2019 Chevrolet Silverado 1500 Engine Problems

I was driving my 2019 Chevy Silverado TrailBoss with 81,000 miles at 65MPH on I-80 East in Omaha, NE, when 3 warning lights came on. The first was the Service Parking Brake. The second was Service ESC. The final was a flashing Check Engine light. My truck started backfiring/misfiring, making a loud ticking noise, and running extremely rough. I was trying to merge off the interstate, but it was running so rough that it made it very difficult to do so safely. Eventually, I just had to finish going where I was headed and park it in the lot. I did some research and called my local shop. They said to stop driving immediately and have it towed to them for inspection. They used a diagnostic tool and diagnosed the issue as a DFM lifter failure. But they could not fix it there and recommended I take it to a different shop. I had it towed again, and they did their own diagnostics and have the same idea, but without taking the engine completely apart, they can't tell for sure. They want to charge me $1,250.00 to inspect it further. I called the dealer where I purchased the truck back in 2019 and am working with them on next steps. The last shop quoted me $7,800 repair if it is indeed the DFM lifters. Based on what I know, this is a known issue with these trucks. GM has an "Out of Warranty Policy Assistance" in place just for these know lifter issues. This is very concerning that GM hasn't done a recall on these parts as it has shown to be a safety issue when driving the vehicle in traffic on the interstate. I just hope that GM assists me with the repair costs because it is not guaranteed and I cannot afford $7,800 right now.

NHTSA ID

11756456

Incident

Aug 7, 2026

I am reporting a potential safety defect involving my 2019 Chevrolet Silverado 1500 Z71 Trail Boss (VIN [XXX]), currently at approximately 63,000 miles. My truck suddenly developed a rough idle, engine ticking, and a cylinder 3 misfire. The check engine, traction control, parking brake, and “Service ESC” warnings appeared. The transmission also began shifting extremely hard, at times feeling as though another vehicle had struck the truck from behind. The oil pressure gauge also stopped functioning. Due to these symptoms, I stopped driving the vehicle. A diagnostic scan produced P0303, P0449, P0498, P0499 and P0500. After replacing a failed cylinder 3 spark plug, the truck initially ran perfectly for approximately 20 minutes before the rough idle and warning lights returned. The vehicle was subsequently diagnosed by a Chevrolet dealership. The dealership determined that the engine suffered a collapsed lifter that damaged the camshaft and other internal engine components. The engine repair estimate is approximately $10,000–$12,000. The dealership has also reported that the transmission is slipping and believes the torque converter/transmission requires approximately another $6,300 in repairs. I am concerned that a lifter/DFM-related failure causing a misfire, rough running and potential loss of engine power could occur while a vehicle is traveling at highway speed and create a significant safety hazard. The severe transmission shifting and subsequent slipping are also concerning because unexpected vehicle behavior during acceleration or while in traffic could increase the risk of a crash. The truck has been regularly maintained and has relatively low mileage for its age. I am requesting that NHTSA review whether similar engine/lifter/DFM and related powertrain failures represent a broader safety defect and whether an investigation or recall is warranted. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11756231

Incident

Apr 7, 2026

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving approximately 45 MPH and attempting to accelerate to 55 MPH, the engine started choking, and the vehicle lunged back and forth, and slowly lost drive power. The vehicle was driven to a local certified mechanic while driving at slower speeds. The certified mechanic diagnosed the vehicle and determined that the Active Fuel Management (AFM) and Dynamic Fuel Management (DFM) systems had failed and caused the engine failure. The vehicle was not repaired. The mechanic informed the contact that Chevrolet vehicles with similar engines were known for engine failure. The manufacturer was not informed of the issue. The failure mileage was approximately 119,000.

NHTSA ID

11755970

Incident

Aug 10, 2026

Mileage

119,000 mi

At 70,000 miles the engine failed. Dealership said it was due to the current issues with the 6.2 motors but mine was not included in the recall but was being evaluated to be part of the recall so I did have to buy a new engine.

NHTSA ID

11754858

Incident

Jun 1, 2026

I was driving the vehicle and suddenly there was a loss of power and a ticking noise. I was up to date with my oil changes per dealer recommendations. Had the vehicle towed to to Chevy dealer and they said they weren’t able to find what the problem is without further diagnosing. Further diagnosing was estimated to be about $2500. I had it towed to an independent shop, Viking Motorsports, to which the owner/mechanic tore down the engine and deemed it as bearing failure in my 6.2 L87. There was no warning whatsoever, just went from running to engine dead immediately. I proceeded to an engine change that has costed me approximately $15,000 and would like full reimbursement if not partial reimbursement from GM given that this is a known issue for the problem. I did not go with the Chevy Dealership for the job since they quoted me $20,000+ for the engine swap and realistically that wouldn’t make financial sense. I have a High Country and at 102,000 miles when the engine has failed. This has put me in such a financial bind.

NHTSA ID

11753995

Incident

Oct 24, 2025

Wife was driving on the interstate when the vehicle revved up and then a loss of power. had to drive home while vehicle was popping and still loss of power. I took to an Independent Service Center, and they started a tune up with changing plugs. They checked vehicle and advised that it was possibly a lifter failure, but they couldn't fix it. I took to another independent service person and after a diagnostic check and looking into the engine it was confirmed it was a lifter issue. Vehicle has been in the shop for 3 weeks waiting on parts.

NHTSA ID

11753523

Incident

Jun 6, 2026

The engine malfunctioned then the engine light came on. I finally got home turned it off and let cool down. Tried to restart and same issue

NHTSA ID

11753109

Incident

Jul 6, 2026

I have a 2019 Chevy high country that went into engine failure when going down the freeway to work. The engine light came on flashing and the engine was stuttering. I had it taken into the local Dealership where they first replaced catalytic converter. 3 months later I had engine failure again going down the freeway. I had them drop a whole new engine into it. I understand there is an investigation regarding a recall for 2019-2020 year vehicles. How I got the vehicle: I had previously bought a certified used Chevy Silverado 2016. It also had engine failure where it would shut off in the middle of driving. I repeatedly took it back to the dealership (different dealership) and they could not fix it; Instead had me test out another loaner vehicle for possible purchase. Driving off of the lot that loaner vehicle engine light came on. I took it back and they failed to mention to me that they dropped a new block into that one. After that I got another loaner vehicle that I was pigeonholed into purchasing as they could not figure out the issue with my previous purchase. 6 months later it started having electrical problems with rear cameras not working, sensors out, etc; Then eventually the engine failed. The amount of money I have spent and growing safety concerns I have for transporting my family and myself are beginning to grow. I do not want to incur subsequent mechanical failures/expenses in other areas due to previous engine failure.

NHTSA ID

11752868

Incident

Sep 10, 2025

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving, the vehicle failed to exceed 6 MPH. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed and it was determined that the ABS module needed to be replaced. The dealer had retrieved DTC: P2074. The vehicle was repaired, but the failure reoccurred. While driving in stop-and-go traffic, the vehicle failed to accelerate and unexpectedly shifted into park(P). The contact stated that the vehicle failed to restart, and the battery was disconnected and reconnected. The vehicle was then taken back to the local dealer, and additional diagnostic tests were recommended. The contact was informed that the torque converter and transmission needed to be replaced. The vehicle was taken to an independent mechanic, who stated that the failure was related to Technical Service Bulletin: 23-NA-018. The manufacturer was contacted and informed that the dealer should use a flow chart. No assistance was provided. The failure mileage was approximately 100,000.

NHTSA ID

11747417

Incident

Jun 3, 2026

Mileage

100,000 mi

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving 25 MPH and approaching a red traffic light, the vehicle stalled. There was an oil message flashing on the screen instructing the driver to pull over. The vehicle was towed to an independent mechanic, and the contact was informed about the GM Customer Satisfaction Program: N212326940. The local dealer was contacted and referred the contact to the manufacturer for assistance. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that the VIN was not under recall. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 42,000.

NHTSA ID

11746747

Incident

Jun 25, 2026

Mileage

42,000 mi

6-12-26 while driving down the highway the engine suddenly started running rough. Multiple warning lights came on and sounded like a muffled backfire. The truck has confirmed lifter failure as well as camshaft damage enough to where they're replacing an engine I still have no ETA on getting my truck back the truck only has about 72 or 73,000 miles.

NHTSA ID

11746186

Incident

Jun 12, 2026

While driving, my 2019 Chevrolet Silverado 1500 with the 5.3L V8 suddenly lost engine power approximately a quarter mile from my home. The vehicle has only 35,000 miles. A check engine light indicated a misfire, and I confirmed cylinder 7 was misfiring. I replaced the spark plug, plug wire, and coil pack, but the misfire continued. The dealership diagnosed a failed lifter in the Active Fuel Management (AFM) system and is disassembling the engine to assess further damage. This matches the widely documented AFM lifter failure pattern in GM 5.3L V8 engines. The sudden loss of motive power while driving created a safety hazard. All maintenance was performed at GM dealerships.

NHTSA ID

11745855

Incident

Oct 24, 2025

Purchased 2019 Chevrolet Silverado High Country Edition with the 6.2L engine and 143K miles for my son. The vehicle had a clean service history on Car Fax. On the day we purchased the vehicle, we drove it home and noticed it was shuttering at times. I used my computer scanner and it came back with a misfire cylinder #5. I troubleshot the issues and noted that the most common thing was a spark plug. Therefore, I replaced the spark plug and it drove much better. Two weeks later, my son was driving vehicle on I-40 near Nashville TN and without warning, vehicle stalled, locking steering wheel in place! Check engine lights came on and instructed him to place in neutral and restart, which he promptly did. The vehicle started, but went in limp mode making loud noises in engine before shutting off again. Luckily, traffic was minimal at 8 pm and he was able to get it over to the shoulder and avoid any injuries or accident. Towed it to Nick Mayer Chevrolet in Dickson, TN where they diagnosed it with catastrophic engine failure and needed to be completely replaced. This is the same issue that GM is being sued for and have somehow managed to take the stance that the lifter/cam/DFM issue only existed in 2020-newer models. The 2019 is when they changed to the newer body style and the new Gen V L87 engine in the 6.2. Despite the clean vehicle history, dealership reached out to GM and they stated they would not help cover any repairs but would gladly take 14K to fix it. The 2019-2026 models all need to be recalled due to this safety issue and fixed before catastrophic engine failure claims another victim financially or worse!

NHTSA ID

11744567

Incident

Jun 14, 2026

At 60k miles we had a lifter failure that caused an engine replacement. We were traveling home on I-10 about an hour from the Texas Border. My wife was driving about 70-75mph. We had to loud pops and the truck started shaking badly. The pickup was purchased in May 2021 with 26,450 miles. It has been well maintained, so the lifter failure was a complete surprise. We booked a room at a local hotel (3 nights total). The towing company took it to the local Chevrolet Dealership. The dealership couldn't even look at it for over a week. My brother in-law drove 6 hours from our home with a trailer and we hauled it home. We scheduled an appointment with our purchasing dealership and dropped it off. It took a week to get the diagnoses. It was a lifter failure. Our warranty company authorized an engine replacement, but the dealership wanted to just do a cam shaft and lifter. We were without our truck for over a month. It then cost us $300 plus for componets not covered.

NHTSA ID

11744055

Incident

Feb 4, 2025

2019 Silverado experienced sudden engine failure while driving, creating a safety hazard. Had taken vehicle to Serpentine in Tallmadge Ohio for brake repair as well as a ticking sound a couple of times within the past 2 years. Each time the complaint regarding the noise it made was not addressed or documented as they said it was the brakes. While driving the truck, it started clanking and banging, smoking and spewed oil all over engine and ground. The truck is completely inoperable.

NHTSA ID

11741331

Incident

May 30, 2026

The engine in my truck failed while driving down the interstate highway (I-10) on May 28, 2026. At the time of failure, a loud popping noise emitted from the engine. Power and speed were reduced as the result of the failure. The Check Engine Light and Service Engine lights illuminated as quickly as the failure occurred. As many vehicles were simultaneously traveling along the highway at speed, my vehicle suddenly slowing down without indication (brake lights) could have inadvertently caused an accident. As a result, I continued driving the vehicle under reduced power to my home which was only approximately 2 miles away. During the 2-mile drive to my home, the loud popping noise intermitted but reduced power was consistent. Diagnostic checks revealed a code P0305 indicating that cylinder #5 was misfiring. Checking the components of that cylinder revealed the intake valve of cylinder #5 was not actuating when the engine was running indicating a failed lifter & camshaft.

NHTSA ID

11741225

Incident

May 28, 2026

The lifters failed at 106634 miles. This caused the motor to lose power while driving. The dealer confirmed and said a new engine was needed. There were no warnings just immediate failure of a part Chevrolet knows very well is an issue but won't do anything about.

NHTSA ID

11741050

Incident

May 21, 2026

was driving along at 65mph when i heard a pop and then truck shut off said loss of oil pressure along with a few other warnings. managed to cost to the side of a hwy that has no shoulder msg came up saying put in neutral to start did so the motor cranked but would not turn over like it had lost all compression. got towed to a local repair shop spun a main bearing which in turn broke the timing chain that then took out the oil pump. had no prior issues have kept up and regular maintenance well before the recommended time intervals. the hwy i was on is very busy two lane road with no shoulders and very limited passing opportunities could have very easily been hit. this has left me with a need for a total engine replacement that are quite expensive on a vehicle that was bought because it was not part of the gm recall as it is outside the listed as effected yrs.

NHTSA ID

11739583

Incident

Apr 30, 2026

While driving on highway with cruise control set at 65 mph, the engine started misfiring, lost power and multiple warning lights came on. This was the first and only time I had engine problems and I never had any warning lights come on prior to this incident. Dealer confirmed engine experienced complete failure and need to be replaced.

NHTSA ID

11739527

Incident

Mar 21, 2026

The engine died while in use. We were130 miles from home when the engine started making weird noises and a tapping sound.all the lights on the dash lit up and truck would hardly run.l had a independent car hauler haul the vehicle back home to a local garage. The vehicle has been repaired for $10,919 and paid $800.00 to have it transported.

NHTSA ID

11739142

Incident

Apr 6, 2026

: Experienced engine failure. : As of now, vehicle is at the dealership since ( April, 24 2026 ) Dealership - Sunshine Chevrolet - Arden NC 28704 ( Vehicle is available for inspection ) : I was on my way to work on interstate 26, near Asheville NC when i noticed sudden shaking and loss of power. I had to immediately get the vehicle into slower lane of traffic, before exiting the interstate. : Problem has been confirmed by the dealer : Yes > Warning lights did appear. ( Service Engine ) Also ( Oil pressure warning light )

NHTSA ID

11738220

Incident

Apr 23, 2026

Engine oil cooler line leaking from crimp. Same issue CSP N212326940 GM distributed but my truck was not covered for some reason.

NHTSA ID

11738135

Incident

May 15, 2026

While driving home from my way to work, an esc sensor alert went off on the dashboard display. My truck was sent into limp mode, could not accelerate anymore and as soon as I pulled off onto the side of the road the truck died. I was never able to start the truck again. Determined it was an engine lock up when I tried to turn the crankshaft by hand.

NHTSA ID

11738115

Incident

May 7, 2026

On Sunday, April 12, 2026, at approximately 5:00 PM, I experienced a sudden and complete engine failure while driving my 2019 Chevy Silverado equipped with the 6.2L V8 engine. Without warning, the vehicle lost all ability to accelerate, creating an immediate and dangerous situation for myself, my family, and surrounding drivers. I was forced to rely on the vehicle’s remaining momentum to maneuver to the side of the road, all while other drivers honked as I attempted to merge with no engine power. This incident caused significant stress and posed a serious safety risk. My vehicle had to be towed home and then to [XXX] Casa Chevrolet at [XXX] . After inspection, the dealership informed me that the engine requires a full rebuild, despite the vehicle having only 115,697 miles. According to the dealership, the engine shows **no compression on all cylinders**, **crankshaft and camshaft compression failure**, **pistons coated in oil and fuel with visible damage**, and a **non‑functioning timing chain likely due to a broken guide**. These findings mirror the exact symptoms currently under investigation in GM’s **EA25007** inquiry involving the 6.2L V8 (L87) engines in 2021–2025 GM trucks and SUVs GM has already issued a major recall affecting nearly **600,000 vehicles** due to defective connecting rods and crankshafts that can cause sudden engine failure, stalling, and potential fire hazards. Although my 2019 Silverado is not included in the recall, it is experiencing the same catastrophic engine failure associated with the defective components identified in the investigation. The dealership has quoted me $10,000 for an engine rebuild and has refused to assist with the cost. I have also filed a complaint directly with GM, as this failure presents the same safety risks and mechanical defects acknowledged in the recalled models. This sudden engine failure placed my family and other motorists in immediate danger, and the lack of w INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11737709

Incident

Apr 12, 2026

The contact owns a 2019 Chevrolet Silverado. The contact stated that while parked and idling in his driveway , he observed a squealing noise emanating from the engine compartment. The contact stated that the vehicle was turned off and when the vehicle was turned on the failure persisted. The vehicle was taken to an independent mechanic where it was diagnosed that there was lifer and camshaft failure and the engine needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 104,000.

NHTSA ID

11737620

Incident

Dec 14, 2025

Mileage

104,000 mi