2004 Chrysler Pacifica Engine Problems

DRIVING DOWN INTERSTATE WHEN THE CRUISE CUT OUT AND THE ENGINE SKIPPED. PULLED OVER TO CHECK ENGINE FLUIDS AND ALL WERE OK. NO ENGINE WARNING LIGHTS OR ANY OTHER INDICATION OF SOMETHING BEING WRONG. CONTINUED AT APPROX 70 MPH WHEN THERE SEEMED TO BE AN INTERNAL EXPLOSION WITHIN THE ENGINE CAUSING THE ENGINE TO STOP AND ALL FRONT AIRBAGS TO DEPLOY. VEHICLE THEN CAUGHT FIRE AND WAS TOTALLY DESTROYED.

NHTSA ID

11383210

Incident

Dec 11, 2020

Mileage

150,000 mi

THE UNDER CARRIAGE THAT HOLDS ENGINE IN PLACE IS COMPLETELY RUSTED THROUGH. I BOUGHT BRAND NEW TIRES FROM BELLE TIRE ON SEPTEMBER 9, 2020. BY NOVEMBER 1 2020 I WAS OBSERVING EXTREME WEAR ON THE BRAND NEW TIRES. WENT TO MY MECHANIC AND WAS TOLD THE CAR IS UNSAFE TO DRIVE DUE TO THE CRADLE RUST ROT, AND THE ENGINE IS ABOUT READY TO FALL OUT AND WOULD CAUSE CATASTROPHIC EMERGENCY I AND MY FAMILY COULD DIE. TRYING TO FIND REPLACEMENT AND AM BEING TOLD IT IS SUCH A PROBLEM THAT THERE IS NO PARTS AVAILABLE TO FIX THIS PROBLEM

NHTSA ID

11373618

Incident

Nov 1, 2020

Mileage

11,800 mi

I WAS DRIVING ON THE HIGHWAY, AND MY LIGHTS ALL LIT UP, CAR STALLED, AND MY DASH BOARD SAID NO BUS

NHTSA ID

11364713

Incident

Oct 16, 2020

Mileage

184,000 mi

TL* THE CONTACT OWNED A 2004 CHRYSLER PACIFICA. THE CONTACT STATED THAT WHEN HE PURCHASED THE VEHICLE THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED, HE HAD TAKEN IT TO CHRYSLER JEEP DODGE RAM BRUNSWICK GEORGIA (5400 ALTAMA AVE, BRUNSWICK, GA 31525) FOR A FULL INSPECTION. A WEEK LATER WHILE AT A STOP SIGN, THE CHECK ENGINE AND AN UNKNOW RED WARNING LIGHTS ILLUMINATED A SECOND TIME. THERE WAS SMOKE AND FIRE COMING FROM UNDERNEATH THE FRONT HOOD AREA. THE CONTACT WAS OCCUPYING THE VEHICLE AS THE DRIVER AND MANAGED TO EXIT THE VEHICLE. THE CONTACT STATED THAT THE FUEL LINE CAUGHT ON FIRE AND BURNED THE VEHICLE CAUSING TO IGNITE INTO FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A FIRE AND POLICE REPORT WERE FILED. THE VEHICLE WAS TOWED TO A JUNK YARD WHERE IT WAS BEING INVESTIGATED. THE VEHICLE WAS DEEMED DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED A CASE NUMBER. THE CONTACT MENTIONED THAT THERE WAS A SIMILAR RECALL BUT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 170,503.

NHTSA ID

11364337

Incident

Jul 10, 2013

Mileage

170,503 mi

ITS THROWING A PCM CODE AN THE CAR IS STALLING SO BAD IN THE MODDLE OF DRIVING I HAVE BEEN STUCK SEVEREAL TIMES AN I THUNK THERE IS A FUEL LEAK I SMEELL GAS SO BED ITS THROING PO300 CODE AN WONT CHANFE EVEN WHEN I GOT ALL THE PARTS I SEE THERE IS A RECALL ON MY YEAR OF CAR CAN SOMWONW HWLP MW I CANT KEEO CUTTING OFF ILL WRECK

NHTSA ID

11353350

Incident

Aug 20, 2020

Mileage

65,000 mi

UPON TAKING A THE VEHICLE TO A MECHANIC, I WAS INFORMED THE SUBFRAME WHICH SUPPORTS THE ENGINE IS RUSTING TO THE POINT IT WILL NOT HOLD THE ENGINE CAUSING CATASTROPHIC FAILURE. I HAVE BECOME AWARE CHRYSLER IS AWARE OF THE FUTURE FAILURE AND WILL NOT FIX IT.

NHTSA ID

11350021

Incident

Jun 4, 2020

Mileage

75,000 mi

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. THE CONTACT STATED THAT ON SEVERAL OCCASIONS WHILE DRIVING AT UNDISCLOSED SPEEDS, THE VEHICLE DECELERATED INDEPENDENTLY AND STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC ON FOUR OCCASIONS HOWEVER, THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE OR RETRIEVE A FAULT CODE. ADDITIONALLY, WHILE DRIVING AT 40 MPH, THE VEHICLE DECELERATED WITHOUT WARNING. THE VEHICLE WAS TOWED TO BROOKFIELD CHRYSLER DODGE JEEP RAM (1845 PIPESTONE RD, BENTON HARBOR, MI 49022), TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE OXYGEN SENSOR FAILED AND NEEDED TO BE REPLACED. THE OXYGEN SENSOR WAS REPLACED SEVEN TIMES HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 149,000.

NHTSA ID

11342058

Incident

Feb 5, 2020

Mileage

149,000 mi

VEHICLE WAS TAKEN TO SERVICE. SHOP WOULD NOT WORK ON VEHICLE STATING THE DETERIORATION OF THE SUBFRAME WAS TO EXTENSIVE AND THEY WOULD NOT WORK ON IT. UPON CLOSER INSPECTION SHOWED THE FRAME IN A GREAT STATE OF DECAY, WITH SOME PLACES ONLY BEING HELD TOGETHER WITH THIN STRIPS OF METAL. THESE VEHICLES WERE RECALLED IN THE PAST FOR DEFECTIVE FRAMES HOWEVER NOT ALL WERE RECALLED AND THIS IS ONE VEHICLE THAT WAS NOT. THE MOTOR IN THESE VEHICLES WILL FALL OUT AND COULD CAUSE AN ACCIDENT WHICH COULD RESULT IN SERIOUS INJURY OR LOSS OF LIFE. THESE FRAMES ARE DEFECTIVE IN WORKMANSHIP FROM THE FACTORY AND SHOULD BE HANDLED BY THE FACTORY ACROSS ALL 2004-2008 CHRYSLER PACIFICA'S AFFECTED BY DEFECTIVE EQUIPMENT KNOWINGLY INSTALLED BY THE FACTORY THAT WILL LEAD TO AN ACCIDENT AND CAUSE SERIOUS INJURY OR DEATH. THOUSANDS OF THESE VEHICLES ARE ON THE ROAD TODAY WITH OCCUPANTS UNKNOWINGLY DRIVING THESE VEHICLES WHICH ARE "TICKING TIME BOMBS". *TR

NHTSA ID

11329184

Incident

Jun 12, 2020

Mileage

167,000 mi

ENGINE STALLS FOR NO REASON INDICATED BY ENGINE CODES. VEHICLE WAS COMING TO A STOP. WAS BACKING UP ONCE. JUST IDLING AND STALLED. SOMETIMES WHEN DRIVING IT FEELS AS IF NOTHING IS HAPPENING WHEN I ATTEMPT TO ACCELERATE. HAS DONE THIS BEFORE THE DATE SUBMITTED. DIFFERENT DATES.

NHTSA ID

11318173

Incident

Mar 15, 2020

Mileage

89,100 mi

VEHICLE.JUST QUIT RUNNING.AND WOULDN'T START.AGAIN. THE VEHICLE WAS IN MOTION

NHTSA ID

11252994

Incident

Aug 30, 2019

Mileage

202,102 mi

I WAS DRIVING ON A CITY STREET AND I WAS TURNING AT A STOP LIGHT WHEN MY CAR MADE A VERY STRANGE SOUND. I COULD NOT STEER THE CAR SO I PULLED OVER AND UPON LOOKING UNDERNEATH THE VEHICLE AND UNDER THE HOOD THE MOTOR HAD SHIFTED DUE TO A ROTTING CRADLE MOUNT.

NHTSA ID

11119746

Incident

Aug 5, 2018

Mileage

160,000 mi

K-FRAME IS ROTTED OUT NOT SAFE TO DRIVE ENGINE COULD FALL OUT

NHTSA ID

11118605

Incident

Aug 8, 2018

Mileage

129,700 mi

HAVE 2004 CHYSLER PACIFICA HAVING ISSUES WITH FUEL SYSTEM TRUCK DRIVES THEN SPUTTER SHUTS OFF TAKE LONG TIME STARTING UP ALSO OVER HEATS NO REASON TRUCKS SHIFTS INTO GEAR 2 BUT DON'T GO SPEED THINK I'M GOING TRANSMISSION SLIPS CAN BE RIDING UP STREET SHUTS OFF ON ME SHIFTS INTO DRIVE WITH RPM SAYING 2

NHTSA ID

11110786

Incident

Jul 11, 2018

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. WHILE DRIVING APPROXIMATELY 55 MPH IN THE RAIN, THE INSTRUMENT PANEL LIGHTING AND THE ABS INDICATOR BEGAN TO FLASH. IN ADDITION, THE WINDSHIELD WIPERS STOPPED WORKING, THE VEHICLE SUDDENLY JOLTED FORWARD, AND STALLED. THE NEXT DAY, AFTER RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 150,000.

NHTSA ID

11104071

Incident

Jun 24, 2018

Mileage

150,000 mi

2004 CHRYSLER PACIFICA. CONSUMER WRITES IN REGARDS TO SAFETY RECALL THAT WAS NEVER REPAIRED WHICH RESULTED IN VEHICLE FIRE. *LD CONSUMER SENT ADDITIONAL CORRESPONDENCE. *LD *TR *JS *JS THE MANUFACTURER WAS NOTIFIED, BUT HAD NOT OFFERED ANY ASSISTANCE. *JS

NHTSA ID

11074814

Incident

Jul 1, 2013

WE OWN A 2004 CHRYSLER PACIFICA WITH AROUND 117K MILES ON IT. MY DAUGHTER DRIVES IT. WHILE CHANGING THE ENGINE OIL ON IT LAST WEEKEND, I NOTICED SEVERE CORROSION (PERFORATION ACTUALLY) OF THE VEHICLE ENGINE CRADLE. THE PASSENGER SIDE OF THE CROSS MEMBER IS RUSTED COMPLETELY THROUGH ON THE BOTTOM AND THE DRIVER SIDE IS ABOUT 70% RUSTED THROUGH. AS THIS CROSS MEMBER IS WHAT HOLDS THE ENGINE IN THE VEHICLE AND ACTS AS THE BASE OF THE FRONT SUSPENSION, I DON'T BELIEVE THIS VEHICLE IS SAFE TO DRIVE ANYMORE. SHOULD THIS STRUCTURAL COMPONENT FAIL DURING HIGHWAY DRIVING, I BELIEVE THE VEHICLE WOULD BECOME UNSTABLE AND UNCONTROLLABLE WHICH WOULD BE A HAZARD TO THE DRIVER, PASSENGERS AND OTHER MOTORISTS. YES, WE LIVE IN WISCONSIN (PART OF THE SALT BELT), BUT THIS AMOUNT OF CORROSION ON SUCH A CRUCIAL STRUCTURAL COMPONENT IS CRAZY! THE VEHICLE HAS ONLY BEEN ON THE ROAD FOR 14 YRS AND FOR ONLY 117K MI. I WOULD UNDERSTAND IF THE BODY STARTED TO DETERIORATE IN THAT AMOUNT OF TIME, BUT NOT A SUPPORTING FRAME MEMBER. I DON'T BELIEVE THE ENGINE CRADLE WAS PROPERLY TREATED AGAINST CORROSION, OR THE DESIGN OF THE CRADLE MADE IT SUSCEPTIBLE TO EXCESSIVE LOCALIZED CORROSION AND THE MANUFACTURER SHOULD BE HELD LIABLE FOR REPAIRS.

NHTSA ID

11078247

Incident

Mar 4, 2018

Mileage

117,000 mi

CHRYSLER DEALERSHIP SERVICED MY CAR WITH A OIL CHANGE. I WAS TOLD MY CAR WAS UNSAFE TO DRIVE DUE TO MOTOR MOUNT RUSTED. I HAD TO SIGN A PAPERS THAT THIS CAR IS UNSAFE TO DRIVE, THEY CAN'T RELEASE THE CAR TO ME. FRAME IS ROTTED AND UNSAFE TO DRIVE. I DIDN'T EXPECT THIS AND WASN'T READY TO BUY ANOTHER CAR. I DON'T KNOW IF THIS PROBLEM WAS A RECALL FOR CHRYSLER PACIFICA. THANKFULLY I WAS TOLD BEFORE SOMETHING HAPPENED.

NHTSA ID

11055635

Incident

Dec 19, 2017

I HAVE CHRYSLER PACIFICA 2004. HAVE TAKEN GOOD CARE OF VEHICLE, NO ACCIDENTS. VEHICLE BEGAN SHAKING VIOLENTLY WHEN DRIVING DOWN ROAD. I HAVE BRAND NEW TIRES . HAD THEM REBALANCED COUPLE OF TIMES . STILL VIBRATING VIOLENTLY. MY MECHANIC COULD NOT FIND ANY PROBLEMS EXCEPT THAT ENGINE CRADLE FOR ENGINE IS BADLY ROTTED OUT WITH RUST. I LOOKED ON LINE FOR PROBLEM AND SEE THAT CHRYSLER HAD NOT PROPERLY COATED THE ENGINE CRADLE AND HAS LED TO FREQUENT PROBLEMS AND DANGEROUS DRIVING CONDITIONS, DUE THAT THE ENGINE COULD FALL OUT OF VEHICLE. THIS IS OF NO FAULT TO OWNER. I DIDNT FEEL SAFE DRIVING A VEHICLE THAT THE MOTOR COULD FALL OUT OF. THIS IS A SAFETY ISSUE THAT CHRYSLER SHOULD BE RESPONSIBLE FOR. A CONSUMER SHOULD NOT HAVE TO WORRY THAT THERE SEAT BELT OR AIR BAG MIGHT FAIL AND THEY DEFINITELY SHOUDNT HAVE TO WORRY ABOUT THERE ENGINE FALLING OUT OF THERE CAR WHILE DRIVING DOWN THE ROAD, WHICH COULD LEAD TO A WRECK OR FIRE. THANK YOU FOR YOUR TIME AND CONSIDERATION.

NHTSA ID

11021366

Incident

Jul 22, 2017

Mileage

170,000 mi

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. THE CONTACT ARRIVED HOME AND WAS NOTIFIED BY AN EYEWITNESS, APPROXIMATELY 15-20 MINUTES LATER, THAT SMOKE WAS COMING FROM THE VEHICLE. THE CONTACT OBSERVED MAJOR SMOKE AND FLAMES UNDERNEATH THE FRONT OF THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED AND DETERMINED THAT THE FIRE STARTED FROM THE ENGINE AREA. A FIRE REPORT WAS FILED. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES. THE VEHICLE WAS STILL PARKED OUTSIDE OF THE OWNER'S HOME. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. IT WAS NOT DETERMINED WHETHER OR NOT THE VEHICLE WAS DESTROYED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

NHTSA ID

11020522

Incident

Aug 25, 2017

Mileage

100,000 mi

ENGINE CRADLE RUSTED OUT TO THE POINT THE ENGINE DROPPED. MY DAUGHTER WAS DRIVING HOME FROM WORK ON I94WEST OUT OF MILWAUKEE WHEN SHE HEARD A CLUNK. SHE WAS ABLE TO DIVE TO OUR RESTAURANT AND PARK. I HAD THE VEHICLE TOWED TO AN AUTO MECHANIC AND THAT IS WHEN HE TOLD ME THAT IT ENGINE CRADLE WAS RUSTED OUT.

NHTSA ID

11010830

Incident

Jul 9, 2017

Mileage

150,000 mi

ENGINES STALLS INTERMITTENTLY WHILE DRIVING THEN SHUTTERS AND CONTINUES TO RUN. HAPPENS 3 TO 4 TIMES DURING SAY A 25 MILE DRIVE . I FEEL IT IS VERY UNSAFE . ALSO STALLS AT IDLE AT STOP SIGN BUT RESTARTS IMMEDIATELY AND RUNS AS IF NOTHING HAPPENED . I GOT ONLINE TO SEE IF OTHERS HAD SIMILAR PROBLEM AND SEEN OTHER SIMILAR PROBLEMS WHERE THEY SAID IT WAS SOFTWARE RELATED AND HAD TO GO TO DEALERSHIP TO BE REPROGRAMMED.

NHTSA ID

11003802

Incident

Jun 30, 2017

Mileage

109,274 mi

A POPPING SOUND COMING FROM THE FRONT END WHEN TURNING WHILE MAGEING TURNS. IT IS SO LOUD YOU THINK SOMETHING FELL OFF. THIS HAS BEEN HAPPING FOR AT LEAST 4 YEARS I ALWAYS TAKE IT TO THE SHOP AND THEY SAY THEY CAINT FIND ANYTHING WRONG BUT I KNOW IT IS THE SHOP KEEP COMPUTER RECORDS SO I KNOW THEY WILL HAVE THE TIMES I KEPT RETURING WITH THIS PROBLEM IT NEVER DO IT WHEN I TAKE IT SO THEY SAY THEY CAINT DIGONOSE MY PROBLEM. YOU WILL NEVER KNOW WHEN IT WILL MAKE THAT LOUD POPPING SOUND BUT WHEN IT DOSE IT YOU WILL BE STARTELD YOU BECAUSE YOU THINK YOUR WHEEL IS OFF. IT ALSO WILL NOT START OCCASIONALY YOU NEVER KNOW WHEN THIS WILL HAPPEN I REPLACE MY BATTERY EVERY YEAR BECAUSE IT WILL KILL YOUR BATTERY ALL THE TIME .I HAVE REPLACED MY GAS PUMPS THEY WENT OUT 5 YEARS AGO

NHTSA ID

11002610

Incident

Jun 30, 2017

Mileage

900,000 mi

I PURCHASED A USED VEHICLE FROM A LOCAL AUTO DEALERSHIP ON JANUARY 30, 2017. AFTER DRIVING THE VEHICLE EVERYDAY FOR ABOUT A WEEK I BEGAN NOTICED THE CAR WOULD SHAKE AND PULL TO THE LEFT EVEN WHILE DRIVING AT VERY SLOW SPEEDS.ON FEBRUARY 23, 2017 I TOOK THE NEWLY PURCHASED CHRYSLER PACIFICA IN FOR AN OIL CHANGE. I RECEIVED A CALL FROM THE MECHANIC ABOUT 15 MINS AFTER I DROPPED THE VEHICLE OFF AND HE INFORMED ME THAT MY FRONT ENGINE CRADLE WAS SEVERELY RUSTED AND IF I CONTINUED TO DRIVE IT THE ENGINE COULD FALL OUT AT ANY MINUTE. I RUSHED BACK TO THE LOCATION THAT MY VEHICLE WAS BEING SERVICED AND I WAS SHOCKED AT HOW BAD THE ENGINE CRADLE ACTUALLY WAS. THERE WAS AT LEAST AN INCH GAP INDICATING IT WAS BEGINNING TO SEPARATE FROM THE BODY OF THE CAR. I TOOK PICTURES OF THE DAMAGE AND EMAILED THEM TO THE DEALER THAT SOLD ME THE VEHICLE. I ALSO DID A QUICK INTERNET SEARCH FOR FRONT ENGINE CRADLE DAMAGE IN 2004 CHRYSLER PACIFICA'S AND CAME ACROSS NUMEROUS CONSUMER COMPLAINTS HAVING THE SAME ISSUES WITH 2004 PACIFICA'S. I ALSO FOUND CHRYSLER PREVIOUSLY ISSUED AN EXTENDED WARRANTY TO RESOLVE DEFECTIVE ENGINE CRADLES FOR OWNERS RESIDING IN SALT BELT STATES AND VEHICLES WITH UNDER 150K MILES. CONFIDENT THAT MY VEHICLE QUALIFIED FOR THE EXTENDED WARRANTY I CONTACTED CHRYSLER DIRECTLY. I WAS INFORMED BY THE CHRYSLER REPRESENTATIVE THAT THE PACIFICA I CURRENTLY OWN DOES NOT QUALIFY TO RECEIVE REPAIRS UNDER THE EXTENDED WARRANTY BECAUSE IT WAS BUILT IN JANUARY OF 2004 AND WARRANTY ONLY COVERS FRONT ENGINE CRADLE DAMAGE TO VEHICLES THAT WERE BUILT AFTER FEBRUARY 23, 2004 AND BEFORE MARCH 31, 2004.

NHTSA ID

10956671

Incident

Feb 23, 2017

Mileage

124,000 mi

I DROVE TO MY FRIENDS HOUSE, AND 15 MINUTES LATER MY CAR WAS ENGULFED IN FLAMES! THE FIRE CHIEF SAID IT WAS AN ELECTRICAL PROBLEM THAT STARTED THE FIRE. MY CAR WAS NOT RUNNING, AND I WAS NOT IN IT.

NHTSA ID

10945487

Incident

Jan 13, 2017

Mileage

200,000 mi

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. WHILE DRIVING IN REVERSE, A VERY LOUD SCRATCHING NOISE EMITTED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE SEPARATED FROM THE CRADLE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 216,000. THE VIN WAS NOT AVAILABLE.

NHTSA ID

10910585

Incident

May 15, 2016

Mileage

216,000 mi