2012 Chevrolet Cruze

General Motors (GM) has initiated a safety recall of 31,520 model year (MY) 2012 Buick Verano and Chevrolet Camaro, Cruze and Sonic vehicles to address a defect condition that could result in the primary or secondary stage air bag not deploying.These vehicles are a small percentage of all MY 2012 vehicles and were built on several specific production dates broadly ranging from December 1, 2011 to August 2, 2012 (see NHTSA recall 14V-300 for more information).Also, see attached additional report for more information.This investigation was opened to evaluate the scope of two uninfluenced safety recalls (NHTSA recalls 12V-522 and 13V-023) of certain MY 2012 Verano, Camaro, Cruze and Sonic vehicles.These recalls involved the same defect issue as the new recall mentioned above.Accordingly, this investigation is closed based on the recall actions GM is undertaking.

NHTSA opened AQ12-002 to determine whether Chapman Chevrolet of Philadelphia, Pennsylvania complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C.Chapter 301 (Safety Act) and its implementing regulations.The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with Federal Motor Vehicle Safety Standards and, in turn, that a dealer not sell a new vehicle subject to a recall unless the recall remedy has been performed (49 U.S.C. ? 30120(i)). NHTSA issued an information request (IR) letter to Chapman Chevrolet on October 16, 2012.Chapman Chevrolet responded to this request on November 8, 2012.To gather additional information, NHTSA mailed an IR letter to General Motors LLC (GM) on February 25, 2013.GM responded to this request on April 1, 2013.NHTSA then issued a second IR letter to Chapman Chevrolet on July 2, 2013.Chapman Chevrolet supplied their response on July 30, 2013. NHTSA?s investigation indicated that Chapman Chevrolet sold and delivered 23 recalled vehicles that did not have the recall remedy completed at the time the vehicles were delivered to the customers.NHTSA therefore concluded that Chapman Chevrolet was liable for civil penalties for violations of the Safety Act, pursuant to 49 U.S.C. ? 30165.Under a Settlement Agreement dated October 1, 2014, Chapman Chevrolet paid compromised civil penalties in the amount of $50,000.This Audit Query is closed.

In a June 21, 2012 letter to NHTSA, General Motors LLC. (GM) submitted a Defect Information Report (DIR) identifying a defect in approximately 413,148 model year (MY) 2011 through 2012 Chevrolet Cruze vehicles manufactured from October 2, 2009 through May 31, 2012 (Recall 12V-288). According to GM, engine oil change procedures can result in spilling or dripping of oil on the engine shield.Also, manual transmission vehicles with a completely worn clutch may cause hydraulic fluid to be expelled from the clutch housing vent hole.If oil, debris or the burning hydraulic fluid contacts hot engine or exhaust system surfaces, and the engine shield, the shield may ignite and burn, leading to a possible engine compartment or vehicle fire.GM and its engine shield supplier, Hanwha, modified the engine shield to address factors that may contribute to engine compartment fire. The redesigned shields were completely implemented in production vehicles by June 2012.The Office of Defects Investigation (ODI) analyzed complaint data provided by GM as well as complaints submitted to ODI from consumers. In total, there were 25 unique Chevrolet Cruze reports indicating hot surface ignition due to engine oil or hydraulic fluid contacting hot manifold, exhaust surfaces and the engine shield.Four additional fires were identified that resulted from other or unknown causes, including 1 attributed to a missing oil filler cap.Three fires of unknown cause all involved vehicles equipped with 1.4L L4 turbocharged engines.ODI will continue to monitor field experience in Cruze vehicles equipped with that engine.Owners of the recalled vehicles are notified to take their vehicle to a GM dealer, who will modify the engine shield to prevent oil fluids from contacting the shield.Also, on vehicles with a manual transmission, dealers are to apply a protective tape to the electronic power steering wire harness to prevent any incidents related to this issue. This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.): 10456338, 10453754, 10450556, 10446718.

Was driving and my car literally wouldn't go forward. Prior to I had an oil change and I would smell burning oil

NHTSA ID

11744364

Incident

Jun 15, 2026

My breaks do not work in reverse. Pump valve seems to be bad

NHTSA ID

11741926

Incident

May 28, 2026

Have called about this starting 2020. Had 137000. Also previous owner since 99000mi. Drive train & Turbo. Brake assist. Oil leaks, shutting off while driving. Now as of Saturday April 25 2026 Car shut off while driving and has been towed to dealership. Car deemed lemon by GM. In 2020 car to have been replaced I have all service contact numbers as well as my receipts. Car is a death trap. Do better Chevrolet & GM

NHTSA ID

11734134

Incident

Apr 25, 2026

The contact owns a 2012 Chevrolet Cruze. The contact stated that while driving at 40 MPH and accelerating over a speed bump, the key slid out of the ignition switch. An independent mechanic was contacted. The vehicle was taken to the independent mechanic, and it was determined that the ignition switch needed to be replaced. The vehicle was not repaired. The contact associated the failure with NHTSA Campaign Number: 16V502000 (ELECTRICAL SYSTEM, POWER TRAIN); however, the VIN was not included in the recall. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 74,522.

NHTSA ID

11733293

Incident

Mar 30, 2026

Mileage

74,522 mi

The contact owns a 2012 Chevrolet Cruze. The contact stated that while driving at an undisclosed speed, the engine started overheating, and a coolant leak was discovered. During the failure, the check engine warning light was displayed, and the message "A/C Off Due to High Engine Temp" was displayed even though the A/C was not activated. The temperature gauge was elevated, creating a risk that the engine might stall or catch on fire. The contact referenced NHTSA Campaign Number: 12V288000 ( ENGINE AND ENGINE COOLING); however, the VIN was not included in the recall repair. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 144,000.

NHTSA ID

11728123

Incident

Mar 21, 2026

Mileage

144,000 mi

Check engine light on Car smoking when driven and smells like burning oil

NHTSA ID

11711132

Incident

Jan 2, 2026

My son just purchased this car and nearly hit 100,000 miles. It started leaking oil in the engine area the valve cover gasket. It's drips all over the car causing it to smoke and smell.

NHTSA ID

11693383

Incident

Sep 3, 2025

Repetitive coolant leak repaired 5+ times over 9 years; incurred costs over $X,XXX. Coolant (toxic) leak causes burn off in the engine compartment and the vapors from this are transferred into the cabin, posing a risk to driver and passenger health.

NHTSA ID

11685443

Incident

Sep 6, 2025

This preliminary information communicates information about how to determine if a wheel and tires size change is available.

This Preliminary information communicates the steps on how to save a GDS2 Session Log and upload to a Technical Assistance Case in CX Connect.

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

This Preliminary Information communication provides information to the technician about vehicles that have had multiple repair attempts that are being performed on customer’s vehicles that exhibit vibration conditions without utilizing the support of General Motors Technical Assistance Center. If valid vibration frequency or Road Force Variation data has been collected and a repair attempt does not correct the customer complaint, contact General Motors Technical Assistance Center for further support. For any vehicles that remains unrepaired after being at the dealer for three days or more and a related bulletin or PI is not found, contact General Motors Technical Assistance Center for further support.

This engineering informational bulletin provides process for a GM engineering study on curtain Takata Airbag Steering Wheel Modules and needs the used Takata airbags to be returned to GM.