Owner-reported complaints naming the powertrain system, filed with NHTSA
Data refreshed
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials. Every record below is an owner-reported complaint about the 2019 Chevrolet Silverado 1500 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 321 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 321, in the owner's own words
Out of specs crankshaft machining, excessive journaling chamfering & debri in the oil galleries have caused rod bearing failure resulting in total engine seizure. This is consistent with the NHTSA 25V-274 recall, of which identifies the 6.2L V8-L87 engine as defective, resulting in 12 recorded accidents. However, this recall does not cover the 2019 model year.
My head, my transmission in my Silverado 1500 6 speed has had rough shifting since I bought it had 29,000 miles on it. It also has been looked at for the rough and they said it was normal now at 100,000 miles by train ships out of gear while driving and coming to an idle at random spots, took it into a train shop Westland transmission. They said I need all new transmission which I think this should've been fixed a long time ago with the rough shifting the recall and lawsuit needs to add the six speed trans to the eight speed intense speed that GM is officially getting served on.
The contact owns a 2019 Chevrolet Silverado 1500. While driving at an undisclosed speed, the low engine oil warning light illuminated. A month later, while driving 60 MPH, the transmission malfunctioned between 4th and 5th gear, either missing shifts or shifting erratically, accompanied by a severe vibration. The vehicle was taken to a local dealer, where technicians discovered a leaking engine oil cooling line while preparing to repair the transmission. The dealer confirmed the failure. The manufacturer was notified of the failure; however, the contact was informed that the VIN was excluded from Customer Satisfaction Program: N192220080.
V8Component Affected: Electrical System / Power Train (Transmission) / Engine Cooling & WiringDescription of the Safety Defect and Incident:While operating the vehicle, severe electrical degradation occurred due to a catastrophic failure of the factory body-to-chassis grounding system. Upon professional inspection by a certified mechanic, it was discovered that the primary ground wires had suffered extreme thermal degradation, with the mechanic stating that the wiring components "almost melted in his hands" upon physical touch.Because the vehicle's manufacturing-defective ground strap severely corroded and failed, the high-amperage electrical current redirected itself along an unintended path of least resistance: directly through the transmission shifting cables and internal wiring harnesses. This extreme electrical bypass caused extensive thermal damage, melted critical electrical insulation, and permanently fried the Transmission Control Module (TCM) and internal transmission components, causing total mechanical failure.Why this is a Critical Safety Hazard:Fire & Thermal Risk: The failure created an active thermal event under the hood. Electrical current reaching temperatures high enough to melt heavy-duty wiring harnesses poses an immediate vehicle fire risk while operating or parked.Sudden Loss of Propulsion: The electrical short directly compromises transmission communication, risking an uncommanded shift into neutral or total loss of motive power while driving at highway speeds, creating a severe crash hazard.Manufacturer Action / Request for Investigation:General Motors recently issued Customer Satisfaction Program #N252515590 specifically to address this exact "body-to-chassis ground strap corrosion" defect on 2019–2024 Silverados.
Came off the parkway and came to a stop at a stop sign. As I attempted to accelerate forward the truck shuttered violently, did not move forward and then slammed into gear. As it slammed into gear it jerked forward. The force of the jerk pushed me back in the seat and caused the steering wheel to turn. About 100 yards later I came to a stop in traffic. As I attempted to accelerate the same incident occurred again. After the second incident anytime I same to a stop and attempted to accelerate forward the shutter was no longer present but the truck would not move at first and would then slam into gear and jerk violently. This would occur in drive and reverse. I brought it to the dealership and they diagnosed that it needed a transmission. The service writer even told me it bucked so hard while the technician was moving it that it almost put him through the steering wheel. The truck is currently having the transmission replaced at Greenbrook GMC. Estimated repair cost is $9400 plus taxes and fees. Can provide invoice and bill once repair is completed.
While Driving I feel shaking while accelerating between 25-40 mph, and its like I'm driving over rumble strips, plus when stopped and start to accelerate it hesitates and then surges forward.
Transmission entered limp mode when decelerating at highway speed. Shutter shift, rapid rpm increase. First shift in the morning is a hard shift with loss of power.
My truck suddenly stopped, received a message on the dashboard that said transmission hot. Idle engine. I was unable to remove my key. Minutes later it started up like nothing.
Torque converter failure led to transmission failure in 6 speed transmission. Engine lifter failure.
Transmission has jerked and shuttered ever since I bought the truck. Sometime when you push on the gas the truck doesn’t immediate go, then suddenly jerks into gear and speeds off! It has gone in several times but all they do is software updates. They also said I needed a transmission flush at only 43,000 miles stating an inferior trans fluid was originally used; however they wouldn’t covered it under my extended warranty
"The transmission valve body is failing, causing the rear wheels to violently lock up while Driving
Had to replace transmission out pocket even though its a very common issue with this vehicle.
I was driving my 2019 Chevy Silverado TrailBoss with 81,000 miles at 65MPH on I-80 East in Omaha, NE, when 3 warning lights came on. The first was the Service Parking Brake. The second was Service ESC. The final was a flashing Check Engine light. My truck started backfiring/misfiring, making a loud ticking noise, and running extremely rough. I was trying to merge off the interstate, but it was running so rough that it made it very difficult to do so safely. Eventually, I just had to finish going where I was headed and park it in the lot. I did some research and called my local shop. They said to stop driving immediately and have it towed to them for inspection. They used a diagnostic tool and diagnosed the issue as a DFM lifter failure. But they could not fix it there and recommended I take it to a different shop. I had it towed again, and they did their own diagnostics and have the same idea, but without taking the engine completely apart, they can't tell for sure. They want to charge me $1,250.00 to inspect it further. I called the dealer where I purchased the truck back in 2019 and am working with them on next steps. The last shop quoted me $7,800 repair if it is indeed the DFM lifters. Based on what I know, this is a known issue with these trucks. GM has an "Out of Warranty Policy Assistance" in place just for these know lifter issues. This is very concerning that GM hasn't done a recall on these parts as it has shown to be a safety issue when driving the vehicle in traffic on the interstate. I just hope that GM assists me with the repair costs because it is not guaranteed and I cannot afford $7,800 right now.
I am reporting a potential safety defect involving my 2019 Chevrolet Silverado 1500 Z71 Trail Boss (VIN [XXX]), currently at approximately 63,000 miles. My truck suddenly developed a rough idle, engine ticking, and a cylinder 3 misfire. The check engine, traction control, parking brake, and “Service ESC” warnings appeared. The transmission also began shifting extremely hard, at times feeling as though another vehicle had struck the truck from behind. The oil pressure gauge also stopped functioning. Due to these symptoms, I stopped driving the vehicle. A diagnostic scan produced P0303, P0449, P0498, P0499 and P0500. After replacing a failed cylinder 3 spark plug, the truck initially ran perfectly for approximately 20 minutes before the rough idle and warning lights returned. The vehicle was subsequently diagnosed by a Chevrolet dealership. The dealership determined that the engine suffered a collapsed lifter that damaged the camshaft and other internal engine components. The engine repair estimate is approximately $10,000–$12,000. The dealership has also reported that the transmission is slipping and believes the torque converter/transmission requires approximately another $6,300 in repairs. I am concerned that a lifter/DFM-related failure causing a misfire, rough running and potential loss of engine power could occur while a vehicle is traveling at highway speed and create a significant safety hazard. The severe transmission shifting and subsequent slipping are also concerning because unexpected vehicle behavior during acceleration or while in traffic could increase the risk of a crash. The truck has been regularly maintained and has relatively low mileage for its age. I am requesting that NHTSA review whether similar engine/lifter/DFM and related powertrain failures represent a broader safety defect and whether an investigation or recall is warranted. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Third transmission failure in 10 months on this vehicle (8-speed automatic). (1) Oct 2025, 67,885 miles: transmission shuddering; dealer replaced the complete transmission with a GM remanufactured unit under extended warranty (RO 240481, Nucar Lannan Chevrolet of Woburn, MA). (2) Jul 2026, 82,439 miles: vehicle would not shift on the highway while driving; DTC P2824 stored; dealer replaced the transmission valve body under warranty (RO 248929). (3) Aug 3, 2026, approx. 82,500 miles — three days after the valve body repair was returned to me — the transmission locked up and the vehicle would not shift gears while in traffic. Loss of gear engagement while driving creates risk of a crash from sudden loss of propulsion. Vehicle is back at the dealership now for the third repair. This vehicle's 8-speed transmission (8L90/8L45 family) is the subject of known shudder/valve-body defect litigation covering 2015–2019 Silverado models.
What component or system failed or malfunctioned, and is it available for inspection upon request? The transmission and drivetrain system appear to be defective. The vehicle repeatedly experiences hard shifting, transmission shudder, hesitation during acceleration, delayed engagement when shifting into gear, and erratic gear changes. These problems occur during normal driving and have progressively worsened over time. The vehicle is available for inspection upon request. How was your safety or the safety of others put at risk? The transmission hesitation and delayed acceleration create a serious safety hazard. When pulling into traffic, crossing intersections, or changing lanes, the vehicle does not respond immediately when the accelerator is pressed. The delay leaves the vehicle exposed to oncoming traffic and increases the risk of a collision. The hard shifting and shuddering also cause the vehicle to behave unpredictably, reducing driver confidence and making it unsafe to operate in normal traffic conditions. Has the problem been reproduced or confirmed by a dealer or independent service center? The problem is consistently reproducible during everyday driving. The transmission shudders, hesitates, and shifts harshly on a regular basis. Although the condition is intermittent in severity, it occurs frequently enough to create ongoing safety concerns. At this time, the vehicle has not been inspected by police or insurance representatives. The vehicle remains available for inspection. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? The first symptoms were occasional hard shifts and slight hesitation during acceleration. Over time, the condition worsened, progressing to severe shuddering, delayed acceleration, and increasingly harsh gear changes. No warning lights or diagnostic messages appeared when the symptoms first began, making it difficult to identify the problem before it be
Transmission started shuttering on way to work went out before making it home. No problem before this trip.
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving, the vehicle failed to exceed 6 MPH. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed and it was determined that the ABS module needed to be replaced. The dealer had retrieved DTC: P2074. The vehicle was repaired, but the failure reoccurred. While driving in stop-and-go traffic, the vehicle failed to accelerate and unexpectedly shifted into park(P). The contact stated that the vehicle failed to restart, and the battery was disconnected and reconnected. The vehicle was then taken back to the local dealer, and additional diagnostic tests were recommended. The contact was informed that the torque converter and transmission needed to be replaced. The vehicle was taken to an independent mechanic, who stated that the failure was related to Technical Service Bulletin: 23-NA-018. The manufacturer was contacted and informed that the dealer should use a flow chart. No assistance was provided. The failure mileage was approximately 100,000.
Engine oil cooler line leaking from crimp. Same issue CSP N212326940 GM distributed but my truck was not covered for some reason.
I've had a unknown problem with my transmission since I've owned my truck, Took it back to two different GM dealership and one said it was low on transmission fluid after keeping it for about two weeks, So I took it to another dealership out of state and was told there wasn't anything wrong with it. I am absolutely sure that something is wrong with the transmission and they don't want to fix it even though the truck is under warranty. I have seen so many complaints about the transmission and the Chevy Silverado of my year 2019 and above it has to be something going on with the transmission in these trucks that nobody wants to admit.
I own a 2019 Chevrolet Silverado 1500 equipped with the 8-speed automatic transmission. The vehicle has developed serious transmission problems that create a safety concern. When the transmission is cold, the vehicle slips between 1st and 2nd gear during acceleration. If I accelerate normally, the transmission slips and then engages with a hard bang. I must accelerate very slowly to avoid harsh engagement. In addition, during deceleration, especially when downshifting into 3rd gear, the transmission makes a hard "thump" or "bang". This unexpected shifting behavior creates a safety risk when entering traffic, making turns, or driving in stop-and-go traffic. The vehicle has been properly maintained, including transmission fluid service at a Chevrolet dealership, but the problem continues and appears to be getting worse. I understand many GM 8-speed transmission owners have reported similar issues. The repair cost quoted by the dealership is between $7,000 and $10,000, which suggests a possible design or manufacturing defect. I am filing this complaint for investigation of a potential safety-related transmission defect. Thanks [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I have a 2019 Chevrolet High Country, have always kept it serviced and maintained. Driving down the road it randomly lost power, wouldn't let me (driver) give gas, started shaking and making loud clanking noise from the engine. Was able to pull over to the side of the road, recorded the noise it was making. Called a tow company to get it towed to the nearest Chevrolet Dealer ship and they confirmed that the engine was no longer good. Related problem to the 6.2l motor issues. They are requested for a New motor.
I am filing this complaint to report a critical manufacturing safety defect regarding the rear differential in my 2019 Chevrolet Silverado 1500. During a recent dealership inspection at approximately 40,400 miles, an authorized GM service center (Jack Hanania Chevrolet) discovered that the vehicle's rear differential was completely "bone dry" of gear oil . Because there is no history of catastrophic fluid leaks, seal blowouts, or external damage, this strongly indicates that the rear differential was either never filled or improperly filled with lubricant at the factory during vehicle assembly. This issue originally presented as a persistent drivetrain vibration, shudder, and "skipping" sensation starting as early as 12,000 miles . I brought the vehicle to the dealership for this exact vibration at approximately 21,000 miles. The dealership misdiagnosed the issue as "low transmission fluid" (despite the transmission being a sealed system) and failed to inspect the rear differential . The symptoms persisted until the vehicle was immobilized in November 2025, which is when the bone-dry rear differential was finally discovered . A vehicle operating with an empty rear differential poses an extreme and immediate safety hazard. The lack of lubrication causes severe internal heat and friction, inevitably leading to a sudden, catastrophic mechanical seizure of the rear axle . If the rear wheels lock up while driving at highway speeds, it will cause an immediate loss of vehicle control, resulting in a high-speed collision. I urge NHTSA to investigate GM's factory fluid-fill procedures and quality control for 2019 Silverado differentials to prevent a fatal lock-up event for other drivers on the road.
. I bought this truck for my husband as a birthday present & it has been a nightmare. My husband is a [XXX] & I wanted a vehicle that he would be comfortable in to take him to his numerous medical appointments. The first indication was the check engine light came on. I took to to O'Reillys & they scanned the vehicle & no issue was detected. I then had several instances where the vehicle would not start & one instance when it would not go into reverse & the truck was making a noise from the underbody. The windshield washer unit also was not working. I then took it back to the Ford dealership where it was purchased. They ran a scan at the dealership & said there was nothing wrong. They then indicated that I should take it to a Chevy dealer which I did. They stated that Chevy has a special scan that the previous scans cannot access. I documented all the issues and the Chevy dealership found 8 issues including the transmission, holes in the struts, software issues, washer pump, grille shutter & loose battery cables. The Ford dealership agreed to fix the struts & the washer pump as well as the diagnostic testing. I thought we were going to be able to resolve the transmission and the grille shutter issue but that has not happened. The defective grille shutter is what is activating the check engine light. The Ford dealership charged me for fixing the battery cables and yet they were needed to be done again. They also told me that the grille shutter was not necessary as I could drive with it but I would never know when I had an actual problem. They wanted to replace the torque converter. I submitted a request to Carvana & they offered me 5,000 and I paid double that plus. I don't feel safe driving the vehicle and GM is well aware of the issues with this make and Model. Let's not wait until someone is killed or hurt before action is taken. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while operating the vehicle, the message "Transmission Fluid Overheat" was displayed. The vehicle was taken to the local dealer to be diagnosed, and it was determined that the TCM had failed and needed to be replaced. The TCM was replaced, and the vehicle was repaired. After retrieving the vehicle, the vehicle failed to immediately reverse as needed. The vehicle hesitated before reversing. The failure later occurred while driving forward, and the vehicle jerked while driving from being stationary. The contact stated that the failure was also present during cold starts. The vehicle was taken back to the dealer to be diagnosed, and it was determined that the transmission needed to be replaced. The vehicle was not yet repaired. The manufacturer was not yet contacted. The failure mileage was 128,000.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .