1999 Newmar Dutch Star

WHILE ON A DOWNGRADE WITH THE ENGINE BRAKE ENGAGED AND IN 4TH GEAR, AT ABOUT 1900 RPM, THE SIDE MOUNTED FAN EXPLODED SENDING PLASTIC AND METAL PARTS OUT THE REAR OF THE MOTORHOME SHOWERING THE VEHICLE BEING TOWED AND ANOTHER VEHICLE FOLLOWING BEHIND. UPON INSPECTION THE FAN, WHICH IS DRIVEN BY A HYDRAULIC PUMP, WAS SUPPOSED TO BE ATTACHED BY TWO BOLTS TO A CROSS BAR BETWEEN THE RADIATOR AND THE ENGINE. THE BOLT HOLES IN THE HYDRAULIC PUMP WERE ELONGATED AND BOTH BOLTS HAD SHEARED OFF ALLOWING THE PUMP TO FALL DOWN WHICH RESULTED IN THE FAN BLADES HITTING THE CHASSIS FRAME AND CAUSING THE FAN TO BOUNCE AROUND THE COMPARTMENT HITTING THE RADIATOR AND PIPING AND THE INTERCOOLER PIPING. THIS HYDRAULIC SYSTEM IS ALSO PART OF THE POWER STEERING SYSTEM. UPON BEING TOWED BACK TO RAPID CITY, SD THERE WAS ANOTHER DUTCHSTAR (A 2000) AT THE FREIGHTLINER DEALER WITH THE SAME FAILURE. REPLACEMENT PARTS CONSISTED OF A HYDRAULIC DRIVE MOTOR, RADIATOR AND INTERCOOLER PLUS ALL THE REPLACEMENT FLUIDS FOR BOTH. I RETAINED THE HYDRAULIC DRIVE MOTOR IF NEEDED. IF THE FAN HAD SEVERED THE HYDRAULIC LINE THAT WOULD HAVE DISABLED THE STEERING SYSTEM WITH LOSS OF THE ABILITY TO STEER. ALSO IF THERE WERE NOT A VEHICLE BEING TOWED THAT TOOK THE BLOW OF MOST OF THE PARTS COMING OFF THE ENGINE THE VEHICLE BEING DRIVEN AND FOLLOWING BEHIND COULD HAVE RECEIVED SIGNIFICANT DAMAGE AND POSSIBLE RESULTED IN AN ACCIDENT.

NHTSA ID

11233258

Incident

Oct 9, 2015

Mileage

82,000 mi

HAD BAD FUEL LEAK CAUSED BY USE OF ULTRA LOW SULFER DIESEL FUEL.(ULDF). REPLACED FUEL TRANSFER (LIFT) PUMP P/N 4935007 OLD PUMPWAS AVAILABLE. *AK

NHTSA ID

10192968

Incident

May 17, 2007

Mileage

47,305 mi

TL*THE CONTACT OWNS A 1999 NEWMAR DUTCH STAR. THE CONTACT TOOK THE VEHICLE TO THE SERVICE CENTER FOR REGULAR PREVENTIVE MAINTENANCE, AND ALSO BECAUSE HE NOTICED THE SHUT OFF SWITCH FOR THE ELECTRICAL SYSTEM MALFUNCTIONED. THE SERVICE CENTER STATED THAT A FIRE PREVIOUSLY OCCURRED BECAUSE THE WIRING MELTED. THE CONTACT DID NOT SMELL ANYTHING BURNING NOR DID HE SEE ANY FLAMES. HE DID NOT KNOW WHEN THE FIRE OCCURRED. THE CURRENT AND FAILURE MILEAGES WERE 70,000. *AK THE CONSUMER STATED THE DAMAGE WAS LOCATED AT THE REAR COMPARTMENT. UPDATED 05/21/07. *JB

NHTSA ID

10189367

Incident

Apr 20, 2007

Mileage

70,000 mi

DT*: THE CONTACT STATED WHILE DRIVING 50 MPH ON WET ROADS IN THE RAIN, MOISTURE WAS PICKED UP THROUGH THE INTAKE MANIFOLD. THE VEHICLE PARTIALLY LOST POWER, BUT KEPT MOVING. THE VEHICLE WAS NOT SEEN BY A DEALER. PRIOR TO THIS INCIDENT, THE AIR INTAKE TUBE HAD BEEN REPLACED BY A SERVICE DEALER DUE TO THE SAME ISSUE, BUT THE PROBLEMS PERSISTED. THE MANUFACTURER WAS CONTACTED, WHO STATED THAT THE CONTACT HAD THE MOST UP TO DATE FIX FOR THIS PROBLEM, AND THAT IT SHOULD NOT HAVE RECURRED A SECOND TIME.

NHTSA ID

10175590

Incident

Sep 17, 2006

Mileage

39,200 mi

DRIVING ON I-90 IN SOME RAINY WEATHER, ERROR CODE LIGHT CAME ON. I STOPPED CHECKED ALL FLUID LEVELS & CONTINUED ON. A FEW HOURS LATER THE ENGINE BEGAN TO INCREASE IN SPEED ON ITS OWN .RPM'S WERE AT 2000 & THE COACH WAS ALMOST IMPOSSIBLE TO STOP. THE CHASSIS CONNECTOR ( CONNECTS COACH TO ENGINE AND ELECTRONIC CONTROL MODULE) FILLED WITH WATER AND CAUSED SHORTS,CROSSES,AND GROUNDS IN THE WIRING AND CAUSED THE MOTORHOME TO INCREASE IN SPEED ON ITS OWN. THE BRAKES WERE HOT AND SMOKING WHEN WE FINALLY GOT STOPPED. TECHNICIAN PULLED CONNECTOR APART, USED COMPRESSED AIR TO REMOVE THE WATER & A CONTACT CLEANER TO CLEAN THE PROBES & CONTACTS IN THE CONNECTOR. CONNECTOR WAS PLUGGED BACK TOGETHER, ALL SHORTS, GROUNDS, AND CROSSES WERE GONE. TECHNICIAN CLEARED ALL ERROR CODES, PUT SILICONE ON CONNECTOR TO KEEP WATER OUT UNTIL CONNECTOR CAN BE REPLACED. UPON LEAVING THE SHOP TRANSMISSION WOULD NOT SHIFT UP UNTIL RPM'S WERE AT 2000. IT WILL NOT SHIFT INTO 6TH UNLESS IT IS DONE MANUALLY. *NM

NHTSA ID

10138940

Incident

Sep 28, 2005

Mileage

69,199 mi

DT: CONSUMER RECEIVED A RECALL FOR THE FRONT TIRES. BEFORE RECEIVING THE RECALL CONSUMER ROTATED THE TIRES ,TAKING THE TWO FRONT TIRES OFF AND PUTTING THEM ON THE BACK INNER REAR OF THE VEHICLE. THE RECALL LETTER STATED THAT DEALER WOULD ONLY REPLACE THE TWO FRONT TIRES AND THEY DID. BUT THOSE WERE NOT THE ORIGINAL FRONT TIRES, AND BECAUSE THEY HAD BEEN ROTATED AND PUT T ON THE BACK, DEALER WOULDN'T REPLACE THEM IN THE RECALL. THERE WERE THREE DIFFERENT TIRE BLOW OUTS. THE FIRST ONE OCCURRED BEFORE THE RECALL. CONSUMER HAD TO FIND THAT SIZE TIRE SO HE CALLED THE MANUFACTURER, AND THEY SAID TO PUT THE RECALL SIZE ON THE TIRES. MANUFACTURER REIMBURSE CONSUMER FOR THAT TIRE. THE TIRE WAS LOCATED ORIGINALLY ON THE FRONT, BUT IT WAS ROTATED TO INNER REAR AT THE TIME OF THE BLOW OUT. THE SECOND TIME THE TIRE WAS LOCATED ON THE INNER REAR AND IT WAS ROTATED FROM THE FRONT, BUT IT WAS NOT AN ORIGINAL TIRE. IT HAD BEEN ON THE FRONT ABOUT 1500 MILES AFTER IT GOT ROTATED. THE THIRD TIME THE TIRE HAD BEEN ON THE FRONT AT SOME POINT. ALL TOGETHER 3 OF THE 4 TIRES BLEW OUT. ONE OF THE ORIGINAL FRONT TIRES GOT MOVED TO THE INNER REAR, AND IT WAS THE FIRST OF THE THREE BLOW OUTS. THE OTHER ORIGINAL FRONT TIRE WAS USED AS A SPARE TIRE AND IS CURRENTLY LOCATED ON THE INNER REAR.*AK

NHTSA ID

10129481

Incident

Apr 1, 2004

RECALL 04V037000 CONCERNING NEWMAR TIRES. DEALER WAS UNABLE TO HONOR RECALL BECAUSE NO PART WAS AVAILABLE SINCE JULY 31, 2004. *AK

NHTSA ID

10089232

Incident

Jul 1, 2004

BOTH FRONT WINDSHIELDS WORKED THEMSELVES OUT OF THE RUBBER GASKET AROUND THE WINDSHIELDS. CONSUMER HAS A CONCERN THAT THE WINDSHIELDS MAY NOT STAY PROPERLY IN PLACE WHILE DRIVING AT HIGH SPEED AND/OR IN INCLEMENT CONDITIONS. MANUFACTURER WAS NOTIFIED. *AK THE RV WAS TAKEN TO A GLASS COMPANY WHO INDICATED THAT THE GLASS WAS TOO LARGE FOR THE OPENING AND REFUSE TO ATTEMPT REPAIR. ANOTHER GLASS COMPANY STATED THAT THE CURVATURE OF THE GLASS DIDN'T MATCH THE CURVATURE OF THE BODY. THEY ALSO REFUSED TO REPAIR THE GLASS. THE MANUFACTURER WILL ONLY PERFORM NO WARRANTY WORK AT THE PLANT DURING WINTER MONTHS (JAN, FEB, MARCH). THE CONSUMER BELIEVES THIS PROBLEM IS A DESIGN FLAW. *NM

NHTSA ID

10081832

Incident

Jul 28, 2003

Mileage

24,000 mi

If the coach's HWH leveling system has intermittent issues when operating, check for corrosion or loose mounting bolts. Torque the mounting bolts (if needed) to 30 ft. pounds. A ground cable may also be installed to improve the overall grounding of the HWH pump assembly.

NEWMAR CORPORATION HAS DECIDED THAT A DEFECT RELATING TO MOTOR VEHICLE SAFETY EXISTS IN SPECIFIC MOTOR HOMES BUILT ON SPARTAN CHASSIS. THIS RECALL IS THE RESULT OF INFORMATION PROVIDED TO NEWMAR BY SPARTAN MOTORS. NHTSA # 15V 829 TC # 2015-587 THE STEERING GEAR MOUNTING BRACKET MAY CRACK AND BREAK, RESULTING IN A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH CAUSING INJURY AND/OR DAMAGE TO PROPERTY.