2019 Chevrolet Silverado 1500 Fuel system Problems

I am reporting a potential safety defect involving my 2019 Chevrolet Silverado 1500 Z71 Trail Boss (VIN [XXX]), currently at approximately 63,000 miles. My truck suddenly developed a rough idle, engine ticking, and a cylinder 3 misfire. The check engine, traction control, parking brake, and “Service ESC” warnings appeared. The transmission also began shifting extremely hard, at times feeling as though another vehicle had struck the truck from behind. The oil pressure gauge also stopped functioning. Due to these symptoms, I stopped driving the vehicle. A diagnostic scan produced P0303, P0449, P0498, P0499 and P0500. After replacing a failed cylinder 3 spark plug, the truck initially ran perfectly for approximately 20 minutes before the rough idle and warning lights returned. The vehicle was subsequently diagnosed by a Chevrolet dealership. The dealership determined that the engine suffered a collapsed lifter that damaged the camshaft and other internal engine components. The engine repair estimate is approximately $10,000–$12,000. The dealership has also reported that the transmission is slipping and believes the torque converter/transmission requires approximately another $6,300 in repairs. I am concerned that a lifter/DFM-related failure causing a misfire, rough running and potential loss of engine power could occur while a vehicle is traveling at highway speed and create a significant safety hazard. The severe transmission shifting and subsequent slipping are also concerning because unexpected vehicle behavior during acceleration or while in traffic could increase the risk of a crash. The truck has been regularly maintained and has relatively low mileage for its age. I am requesting that NHTSA review whether similar engine/lifter/DFM and related powertrain failures represent a broader safety defect and whether an investigation or recall is warranted. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11756231

Incident

Apr 7, 2026

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving approximately 45 MPH and attempting to accelerate to 55 MPH, the engine started choking, and the vehicle lunged back and forth, and slowly lost drive power. The vehicle was driven to a local certified mechanic while driving at slower speeds. The certified mechanic diagnosed the vehicle and determined that the Active Fuel Management (AFM) and Dynamic Fuel Management (DFM) systems had failed and caused the engine failure. The vehicle was not repaired. The mechanic informed the contact that Chevrolet vehicles with similar engines were known for engine failure. The manufacturer was not informed of the issue. The failure mileage was approximately 119,000.

NHTSA ID

11755970

Incident

Aug 10, 2026

Mileage

119,000 mi

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the vehicle lost power and stalled in the middle of the road. The check engine warning light was illuminated with the message "Fuel Low" displayed. The vehicle was pushed to the side of the road, and the contact later returned to the vehicle and added a small amount of fuel to the fuel tank. After starting the vehicle, the vehicle operated normally and was driven to the residence and parked. The following day, the vehicle was started, and the fuel gauge indicated that the fuel tank was half full. The vehicle was driven to the local dealer, who diagnosed the vehicle with fuel pump power control module failure. The contact was informed that the fuel pump power control module needed to be replaced. The fuel pump power control module was replaced. The cause of the failure was not yet determined. The manufacturer was not contacted. The failure mileage was 71,969.

NHTSA ID

11753588

Incident

Jul 22, 2026

Mileage

71,969 mi

I purchased the truck in 2021 from a chevy dealer with 32k miles on it, truck looked great and performed great, at 42k miles it started to be sluggish and it would vibrate between 30-40 and 60-70 as i feathered the gas pedal to maintain speed, but if i gave it more gas or take my foot off the pedal it would stop vibrating, I've taken it to 2 chevy dealers, the first one said it drives within GM spec's. the 2nd one looked more promising but my warranty ran out at 75k and i was at that mileage. So today at 93k on it, it still vibrates and sluggish from a start. I looked online and many people have similar problems. ALSO: The paint around my front wheels is peeling off down to the primer, I've had many vehicles and never had this happen to me, It's just flaking off, When i had the truck at the chevy dealer for maintenance and told him about it, He said GM will not fix it and they know about the issue. Now these trucks are not cheap, It seems like once they sell the vehicle GM washes their hands of it, I guess that's why they only give you 36,000 mile warranty because they don't even trust their product to last.

NHTSA ID

11734730

Incident

May 23, 2023

I Was traveling home one night and the truck shut off while driving and lost all power, loosing all steering, braking power aswell as all my lights while traveling down the road in the dark. . When I went to start it again all I would get was a cranking noise but no firing. After 30 minutes of waiting the truck started again. In which I drove it 3 more miles before it shut down again. After that it would not crank nor start. I then had the vehicle towed to my local Chevrolet dealer, and they had notified me that the engine had failed and locked up. In the process it had also taken out the FPCM (fuel pump control module) aswell as the high pressure fuel pump located on top of the motor. Causing me to have a new motor from GM installed. I had no previous problems or lights before this had happened.

NHTSA ID

11732894

Incident

Apr 4, 2026

I’d like to report a serious, ongoing safety concern with my 2019 Chevrolet Silverado (5.3 V8 53,028 mi) since Dec 2025. Over the last 4 months, I have experienced at least 20 engine failures/loss of power, with no engine light illuminated after restarting truck. These failures result in a complete loss of power, including steering and braking, posing a significant risk of a crash. Chevy said it would be hard to diagnose with no engine warning light on. Feb 24th, engine failure, warning light stayed on and towed truck to Chevy. Truck on standby, repaired Mar 10th, replacing 2 oxygen sensors per Diagnostics. Picked it up on March 11th, but engine shutdown again the same day and 4 additional failures while driving in my neighborhood, making the truck undrivable. I reached out to Chevy service supervisor, Juliana, but have received no response for the last 10 days. I urge NHTSA to investigate this defect as it poses a severe safety risk. Thank you for your urgent attention.

NHTSA ID

11726217

Incident

Mar 15, 2026

VECHILE CONTINUES TO FAIL OIL CONSUMPTION TEST, TEST BEGAN 09/2023, AND CONTINUES TO BE THE ISSUE PRESENT DAY. ENGINE WAS REPLACED 2025, 3-4 MONTHS LATER TRANMISSION WENT OUT. TRANSMISSION REPLACED 2025. OIL CONSUMPTION CONTINUES TO FAIL. DEALERSHIP CHUCK HUTTON 2471 MT. MORIAH ROAD, MEMPHIS, TN 38115 PERFORMED ALL THESE SERVICES. SAFETY CONCERN IS THAT THE LEAKING OIL POLLUTION IS CAUSING HARM TO ME AND MY FAMILY AS WELL AS LEAVING OIL RESIDUE IN THE DRIVEWAY. NO WARNING MESSAGES EXCEPT FOR WHEN IT SAYS ADD OIL, THAT'S WHEN I'M PUT ON NOTICE THAT THE VECHILE IS LOSING OIL. DUE TO THE LEAKING OIL, OIL IS NOW MIXING WITH GASOLINE, INDICATING THERE TO BE AN ISSUE WITH THE FUEL PUMP. NOW BEIND DIRECTED TO REPLACE THE FUEL PUMP. THIS HAS BECOME VERY COSTLY FOR ME AND MY FAMILY AND CONTINUES TO BE AN ON-GOING PROBLEM

NHTSA ID

11725060

Incident

Sep 25, 2023

The oil cooler lines cracked due to cold weather and oil spouted out of the engine. Truck was immediately pulled over when the chime went off, however the engine still seized up and needs to be replaced. No warning lights before, just the chime at 0 oil pressure. I see that Canada and Alaska has this part recalled and I want to know why it’s not recalled everywhere. No oil was leaking prior to this incident. This left us stranded on the side of the highway and we now have to purchase a new engine with only 65,000 miles on it.

NHTSA ID

11716733

Incident

Feb 7, 2026

I was driving on the interstate, when all my dash lights came on. When stationed, it would vibrate and have excessive smoke come from the exhaust when I would start driving again. After arriving to my destination there was an unusual burning/smokey smell when I got out of the vehicle. I got it scanned and it said it was a cylinder 2 misfire. I replaced the spark plug, coolant, gaskets. Still wasn’t fixed. Then I replaced the fuel injector. Still not working. The mechanic said the oil psi was 30. The vehicle was also burning thru gas and oil quicker than usual. Took it to the dealership and they said it needs a whole new engine and warranty is unsure if they will cover it or not.

NHTSA ID

11711316

Incident

Dec 22, 2025

engine shut off while driving ,and would not start again .upon inspection from gm dealer they stated the high pressure fuel pump. cam shaft and lifters need to be replaced ...there was no sign of failure prior to shut down

NHTSA ID

11693842

Incident

Sep 18, 2025

One day when headed out of town I stopped and got gas immediately once getting back on the highway my dash lit up like a Christmas tree, driving became uncomfortable as it sputtered when trying to give gas. I looked up a couple of the dash warning lights and it alluded to emission problems. I take the truck to the mechanic and he says that a head is cracked and the cam shaft needs to be repaired. This issue came out of nowhere, no prior issues as far as over heating or any dash lights on.

NHTSA ID

11690195

Incident

Sep 13, 2025

TSB PIP5776. 87000 miles failed. dealer quote ($9,000) to repair lifter and bent camshaft. Gm said they aren't helping and my next step is get a attorney. Mention 10% “goodwill” offer and lifter collapse + bent cam

NHTSA ID

11672609

Incident

Jun 25, 2025

I went to drive my truck and it would start but I got a “ service power steering no assist “, service rear vision camera, service trailer brake system. Then it wouldn’t start and got the “ lost communication with fuel pump control module, back up camera was flashing in and out and license plate lights would flash with turn signal on.

NHTSA ID

11671476

Incident

Jul 5, 2025

While exiting the highway from 70MPH my truck quit running on the exit ramp as I approached the end of the ramp. The truck would not restart and blocked traffic until I was able to get a tow truck. After the truck was towed back to my home I was able to scan the truck and found P129F code reporting (Fuel Pump Driver Control Module Fuel Pump Speed Signal Incorrect) (see attached report). Only after purchasing a Fuel Pump Driver Control Module from the dealer (P/N) 13565641 (replacement for the original 13531875 P/N) and installing it would the truck start. This was a real safety concern as other driver were also exiting the highway at speed while my truck was blocking a lane. The fuel pump control modules should be designed in "fail safe" way to allow the fuel pump to continue even if it isn't running at the most optimal level.

NHTSA ID

11667037

Incident

May 25, 2025

Shut down

NHTSA ID

11664209

Incident

May 5, 2025

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving 65 MPH, the traction control and another unknown warning light illuminated on the instrument panel. Despite the failure, the contact was able to drive the vehicle to the residence. The vehicle was then taken to a dealer where a diagnostic test was performed. The dealer replaced the fuel injectors, lifters, and the catalytic converter. The manufacturer was notified of the failure and extended the warranty on the vehicle and offered the contact reward points. The vehicle was repaired. The failure mileage was 110,000.

NHTSA ID

11655783

Incident

Mar 17, 2025

Mileage

110,000 mi

Vehicle has been at dealership multiple times for the same issues and the cant figure it out. Constantly p303 codes. On highway doing 65-70 and truck starts to shutter and drop speed swerving down to about 40mph on highway in traffic. Have to pull to shoulder and restart Vehicle.

NHTSA ID

11653976

Incident

Apr 10, 2025

I stopped at street light, Automatic Fuel Management system shut off engine. As engine restarted I experienced several dash lights came on. The engine light continued to blink and E light stayed on. Immediately went to dealer, 1 mile away. Computer said cylinder 5 was misfiring. Upon repair the lifter was bent and the cam shaft was damaged. Repairs were over $7,000.00. Truck had oil changes on time, all performed by the dealer. Truck had 67,000.00 miles. Repairs have been completed.

NHTSA ID

11649655

Incident

Feb 27, 2025

CRANK NO START WITH A P129F SET DUE TO INTERNAL SPEED FAILURE BETWEEN FUEL PUMP AND FUEL PUMP CONTROL MODULE. UPDATED DESIGN MODULE AND PUMP MUST BE REPLACED TOGETHER SE APAGO DEJANDONOS EN MEDIO DE 2 CARRILES EN UNA CURVA Y NO FUNCIONABAN LAS INTERMITENTES PASABAN MUCHOS AUTOS Y TRAILERS ESTABAMOS MI ESPOSO MI HIJO DE [XXX] Y YO GRACIAS A DIOS NO SE NOS ESTAMPO UN TRAILER MI HIJO ES [XXX] Y DE EL MIEDO NO HA PODIDO DORMIR BIEN NI YO TAMPOCO AUN TIEMBLO ERA DOMINGO Y NO PODIAMOS CONSEGUIR UNA GRUA Y LLAME A CHEVROLET DIJERON QUE LLEGARIAN EN 16 MINUTOS Y TARDARON MAS DE 1 HORA LA LLEVARON A MI CASA Y EL LUNES LA LLEVARON A LA AGENCIA DE CHEVROLET MUCHAS CAMIONETAS HAN TENIDO ESA FALLA NO SE POR QUE NO HAY AVISOS EN ESTA PAGINA ME QUIEREN COBRAR MUCHO Y LA CAMIONETA SOLO TIENE 7921 MILLAS NO HUBO MENSAJES DE ADVERTENCI NI LUCES HASTA DESPUES DE QUE SE DETUVO LA CAMIONETA Y YA NO QUIZO AVANZAR SE APAGABA INMEDIATAMENTE INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11648027

Incident

Mar 9, 2025

I own a 2019 Chevrolet Silverado 1500 LT Trail Boss that exhibits strange and persistent issues. A recurring engine code appears P0499, clears itself, and then reappears without consistent resolution. This affects the remote starter as the engine light will be engaged. Additionally, several service warnings flash momentarily and disappear, including: •Service Trailer Brake System •Brake System Failure – Top Speed Limited to 62 or 43 MPH •Parking Sensor Unavailable These warnings occur without warning and vanish too quickly to document fully. Despite multiple visits to the dealership, technicians have been unable to replicate or resolve the problem. This unpredictable behavior creates safety concerns, particularly regarding brake system reliability and sensor functionality. I and many others experiencing these same issues are concerned about a potential electrical or sensor issue impacting vehicle performance and safety.

NHTSA ID

11635899

Incident

Sep 10, 2024

Wires were improperly installed during assembly, on truck and rubs on a frame which chafes, which causes the protective covering to get rubbed off causing a short circuit on my wiring harness which causes the "check engine light" to stay on constantly. This is a factory mistake yet they want to charge me for the fix. I also have come to know this is getting too common on Chevy Silverado 1500 and GMC Sierras. GM needs to correct their factory defect for free. This chafing can happen in three different areas on the trucks. These shorted wires can cause failure of the fuel pumps and leave you on the road when the engine shuts down. GM knows about these problems but has not acted on this problem. they never mentioned or noted the wiring problem on my repair summary, Oct. 23, 24, when they were replacing the torque converter. They showed it to me, but never made note of it. They are going to work on it Monday 12/9/24, I will talk of, who's going to cover the cost of this after it's repaired.

NHTSA ID

11629529

Incident

Oct 23, 2024

The engine oil cooler line detached from the crimp joints, causing an "oil pressure low turn vehicle off" alert. I was fortunately able to pull over immediately, and catch the 8 quarts of oil which dumped out. This resulted in $634 repair bill, and likely damage to the engine of the truck. Had I not been in a rural area and able to pull over immediately, I would have lost all power to drive and dumped that oil on the road, causing both safety hazard and environmental damage. This truck has been serviced by our local Chevy dealer who confirmed the problem with GM. This is a known problem to GM, the subject of their Customer Satisfaction program bulletin N192220080, and a recall in Canada and Alaska. Clearly the issue exists in areas other than Canada and Alaska, yet GM refused to cover any of the cost under our 60,000 mile warranty and has not issued a recall in other states.

NHTSA ID

11619813

Incident

Aug 16, 2024

The oil cooler lines on my 2019 Silverado 1500 disconnected at the crimp while I was driving. The vehicle has only a bit more than 30,000 miles. I checked online, I.e. various sites as well as nhtsa and found the GM Customer Satisfaction Program N192220080. In the pdf on your site dated June 22, 2021, it is stated that only 530 vehicles were affected. I believe that this problem is more widespread than GM is willing to admit. Fortunately I was not driving on the interstate at a high rate of speed where “ a potential loss of propulsion” could have resulted in a tragic outcome.

NHTSA ID

11597780

Incident

Jun 5, 2024

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while in park(P), he observed a gasoline odor. Additionally, the contact stated that while driving at 65 MPH, he observed a gasoline odor entering the cabin of the vehicle through the vents. The contact exited the highway and pulled over, examined, and turned off the vehicle. The vehicle was towed to the residence. The vehicle was then towed to an independent mechanic where it was diagnosed that the high-pressure fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 123,000.

NHTSA ID

11577537

Incident

Mar 13, 2024

Mileage

123,000 mi

CEL for emissions evap circuit. Problem part is fuel pump control module. GM has recalled other vehicles over this part and has suggested its failed operation may cause the engine to stall due to the fuel pump shutting off. Currently my vehicles evap system is unable to vent fuel vapors to the engine which poses a safety risk if the pressure accumulates in the tank. I believe GM wasn’t thorough in the recall and only recalled what was absolutely necessary. The part is on back order which points to how common this item fails.

NHTSA ID

11556713

Incident

Sep 30, 2023