTSA ID

11430373

Incident

Aug 22, 2021

This is a notice for software changes with the ODIS diagnostic program to correct the communication during vehicle programming function: A software fix is needed to correct the issue: DA 0019 - Hotfix 12-V battery test(s) – No battery diagnosis - Inconclusive test result.

Oil Consumption Measurement and Electronic Oil Consumption Measurement

Lubricating engine components before reassembly.

Instruction, how to lubicate engine before initial start.

Inquiries

Volkswagen Engine Oil Standards