2011 Chevrolet Cruze

NHTSA opened AQ12-002 to determine whether Chapman Chevrolet of Philadelphia, Pennsylvania complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C.Chapter 301 (Safety Act) and its implementing regulations.The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with Federal Motor Vehicle Safety Standards and, in turn, that a dealer not sell a new vehicle subject to a recall unless the recall remedy has been performed (49 U.S.C. ? 30120(i)). NHTSA issued an information request (IR) letter to Chapman Chevrolet on October 16, 2012.Chapman Chevrolet responded to this request on November 8, 2012.To gather additional information, NHTSA mailed an IR letter to General Motors LLC (GM) on February 25, 2013.GM responded to this request on April 1, 2013.NHTSA then issued a second IR letter to Chapman Chevrolet on July 2, 2013.Chapman Chevrolet supplied their response on July 30, 2013. NHTSA?s investigation indicated that Chapman Chevrolet sold and delivered 23 recalled vehicles that did not have the recall remedy completed at the time the vehicles were delivered to the customers.NHTSA therefore concluded that Chapman Chevrolet was liable for civil penalties for violations of the Safety Act, pursuant to 49 U.S.C. ? 30165.Under a Settlement Agreement dated October 1, 2014, Chapman Chevrolet paid compromised civil penalties in the amount of $50,000.This Audit Query is closed.

In a June 21, 2012 letter to NHTSA, General Motors LLC. (GM) submitted a Defect Information Report (DIR) identifying a defect in approximately 413,148 model year (MY) 2011 through 2012 Chevrolet Cruze vehicles manufactured from October 2, 2009 through May 31, 2012 (Recall 12V-288). According to GM, engine oil change procedures can result in spilling or dripping of oil on the engine shield.Also, manual transmission vehicles with a completely worn clutch may cause hydraulic fluid to be expelled from the clutch housing vent hole.If oil, debris or the burning hydraulic fluid contacts hot engine or exhaust system surfaces, and the engine shield, the shield may ignite and burn, leading to a possible engine compartment or vehicle fire.GM and its engine shield supplier, Hanwha, modified the engine shield to address factors that may contribute to engine compartment fire. The redesigned shields were completely implemented in production vehicles by June 2012.The Office of Defects Investigation (ODI) analyzed complaint data provided by GM as well as complaints submitted to ODI from consumers. In total, there were 25 unique Chevrolet Cruze reports indicating hot surface ignition due to engine oil or hydraulic fluid contacting hot manifold, exhaust surfaces and the engine shield.Four additional fires were identified that resulted from other or unknown causes, including 1 attributed to a missing oil filler cap.Three fires of unknown cause all involved vehicles equipped with 1.4L L4 turbocharged engines.ODI will continue to monitor field experience in Cruze vehicles equipped with that engine.Owners of the recalled vehicles are notified to take their vehicle to a GM dealer, who will modify the engine shield to prevent oil fluids from contacting the shield.Also, on vehicles with a manual transmission, dealers are to apply a protective tape to the electronic power steering wire harness to prevent any incidents related to this issue. This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.): 10456338, 10453754, 10450556, 10446718.

i’m unsure if the person i bought this vehicle from had the codes wiped before selling to me, but there were NO lights on dash for 3 days after minimal driving only to work and back, then all of a sudden the check engine light came on, and in the info box it would pop up saying “service stability system” - i took to o’reiley’s to see what it was for, apparently it was the ECM (electronic computer module) which essentially controls like everything. days go by i don’t do anything more about it and drive as usual to work, and it starts overheating, and smoking like crazy, but doesn’t say it’s hot on my dash, so i had no idea how hot it got or anything. i got to work, worked my shift, and went to put coolant in before returning home- just to find that it was full and i didn’t need to put any in. weird, right? ok well on my way home i’m going about 55mph on the highway and it suddenly just wouldn’t let me accelerate anymore and behaved as if i ran out of gas but i had over half a tank. when i came to a stop i turned the car off, and tried to turn it back on when it wouldn’t even turn over. i sat about 15 mins on the side of the highway before it actually started and i drove home. a week goes by, and now this ecm is effecting more and more- driving on the highway/streets it’s shifting really hard, immediately following that, my speedometer and rpm meter fall to “0” on the dash but the vehicle is still driving and the message pops up about the service stability system. i replaced my tire and now it’s telling me to service airbag system and the abs light is stuck on, as well as traction control and it’s just so weird. i just don’t feel safe in this car and after looking it up, apparently everyone with the make and model have very similar problems, but specifically searching by my VIN- apparently there’s no recalls and it’s just extremely frustrating and i don’t know what to do. if i fix the ECM will all these issues be resolved or will i waste $600-$800 replacing it?

NHTSA ID

11745175

Incident

Jun 18, 2026

I purchased my car in 2020 and have had this issue recently come up. I have coolant that is vanishing from my car but not dripping to the floor. I've learned since then that there was a recall on my car for my water pump which causes this exact issue which has caused a related check engine light to appear. It seems unfair to me that there's a recall on my car that was taken away after one year despite it still not being replaced, and purchasing my car not knowing of this recall not being done and the window closing I feel should be rectified. I will be notifying GM about this matter as well. Thank you for your time and consideration on this matter

NHTSA ID

11740259

Incident

Mar 18, 2020

Odometer Fraud. The contact purchased a 2011 Chevrolet Cruze. It was discovered that there was a mileage discrepancy. The vehicle was a private in April 12th 2026. At the time of purchase, the vehicle mileage was 135,000 The contact stated that the next day when retrieving the title they noticed the mileage discrepancy. The contact spoke withe seller who then stated it was the same mileage they were told when they received the vehicle and had since replaced the engine therefore the engine mileage would not show at the DMV. The contact looked up the CarFax and saw the same mileage discrepancy with a mileage of over 300,000. When the contact took the vehicle to the dealer for an air bag recall, when the dealer confirmed mileage discrepancy. The contact sought out legal assistance.

NHTSA ID

11739476

Incident

Apr 13, 2026

Mileage

300,000 mi

The primary failure is a total loss of engine power and electrical systems while the vehicle is in motion. The dealership (Ray Skillman Southside Mitsubishi) has diagnosed this as a failed engine/body control computer system. The vehicle is currently located at the dealership's service center and is available for inspection. The vehicle has stalled/shut off completely while driving on four separate occasions. This resulted in an immediate loss of power steering and motive power, nearly causing collisions in traffic. A vehicle that loses all power without warning is a severe safety hazard to the driver, passengers, and other motorists on the road. Yes. The problem has been confirmed by the Ray Skillman service department. They have attempted to repair the issue 3 times without success and currently state that the vehicle is inoperable while they search for a used replacement computer component. The vehicle has been inspected multiple times by the Ray Skillman dealership technicians. To date, no representative from the manufacturer (General Motors) or insurance has performed an independent inspection, though a formal complaint has been initiated with the dealership's corporate management. There were no consistent warning lamps or symptoms prior to the failures. The vehicle would unexpectedly lose all power and shut down. These symptoms first appeared within the first 100 miles of ownership (purchased at 11,000 miles; current mileage approximately 11,800 The dealership has refused to provide a loaner vehicle and is currently attempting to resolve a recurring safety failure using a used/salvage electronic component rather than a certified new part, which I believe further compromises the safety of the vehicle.

NHTSA ID

11728928

Incident

Apr 1, 2026

The contact owns a 2011 Chevrolet Cruze. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the traction control warning light was illuminated. The check engine warning light illuminated shortly after the vehicle was purchased. The contact stated that the vehicle was shaking erratically, and the engine was abnormally loud. In addition, the RPM was elevated. The contact stated that the vehicle lost motive power and the engine seized. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The contact stated that there was electrical power to the vehicle; however, the engine failed to crank. The vehicle was towed back to the dealer where it was purchased, and diagnosed with a computer system failure. The contact was informed that the computer system needed to be replaced. In addition, the contact was informed that the computer system was being replaced with a used computer system. The vehicle was being repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 12,000.

NHTSA ID

11728916

Incident

Apr 1, 2026

Mileage

12,000 mi

The vehicle continues to overheat. The fan has been changed, the thermostat has been changed, the coolant reservoir has been changed, the cadilatic converter has been changed. Still running over hot. We continue to check oil and coolant levels, making sure they are where they need to be. Occasionally smoking.

NHTSA ID

11719712

Incident

Apr 1, 2024

The contact owns a 2011 Chevrolet Cruze. The contact stated that while driving 25-35 MPH, the vehicle failed to shift into the intended gear and then stalled. The contact was able to pull over to the side of the road. The vehicle failed to restart and was towed to the residence. There was no warning light illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 230,000.

NHTSA ID

11699756

Incident

Nov 17, 2025

Mileage

230,000 mi

When I start my vehicle and go over a certain speed it show service abs system it also makes a grinding sound when breaking before that speed is hit it also has a wobbleing steering wheel when breaking at high speeds also when accelerating it will sometimes show engine power reduced after presing the gas pedal

NHTSA ID

11697199

Incident

Jul 22, 2025

This preliminary information communicates information about how to determine if a wheel and tires size change is available.

This Preliminary information communicates the steps on how to save a GDS2 Session Log and upload to a Technical Assistance Case in CX Connect.

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

This Preliminary Information communication provides information to the technician about vehicles that have had multiple repair attempts that are being performed on customer’s vehicles that exhibit vibration conditions without utilizing the support of General Motors Technical Assistance Center. If valid vibration frequency or Road Force Variation data has been collected and a repair attempt does not correct the customer complaint, contact General Motors Technical Assistance Center for further support. For any vehicles that remains unrepaired after being at the dealer for three days or more and a related bulletin or PI is not found, contact General Motors Technical Assistance Center for further support.

This engineering informational bulletin provides process for a GM engineering study on curtain Takata Airbag Steering Wheel Modules and needs the used Takata airbags to be returned to GM.