2016 Lexus RX

I am reporting a safety issue with a 2016 Lexus RX350, VIN [XXX], with about 60,000 miles. The vehicle is registered in [XXX] and was being driven to [XXX] when it suddenly overheated on XXX near [XXX]. The warning lights appeared while the vehicle was traveling at highway speed. The driver immediately took the first available exit within about one minute. The failed system appears to be the engine cooling system, specifically the water pump. The vehicle is currently at Kendall Lexus of Eugene and should be available for inspection. This failure created a safety risk because it happened suddenly on a major highway. The driver had to exit quickly and the vehicle became disabled far from home. A sudden coolant-loss or overheating event at highway speed can leave drivers stranded in unsafe locations with very little warning. Kendall Lexus of Eugene inspected the vehicle. Their Service Manager stated in writing that the technician found a leaking water pump, misfires in every cylinder, and a 95% leak in cylinder #6 through the exhaust valves. She stated that the water pump failure caused the vehicle to lose coolant, overheat, and suffer internal engine damage requiring engine replacement. Lexus Customer Relations has been notified under Case #XXX. Whether Lexus corporate has physically inspected the vehicle is unknown. Before the incident, there were no known warning signs. The warning lights appeared five hours into the road trip when the overheating occurred. After exiting, the driver let the vehicle cool for 30 minutes, checked for visible leaks, and tried to continue only briefly around the block. The warning returned almost immediately, so the vehicle was towed. This vehicle has extensive Lexus dealership maintenance history. Lexus quoted about $20,000 for engine replacement. Lexus has issued TSB L-SB-0039-20 / NHTSA ID 10183269 regarding water pump leak inspection and diagnosis, but there appears to be no rec INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11751679

Incident

May 1, 2026

*Driver-side entry failure = primary access point compromised * Could trap occupants if internal handle fails or after an accident * Emergency responders rely on driver-side access first * This is not normal wear and tear—it’s a safety-related failure.

NHTSA ID

11733701

Incident

Apr 17, 2026

The electronic screen on dashboard that displays map, HVAC, etc. turns pink then black and disappears for several minutes. One then has no control over the various functions displayed on the screen. I've done a hard reset by disconnecting the battery for several minutes...to no avail. Thank you.

NHTSA ID

11695726

Incident

Aug 1, 2025

The contact owns a 2016 Lexus RX 350. While the contact was inside the building where she worked, the hazard lights were flashing unintendedly. When the contact arrived at the residence, the hazard lights were flashing again. The vehicle was not diagnosed or repaired. Additionally, the contact stated that the air bag warning light was illuminated. The contact stated that on a separate occasion, there was an abnormal vibrating sound coming from underneath the brake pedal. No warning lights were illuminated. The manufacturer was not made aware of the failure. The failure mileage was approximately 98,000.

NHTSA ID

11690010

Incident

Aug 30, 2025

Mileage

98,000 mi

Both sides of the black wheel guides have popped off causing damage to the front bumper and wheel fenders.

NHTSA ID

11687797

Incident

Sep 11, 2025

As I was driving southbound on I five in the state of Washington in Stanwood area 8:00 AM my sunroof exploded, causing me to swerve into other lanes and a distraction for other drivers There were no warnings. The sunroof was in a close position, not being used. The vehicle went into repair today being August 1. We did take pictures. Had there been cars directly on either side of me accident would have occurred.

NHTSA ID

11678000

Incident

Jul 29, 2025

I was driving and pressed the button to close the sunshade on the panoramic sunroof when I heard this like a grinding noise. The cloth sunshade stopped moving. Then I heard a pop noise, and the sunshade came down, and it hit me more on the back of the neck. Then I heard something fall on the floor behind me in the back seat area. I couldn't pull over right away, stopped at a store, and there was a black, plastic and metal piece that was on the floor in back. The sunshade itself was partly hanging off the ceiling where it came from. It didn't hurt but of course it startled me. This happened on Friday going to work 7/18/2025. I haven't used the sunroof for a while because it has been too hot but Friday I wanted some natural air, and opened it up. Researching I see that it is supposed to be all one piece, and everything which includes the entire panoramic sunroof to be replaced which is close to $3,000. I found online that a lot of people have the same problem for years 16-22 on the RX. I found out where the dealers are telling people excessive heat melts the glue holding these adapters in place, and it eventually give way and break. Most people including me park outside, I don't have a garage, and it's summer, this is defective, and it should be covered my Lexus. Since it just happened yesterday, the vehicle wasn't inspected by nobody, there were no warning signs that this was happening either. The safety issue is when it hit me on the back of the neck while I was driving. Thank you for your time.

NHTSA ID

11674688

Incident

Jul 18, 2025

Timing Cover gasket leak. Apparently this is very common problem with 2016 Lexus RX 350 due to a bad design by Lexus. Lexus is quoting ~7000 to fix

NHTSA ID

11667776

Incident

Feb 1, 2025

Some 2005 – 2026 Lexus vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Service Bulletin is to provide general guidelines and procedures for odor remediation. This Service Bulletin provides a guide on how to prepare and treat the interior of the vehicle for odor remediation. Refer to the applicable model and model year Repair Manuals and the EPA (Environmental Protection Agency) website for the most up-to-date safety and precautionary guidelines. This Service Bulletin is to provide a general overview and direction for the odor remediation process.

The air conditioning dye injection tool kit has been developed to aid in identifying the location of air conditioning refrigerant leaks. The procedures outlined in this Service Bulletin aid in locating, inspecting, and repairing refrigerant leaks.

Some 2010 – 2026 model year Lexus vehicles may exhibit paint stains after the removal of Rapgard™. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard™. The wrinkles may trap water and cause the paint to stain from the trapped moisture, especially on horizontal surfaces such as the hood, roof, and trunk.

Some 2010 – 2026 model year Lexus vehicles may exhibit paint stains after the removal of Rapgard™. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard™. The wrinkles may trap water and cause the paint to stain from the trapped moisture, especially on horizontal surfaces such as the hood, roof, and trunk.

Some 2005 – 2024 Lexus vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Service Bulletin is to provide general guidelines and procedures for odor remediation. This Service Bulletin provides a guide on how to prepare and treat the interior of the vehicle for odor remediation. Refer to the applicable model and model year Repair Manuals and the EPA (Environmental Protection Agency) website for the most up-to-date safety and precautionary guidelines. This Service Bulletin is to provide a general overview and direction for the odor remediation process.

Some 2005 – 2024 Lexus vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Service Bulletin is to provide general guidelines and procedures for odor remediation. This Service Bulletin provides a guide on how to prepare and treat the interior of the vehicle for odor remediation. Refer to the applicable model and model year Repair Manuals and the EPA (Environmental Protection Agency) website for the most up-to-date safety and precautionary guidelines. This Service Bulletin is to provide a general overview and direction for the odor remediation process.