1998 Ford Econoline

ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.

VAN IS LEAKING FUEL FROM A CRACK WHERE IT CONTACTS THE FRAME MEMBER. THIS VAN WAS SUBJECT TO A RECALL BEGINNING APRIL 19, 2001. I DID NOT OWN THE VEHICLE AT THAT TIME, BUT APPARENTLY VEHICLE WAS NOT LEAKING SO IT WAS NOT FIXED. I DO NOT HAVE THE RECALL NUMBER. I OBTAINED THIS INFORMATION FROM A VIN LOOK UP AT HTTPS://DRIVING-TESTS.ORG/VIN-DECODER/ VEHICLE ONLY LEAKS FUEL WHEN FILLING UP AT THE GAS STATION. ONCE I STOP FILLING UP, THE LEAKING WILL DRIP, DRIP, DRIP UNTIL IT STOPS AND I CAN DRIVE OFF. NEXT TIME I WILL TAKE A PICTURE OF LEAKING.

NHTSA ID

11344274

Incident

Jul 8, 2020

WAS TRAVELING ON RT 80 NEAR EXIT 123 IN PENNSYLVANIA ON STRAIGHT ROAD, AT 65 MPH, TEMPERATURE OF 75 DEGREES, DRY, SUNNY DAY. WE HEARD A LOUD BOOM. THE INSIDE REAR TIRE (DRIVER SIDE) HAD BLOWN. IT APPEARED THAT THE SIDEWALL (FACING OUT) HAD FAILED. THE SIDEWALL SEPARATED ALONG A STRAIGHT LINE FROM THE WHEEL TO THE TREAD. ALSO, IN THAT AREA ABOUT 10 INCHES OF TREAD WAS STARTING TO SEPARATE ON THAT SIDE OF THE TIRE - THE TREAD SEPARATION WAS 'CENTERED' ON THAT SIDEWALL FAILURE. FORTUNATELY WE EXPERIENCED NO OTHER DAMAGE.

NHTSA ID

10724174

Incident

Jun 7, 2015

Mileage

31,000 mi

TL* THE CONTACT OWNS A 1998 FORD ECONOLINE E-150. THE CONTACT STATED THAT THE FUEL TANK FRACTURED AND WAS LEAKING FUEL. THE DEALER HAD NOT BEEN NOTIFIED. THE MANUFACTURER WAS AWARE OF THE FAILURE. NO REPAIRS WERE PERFORMED. THE APPROXIMATE FAILURE MILEAGE WAS 79,000 AND THE CURRENT MILEAGE WAS 85,000. THE VIN WAS UNAVAILABLE. UPDATED 08/31/11 *BF UPDATED 2/9/2012

NHTSA ID

10412311

Incident

Nov 1, 2010

Mileage

79,000 mi

TL*THE CONTACT OWNS A 1998 FORD ECONOLINE. THE CONTACT WAS REPLACING THE AIR CONDITIONING BLOWER MOTOR WHEN HE NOTICED THE SPEED SELECTOR SWITCH WAS MELTED. THE FAILURE MILEAGE WAS 240,000 AND THE CURRENT MILEAGE WAS 302,302.

NHTSA ID

10383047

Incident

Oct 31, 2006

Mileage

240,000 mi

1998 FORD ECONOLINE RECALL ON SPEED CONTROL. CONSUMER STATES THAT DEALER DID NOT HAVE THE PARTS AND DID NOT WANT HIM TO MAKE AN APPOINTMENT TO HAVE THIS RESOLVED. HE STATES THAT NO ONE ANSWERED THE 800 NUMBER ON THE RECALL NOTICE. *KB

NHTSA ID

10228508

Incident

Jan 1, 1901

FORD E150 WITH CRUISE CONTROL RECALL. CONSUMER STATES THAT THE DEALER STATED IN SEPTEMBER WHEN THE VEHICLE WAS REPAIRED THAT THE PARTS WOULD BE AVAILABLE IN JANUARY. CONSUMER STATES THAT THE PARTS ARE STILL NOT AVAILABLE. *KB

NHTSA ID

10226213

Incident

Jan 1, 1901

TL*THE CONTACT OWNS A 1998 FORD ECONOLINE. THE CONTACT RECEIVED A RECALL LETTER FOR NHTSA CAMPAIGN ID NUMBER 08V051000 (VEHICLE SPEED CONTROL:CRUISE CONTROL) IN FEBRUARY OF 2008. THE PARTS ARE STILL UNAVAILABLE. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE IS 43,000. UPDATED 4/11/08 *CN

NHTSA ID

10222379

Incident

Feb 13, 2008

1998 FORD ECONOLINE RECALL ON SPEED CONTROL. CONSUMER STATED THAT THE DEALER TOLD THEM THE PARTS WERE NOT AVAILABLE. HE WAS INFORMED THE PARTS WOULD NOT BE AVAILABLE UNTIL THE SECOND QUARTER OF THE YEAR. *KB

NHTSA ID

10220605

Incident

Jan 1, 1901

This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly may cause a perceptible increase in steering effort.

ENGINE OR FUEL SYSTEM CONCERNS WHEN USING FUEL WITH GREATER THAN 5% BIODIESEL CONCENTRATION. *TT

EMISSION RECALL 04E10: COMPRESSED NATURAL GAS (CNG) VEHICLES - FITTING CONNECTOR REPLACEMENT. *MJ

AIR BAG LAMP ILLUMINATED. *TT

SIGNIFICANT CHANGES HAVE BEEN MADE TO THE 7.3L DIT ENGINE EFFECTIVE WITH THE 1998 AND 1999 MODEL YEARS. THE AREAS AFFECTED ARE THE FUEL SYSTEM, HIGH PRESSURE OIL SYSTEM, TURBOCHARGER, AND ENGINE ACCESSORY DRIVE. *TT

SOME VEHICLES EQUIPPED WITH AFTERMARKET MODIFICATIONS MAY EXHIBIT A CRANK BUT NO START OR A HARD START/LONG CRANK CONDITION. *TT