2019 MINI Cooper S

Starter started smoking at start up! And clutch failure at traffic light!!!! No accident occurred because of experienced driver!

NHTSA ID

11737373

Incident

May 10, 2026

The contact owns a 2019 Mini Cooper S. The contact stated that while driving at an undisclosed speed, the contact noticed that a rock had hit the driver's side of the windshield due to construction work on a local highway. The contact stated that the passenger's side of the windshield was also hit by a rock while driving. The contact stated that the driver's side of the windshield sustained a minor fracture; however, the passenger's side of the windshield was severely damaged. An unknown dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 81,485. The VIN was not available.

NHTSA ID

11679180

Incident

Aug 7, 2025

Mileage

81,485 mi

Loss of power steering on startup or at stop light. A message pops up indicating that the Dynamic Stability Control is re-initializing and that steering may become difficult: Drive carefully. The warning message usually appears shortly after the failure. In fact, the steering gets so stiff, that my wife can barely turn corners. The problem comes and goes unexpectedly. This is my wife's car, and it has happened to her on several other occasions. Sometimes we can reset by restarting the car, but that isn't reliable. We put the car out of ECO mode into Sport mode, so that the engine does not stop at stop lights, but the engine sometimes stops anyway. When it happened at a stop light today, we tried several restarts, but the steering remained out. Steering is worse at low speeds. Today, we stopped at a light. My wife was driving. The engine stopped and restarted, and the error message appeared. She had difficulty steering into a parking lot where I swapped places with her. I drove her home. It was difficult for me to steer around corners after today's lock up, but I drove the car to a local BMW-Mini mechanic with whom I had discussed the problem, but it never appeared at his shop. Today, we tried starting at the shop and the difficult steering persisted without an error message. He ran a quick scan indicating that some modules in the steering column were not operating properly. He said the modules were not available for replacement, and that the entire steering column might need to be replaced. Unfortunately, he was booked up until Friday. I drove home and let the car sit in the garage for a couple of hours. I started it while writing this to try to more accurately reproduce the warning messages. However, no messages appeared and the car steered easily. Clearly, sudden loss of power steering poses a danger for my family and others on the road. I've looked on the internet and discovered that others have experienced similar problems with steering in Mini Coopers.

NHTSA ID

11663212

Incident

May 27, 2025

The contact's daughter owns a 2019 Mini Cooper S Clubman. The contact stated that while his daughter was driving at an undisclosed speed, she depressed the brake pedal, but the rear driver's side brake light failed to illuminate. The contact stated that he was driving behind his daughter when he noticed the failure. The vehicle was taken to an independent mechanic, and the rear driver's side brake light bulb was replaced; however, the failure persisted. The mechanic referred the contact to the dealer for assistance. Additionally, the contact stated that the vehicle failed to start. The vehicle was jumpstarted by AAA. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist unless NHTSA required that they do so. The failure mileage was unknown.

NHTSA ID

11571447

Incident

Feb 10, 2024

175 MILES ON 2019 MINI S COUNTRYMAN. TRAVELING AT HIGHWAY SPEED. DRIVETRAIN MALFUNCTION INDICATOR CAME ON, CAR SHUDDERED REPEATEDLY AND DECELERATED RAPIDLY TO APPROX. 20 MPH IN 60 ZONE. CREATED INSTANT HAZARD TO MYSELF AS MULTIPLE LANES OF FASTER MOVING TRAFFIC NEEDED TO BE CROSSED TO REACH SAFETY AND NO WARNING TO TAILING VEHICLE.

NHTSA ID

11165237

Incident

Jan 4, 2019

Mileage

175 mi

During inspection and/or diagnosis there is noticeable dirt/grease buildup on the axles near the inner and/or outer CV boots.

MINI electrical systems have continued to develop over the past few years. As a result, the demand on the batteries has increased. Breakdowns due to an empty battery or problems in the vehicles electrical system can have various causes, most of which are not due to the battery itself. For this reason, a battery replacement will permanently eliminate the problem only in the rarest of cases. The energy diagnosis test module helps to localize these causes. This document covers important information for the dealer on how to handle “discharged battery” complaints. Without performing the energy diagnosis test plan, the root cause of a discharged battery cannot be identified. In order to properly repair the vehicle the first time, it is very important that the diagnostic test plan is performed to completion; with all results taken into consideration.

?BMW AG has issued a Delivery Stop: REPLACE CHARGE AIR LINE.

?The panoramic roof sunblind does not close, or jams while closing.

Upon opening and closing the tailgate, a creaking/groaning sound can be heard from tailgate actuator.

Oscillations in the electric drive can occur. As a result, the 12 V positive battery cable may rub against the battery box cover.