2002 Dodge Durango

DAIMLERCHRYLSER CORPORATION (DCC) WILL RECALL 35,103 MY 2001-2003 DODGE DURANGO VEHICLES EQUIPPED WITH FRONT BENCH SEATS (RECALL # 06V339, SEE DEFECT REPORT FOR DETAILS).THE SUBJECT VEHICLES ARE EQUIPPED WITH EITHER FRONT BUCKET SEATS OR A 40-20-40 SPLIT FRONT BENCH SEAT.VEHICLES EQUIPPED WITH FRONT BENCH SEAT CONTAIN AN UNCAPPED, UNUSED CONNECTOR LOCATED UNDER THE FRONT EDGE OF THE SEAT.THE CONNECTOR PROVIDES POWER TO THE CENTER CONSOLE POWER OUTLET FOR VEHICLES WITH BUCKET SEATS, BUT IT IS UNUSED IN VEHICLES EQUIPPED WITH BENCH SEATS.THE CONNECTOR IS LOCATED REARWARD OF THE CUP HOLDER ON THE TUNNEL FOR VEHICLES EQUIPPED WITH THE BENCH SEAT.THIS CONNECTOR CONTAINS A FUSED B+ CIRCUIT WIRE (THAT IS CONTINUOUSLY POWERED WITH THE KEY OFF) AND A GROUND WIRE. DCC DETERMINED THAT IF LIQUID IS SPILLED FROM THE CUP HOLDER ONTO THE TUNNEL, THE UNCAPPED CONNECTOR MAY BECOME CONTAMINATED.THIS CONTAMINATION MAY ALLOW DEVELOPMENT OF A HIGH RESISTANCE SHORT CIRCUIT IN THE CONNECTOR, CAUSING LOCALIZED HEATING, WHICH COULD EVENTUALLY LEAD TO A FIRE.DCC WILL INSPECT THE UNCAPPED CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT LIQUID CONTAMINATION.ALL OF THE REPORTED UNDER-SEAT FIRES WERE ON SUBJECT VEHICLES WITH A 40-20-40 BENCH SEAT.THIS INVESTIGATION IS CLOSED.

ODI IS AWARE OF 10 REPORTS ALLEGING THAT A FIRE ORIGINATES UNDERNEATH THE DRIVER'S SEAT.SIX OF THEFIRES OCCURRED WHILE THE VEHICLE WAS PARKED WITH THE IGNITION SWITCH TURNED OFF (KEY NOT IN THE IGNITION).THE SUBJECT VEHICLES ARE EQUIPPED WITH MANUAL SEATS. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, (EA06-011), TO ALLOW FURTHER INVESTIGATION OF THE ISSUE.

DAIMLERCHRYSLER CORPORATION (DCC) IS RECALLING THE TARGET POPULATION OF APPROXIMATELY 600,000 MY 2000 THROUGH 2003 DURANGO AND DAKOTA VEHICLES WITH FOUR-WHEEL DRIVE TO REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS WITH REDESIGNED PARTS THAT DO NOT HAVE THE JOINT INTEGRITY CONCERNS AND HAVE SUBSTANTIALLY IMPROVED JOINT RETENTION CAPACITY (NHTSA RECALL NO. 04V-596).THOUGH DCC DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE.BECAUSE OF THE LOW RATES OF SEPARATION INCIDENTS IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

IN JULY 2003, ODI OPENED PE03-032 BASED ON 4 CONSUMER COMPLAINTS ALLEGING SEPARATION OF AN UPPER BALL JOINT.COMPLAINTS ALLEGED AN UNEXPECTED COLLAPSE IN THE FRONT END AND IN SOME OCCASIONS THE BALL JOINT SEPARATION IS ALLEGED TO HAVE RESULTED IN THE WHEEL, BRAKE ROTOR, AND STEERING KNUCKLE SEPARATING FROM THE VEHICLE.SINCE OPENING THE PE, ODI HAS RECEIVED 23 ADDITIONAL COMPLAINTS RELATED TO BALL JOINT SEPARATION. DAIMLERCHRYSLER HAS IDENTIFIED A WEAROUT CONCERN IN THE SUBJECT BALL JOINTS THAT IS BELIEVED TO OCCUR AFTER WATER INTRUSION EVACUATES THE JOINT LUBRICANT.DAIMLERCHRYSLER DOES NOT BELIEVE THE CONDITION POSES AN UNREASONABLE RISK TO SAFETY BECAUSE THE SUSPENSION DESIGN IN THE SUBJECT VEHICLES SIGNIFICANTLY REDUCES THE LIKELIHOOD OF JOINT SEPARATION.OVER 99 PERCENT OF THE FAILURES ARE RELATED TO WORN BALL JOINTS (E.G., NOISE COMPLAINTS).DAIMLERCHRYSLER REVISED THE REPAIR PROCEDURE IN AUGUST 2003 TO ALLOW THE UPPER BALL JOINTS TO BE SERVICED SEPARATELY FROM THE UPPER CONTROL ARM AND REDUCE REPAIR COSTS. DAIMLERCHRYSLER CHANGED THE SUPPLIER OF THE SUBJECT BALL JOINTS FROM TRW TO NEW CASTLE MACHINING & FORGE FOR MY 2000 VEHICLES.MY 2000 DURANGO VEHICLES ACCOUNT FOR 25 OF THE 37 SEPARATION COMPLAINTS.THE UPPER BALL JOINT WAS REDESIGNED IN MY 2003.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE ALLEGED DEFECT IN MY 2000-02 DURANGO VEHICLES.

I have had my front wheel hub replaced 12 times yet my car isn't part of any recall

NHTSA ID

11668686

Incident

Mar 1, 2020

The hub on my 02 Durango has had to be replaced 8 times since I bought it in 2018 but everyone says my car isn't part of recall.

NHTSA ID

11633843

Incident

Apr 1, 2018

While pulling a travel trailer I got onto the freeway. As I have been pulling the trailer for a while now with this vehicle my comfort speed is around 45mph but will push up to 50mph maybe 55mph at the most. Anyways while entering the freeway I accelerated and as I got ready to merge I let my foot off the gas but the peddle stayed down and the vehicle continued to accelerate until around 80mph to 85mph when I finally got the peddle to release and stop acceleration. I quickly got off the freeway to calm myself as I was terrified I was going to crash. During this incident the first thing I did was tap the brakes lightly which did absolutely nothing and the car kept accelerating next I grabbed the floor mat thinking that maybe it was obstructing the peddle, it was not. Then I quickly used my foot to wiggle under the peddle and pull up multiple times until it finally released and came up stopping acceleration and luckily to my relief I did not crash although I had come very close had there been any more traffic or if I had got going g any faster I may not have been so lucky. This only happened the one time where I got to dangerous speeds but since then the peddle has started to stick two other times but this times it was much easier to get the peddle to release and I wasn't towing a trailer. I read that this happened in another model in freezing temperatures fro. The same manufacturer but couldn't find anything to it without freezing temperatures. I think it is a manufacturer defect that maybe affects other 2002 Dodge Durango I dony know if pulling the trailer triggered this or not as I said it has happened twice since and that was without a trailer attached. Definitely scary and should be looked at.. I don't have the funds to take it to a shop so I haven't had it professionally looked at yet

NHTSA ID

11418981

Incident

Mar 15, 2021

WHEN DRIVING TO THE STORE I SHUT VEHICLE OFF AND WENT IN . WHEN I CAME OUT I CRANKED IT OVER AND IT STARTERED AND THEN CAUGHT ON FIRE BY FIREWALL AND WAS INGOLFED IN FLAMES

NHTSA ID

11376450

Incident

Nov 19, 2020

Mileage

180,000 mi

WHEN DRIVING, THE STEERING WHEEL LOCKS AND THE CAR DIES. IT HAS HAPPEN SEVERAL TIMES WHILE I'M ON THE ROAD. REPLACED CAMSHAFT SENSOR BUT IT IS STILL DYING. IF YOU DO A GOOGLE SEARCH YOU WILL FIND THAT A LOT OF PEOPLE ARE HAVING THE SAME ISSUE. IT IS DANGEROUS AND MY LIFE AND THE LIFE OF OTHERS CAN BE AT RISK. *TR

NHTSA ID

11326992

Incident

May 27, 2020

Mileage

207,239 mi

THE STEERING IS VERY LOOSE. HAS A LOT OF PLAY IN IT. HAVE REPLACED TIE ROD ENDS. AT THIS TIME WE CAN NOT SEEM TO FIND OUT WHAT IS CAUSING IT.

NHTSA ID

11309475

Incident

Oct 1, 2019

Mileage

102,000 mi

AFTER STARTING MY DODGE DURANGO AND TRY TO TAKE IT OUT OF GEAR, THE GEAR SHIFTER GETS STUCK IN PARK, IT WILL NOT MOVE. I HAVE TO KEEP PLAYING AROUND WITH IT UNTIL IT MOVES OUT OF PARK. IT DOES THIS OFF AND ON, JUST STATED THIS ABOUT A COUPLE OF MONTHS AGO. TODAY IS 2/16/2020. YESTERDAY, I LOOKED UP THE PROBLEM ON YOU TUBE, AND FOUND OUT THAT I COULD TAKE THE BOOT OFF AT THE COLUMN BY THE SHIFTER AND SPRAY WD40 ON THE GEAR LOCK TO UNSTICK IT. I DID DO THAT AND IT WORKED. BUT WHAT IS MAKING IT DO THAT TO BEGIN WITH?

NHTSA ID

11309471

Incident

Nov 1, 2019

Mileage

102,000 mi

TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE SPARE TIRE HOLDER WAS CORRODED, WHICH CAUSED THE SPARE TIRE TO DETACH FROM THE HOLDER. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 92,000.

NHTSA ID

11288895

Incident

Feb 15, 2017

Mileage

92,000 mi

Verify Reman part number availability. Order the "R" part number for all orders: Warranty, Mopar, customer pay and service contract. Order "68" part number for New unsold units only.

Plate - Planetary

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.

Disinfectant Solution Recommended for COVID-19

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.