2014 Ford Edge Powertrain (other) Problems

The contact owns a 2014 Ford Edge. The contact stated that while driving at slower speeds, the vehicle hesitated while accelerating with the accelerator pedal depressed, and the vehicle to respond as needed. The check engine warning light was illuminated. The contact stated the vehicle was consuming an excessive amount of fuel, with an abnormal burning metal odor entering the cabin of the vehicle through the air vents. The contact scanned the vehicle with an OBD-2 scanner and retrieved error codes for the Power Control Module, Steering Column Control Module, and Power Train Control Module. The vehicle was taken to a local dealer to be diagnosed; however, the cause of the failure was unknown because the contact had previously cleared the error codes twice. The contact related the failure to Manufacturer Recall: 24E10; however, the VIN was not included. The manufacturer was not made aware of the failure. The failure mileage was approximately 108,000.

NHTSA ID

11680954

Incident

Jun 15, 2025

Mileage

108,000 mi

7/2/25-i was driving about 20 miles per hour when suddenly my car went into a type of limp/idle mode. It shut the car down to an idle, a wrench light came on my dash then the car started to shake. I coasted into a driveway and turned the car off. I turned it back on after 5min and it was fine. 7/16/25-I was driving about 30mph and all of a sudden my car goes into this idle mode again. I got the car to coast over into a turning lane. It lost power down to an idle, wrench came up on dash again then the car started to shake. I turned the car off and back on and it was fine. I’m very scared to drive my car bc I don’t know when this will happen again. It could be when I’m turning in front of another vehicle, driving on the expressway or just normal streets or if someone was behind me and wasn’t able to react appropriately bc my car goes into this idle mode so fast that I don’t know how to keep from having an accident myself. 7/17/25-I took it to a machanic and they hooked it to a computer but nothing showed up as being wrong. They drove it several times but they couldn’t get it to do what I’m explaining what it does. After researching the issue, I believe it may be my electric throttle body ETB that ford acknowledged was an issue and had a customer satisfaction program CPS (CSP 13N03) from Ford for ETB replacement on certain 2009-2013 ,.* Jels, sometimes extended into the early 2014 model. * Electronic Throttle Body Failure * Ford ETBs from this era are notoriously bad. * Carbon buildup, worn internal sensors, or electronic glitches cause the throttle to stick or respond erratically. * The PCM detects an unsafe throttle position → activates fail-safe mode → wrench light + jerking + no throttle. * You restart the car, and the ETB re-initializes until it fails again.

NHTSA ID

11674846

Incident

Jul 2, 2025

Loss of power

NHTSA ID

11672993

Incident

Jul 11, 2025

The Power Take Off Assembly (PTU) failed. I had it replaced a a Ford Dealership with a genuine Ford PTU. After driving less than 125 miles the PTU failed again and my right front half shaft disengaged without notice on the high when traveling at highway speeds. Upon return to the dealership they noted that the PTU failed and it was replaced at no cost. However, they charged me for the replacement of the Right Front Axel. I contacted Ford Customer Service and contend that recall 14S10 should apply especially after the new PTU failed. They denied my claiming stating that the dealership claimed a torn CV Boot was the cause of my axel disengaging. However there was no mention of a torn CV Boot in the dealerships multipoint inspection of my vehicle when originally brought in. Ford Customer Service and the dealership denied my claim.

NHTSA ID

11632439

Incident

Dec 14, 2024

See attached document for complaint.

NHTSA ID

11617869

Incident

Sep 12, 2024

The rear differential has failed. It started to fail at 80,000 miles. The car now has a little over 91,000 miles. It makes a whining/grinding noise at over 30 miles per hour. It was subtle at first but has become much louder recently. If this had failed completely while on the highway going 55 MPH or higher, this could have resulted in complete loss of control of the vehicle. Additionally, oil or parts could have been left on the highway becoming a hazard for other drivers. The local mechanic confirmed that this is the part that needs replacing. There were no warning lights or messages at all. This is a major part of the drivetrain and there are many people on the Internet complaining about premature failure of the differential on the Ford Edge and Lincoln MKX. I am surprised there has not been a recall on this already. Please look into it.

NHTSA ID

11540419

Incident

Aug 16, 2023

Pulled out of a parking lot onto a busy street locally, car lost power and the orange wrench light came on. Would not go, all the car did was jerk and sputter. Engine did not shut off but would only coast/roll into the middle lane and managed to coast/roll into another business parking lot next door to where I pulled out from and once parked, I turned ignition off and back on. Wrench light went out and car started. No codes were apparently shown when hooked up to the machine at the car lot the next day (wrench light was still off) this is very scary and very dangerous whatever it is, it needs investigated and fixed so us Ford edge drivers can feel safe when driving. Also 1 week before this my check engine light came on, same code 3 times came up for eval, emissions ECT... Now no codes are showing since the wrench light came on Sunday and my car stopped moving.

NHTSA ID

11517771

Incident

Apr 16, 2023

Mileage

210,552 mi

Damaged antifreeze pump this can cause a very severe overheating on the road, transfer box and transmission make a very uncomfortable noise when turning to both sides I don't feel safe when handling rear differential the same problem (I've already replaced it)

NHTSA ID

11501749

Incident

Jul 15, 2022

Upon stopping at intersection I began to accelerate to proceed through intersection and no warning light on dash came on as my vehicle wouldn’t go into drive. It barely rolled through and off to shoulder. When I tried to shift into park it wasn’t engaging or something, it just wouldn’t do anything so I lulled the engine and used emergency brake. This could have been a very big tragedy at this or any similar situation.

NHTSA ID

11499726

Incident

Nov 15, 2022

Will not register in park, light says transmission not in park. Door does not register it is closed.

NHTSA ID

11483824

Incident

Aug 2, 2022

This has happened twice on my 2014 Ford Edge. Vehicle goes into limp mode without warning. Did not catch the message, was too busy trying not to get hit. No error codes found. Vehicle restarts and works fine after a short period of sitting. There are multiple reports of this going back 10+ years online. Ford says there is no problem. Computer chip failure? First failure was approximately 10 months ago -

NHTSA ID

11482377

Incident

Sep 1, 2022

The contact owns a 2014 Ford Edge. The contact stated while driving 45 MPH, the vehicle decelerated independently with the check engine warning light illuminated. The contact was able to pull over safely and allowed the vehicle to cool down. The contact restarted the vehicle and the vehicle operated normally. The vehicle was taken to the dealer for diagnostic testing but no failure was found. The failure reoccurred and the vehicle was towed to the residence. The manufacturer was contacted and stated that the VIN was not under recall, and referred the contact to the NHTSA. The failure mileage was 72,500.

NHTSA ID

11480648

Incident

Aug 3, 2022

Mileage

72,500 mi

The contact owns a 2014 Ford Edge. The contact stated upon parking the vehicle in the driveway and releasing the ignition key. The message “Transmission Not in Park” was displayed; even though the gear shifter was in park(P). The contact then moved the gear shifter in and out of park(P) several times until the shift indicator showed that the vehicle was in park(P). The contact stated that the failure had recurred each time she parked the vehicle. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 100,000.

NHTSA ID

11469810

Incident

Jun 3, 2022

Mileage

100,000 mi

The vehicle began emitting a strong smell intermittently, which was later determined to be gear oil from the transfer case dripping down. After the smell was originally noted the car was driven only at low speeds and short distance to get repaired. The car was not able to be put into reverse. Eventually, the car began to make a grinding sound while steering and stopping. Luckily after the strong smells started the car was never driven over 35mph and was only driven for a short distance. I could only imagine if the car was going at highway speeds. This is putting customer's safety at risk. This is a dangerous situation and needs to be resolved. No warning lights illuminated during this ordeal. I was told by the mechanic that the transfer case "blew up" and would need to be replaced. The car has less than 48,000 miles on it and has always been kept in a garage and up to date on service.

NHTSA ID

11462523

Incident

Apr 13, 2022

The rear differential went in the car at only 100,000 miles

NHTSA ID

11448079

Incident

Jan 15, 2022

The contact owns a 2014 Ford Edge. The contact stated while driving at various speeds and making a turn, the rear end of the vehicle made abnormal sounds. The vehicle was taken to the independent mechanic who diagnosed that the half-shaft of the vehicle had detached from the transaxle, and the failure was related to NHTSA Campaign Number: 14V393000 (Power Train). The dealer was not notified of the failure. The manufacturer was notified of the failure and informed the contact that his vehicle could not be repaired under the recall for NHTSA Campaign Number: 14V393000 (Power Train) because the VIN was not included in the recall. The vehicle was not repaired. The approximate failure mileage was 113,000.

NHTSA ID

11436556

Incident

Jun 28, 2021

Mileage

113,000 mi

The following happens roughly a few times a month but cannot be reproduced intentionally…. I pull into my garage, or a parking space, etc and put the car in PARK, the dashboard shows a P for Park but it also shows a message that says car needs to be in park in order to shut off (something a long these lines…) so I have to jiggle it for a few seconds for it to register that it’s in park. It also starts paddle shifting by itself while I am driving!!! I believe what is happening is related to the existing recalls (20V692000 & 14V393000) on Edge’s, but does not include my VIN. Please HELP!

NHTSA ID

11426714

Incident

Jul 26, 2021

I was out of town on the by pass went over a RR track slowly then took back off and heard a popping noise, went about 4 more miles and turned off as soon as I straighten my steering wheel out to head on down the road a big pop and my car stopped hard and jerked us and motor rev up. Got out to see what happened. My front tire was sideways. I’m so glad I had just turned off the by pass (60 mph) and was going slow. The axle and ball joint broke. It scared me to think what could have happened to us.

NHTSA ID

11425164

Incident

Mar 13, 2021

TL* THE CONTACT OWNS A 2014 FORD EDGE. THE CONTACT STATED THAT WHILE HER HUSBAND WAS DRIVING 65 MPH, THE VEHICLE LOSS MOTIVE POWER AND DECELERATED. THE CONTACT'S HUSBAND PULLED OVER TO AN EXIT RAMP WHERE THE VEHICLE STALLED. THE CONTACT AND HER HUSBAND EXITED THE VEHICLE AND PUSHED THE VEHICLE TO A REST STOP. THE CONTACT'S HUSBAND WAITED FOR A MOMENT TO RESTART THE VEHICLE AND CONTINUED DRIVING TO HIS RESIDENCE. THERE WAS NO WARNING LIGHT ILLUMINATED. THE CONTACT'S HUSBAND TOOK VEHICLE TO AN UNKNOWN DEALER TO BE DIAGNOSED WHICH WAS STILL PENDING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 76,000.

NHTSA ID

11403122

Incident

Mar 14, 2021

Mileage

76,000 mi

I HAD SENT YOU A COMPLAINT ABOUT MY VEHICLE. COMPLAINT NUMBER 11384259 STATING THE VEHICLE CPU WAS DEFECTIVE. WHAT I MEANT TO SAY WAS "THE PTU UNIT IS DEFECTIVE"{ POWER TAKE OFF UNIT.}. THANK YOU AND I APOLOGIZE FOR THE MISTAKE.

NHTSA ID

11384266

Incident

Dec 15, 2020

Mileage

46,000 mi

BOUGHT VEHICLE APPROX 1.5 YEARS AGO FROM A CHRYSLER DEALER WITH 28000 MILES. PRESENTLY ABOUT 46000 MILES. WHILE DRIVING AT CITY SPEED, CAME TO A RED LIGHT AND STARTED SMELLING THIS ODOR OF BURNT DIFFERENTIAL FLUID OR ROTTEN EGG SMELL. IMMEDIATELY CALLED DEALER AND MADE APPT, FOR FOLLOWING DAY. WE WERE TOLD IT WAS NOT THE CATALYTIC CONVERTER (WHICH WE THOUGHT IT WAS AND UNDER WARRANTY), BUT IT WAS THE CPU UNIT. WE WERE ALSO TOLD IT WOULD COST US $3000.00 . THE WARRANTY ON THE UNIT IS 5 YEARS OR 60000 MILES. WHICHEVER COMES FIRST. HOW COULD THIS HAPPEN ON A UNIT THAT NORMALLY LASTS A LIFETIME. ESPECIALLY AT 46000 MILES. WE DID SOME RESEARCH BECAUSE DEALER SAID THEY CANNOT WARRANTY OR EVEN CHECK WITH MANUFACTURE ON WARRANTY. WE FOUND THAT THIS IS A COMMON DEFECT WITH THE 2014 FORD EDGE ANF FORD KNOWS THE ISSYE AND WILL NOT DO ANYTHING TO RECALL OR REPAIR ANY OF THESE ISSUES. WE DONT HAVE $3000 DOLLARS TO REPAIR THE ISSUE BUT AM DISAPPOINTED THAT WE HAVE TO MAKE A KNOWN REPAIR ON A VEHICLE BOUTGHT A YEAR AND A HALF AGO THAT SHOULD NOT HAPPEN. THERE HAVE BEEN NEWS REPORTS ON TV ABOUT THIS PARTICULAR ISSUE ON ITS SAFETY . HTTPS://BC.CTVNEWS.CA/MOBILE/FORD-OWNER-FEARS-FOR-HER-SAFETY-AFTER-SERIOUS-CAR-MALFUNCTION-1.3139692 . PLEASE ADVISE AND CHECK THIS NEWS REPORT. RIGHT NOW THIS VEHICLE WE SPENT $22000 THOUSAND IS PARKED AND CANNOT BE DRIVEN BECAUSE IT'S TOO DANGEROUS

NHTSA ID

11384259

Incident

Dec 14, 2020

Mileage

46,000 mi

POWER TRANSFER UNIT LEAKING AFTER 80,000 MILES, HAD THE VEHICLE SERVICED TO REPLACE PTU AND NEW PTU IS ALSO LEAKING. OTHER DRIVING ISSUES HAVE OCCURRED SINCE INCLUDING LOSING POWER STEER CAPABILITY ON WHILE DRIVING AT LOW SPEEDS ON UNEVEN ROADS, UNABLE TO ACCURATELY RECREATE THE ISSUE AS IT IS VERY INTERMITTENT. ALL CHECK ENGINE LIGHTS, WRENCH, AND ADVANCETRAC DASHBOARD WARNINGS FLASH WHEN ELECTRICAL AND PROPULSION SYSTEMS MALFUNCTION.

NHTSA ID

11374594

Incident

Nov 2, 2020

Mileage

92,000 mi

MY VEHICLE LOST POWER. A WRENCH ICON APPEARED ON THE DASH. I WAS ENTERING A GAS STATION SO THE CAR WAS IN MOTION AND I WAS ABLE TO PARK. I LOOKED IT UP AND FOUND OUT IT WAS A THROTTLE BODY FAILURE.. I HAD IT TOWED TO A FORD DEALER. I DIDNT TRUST TO DRIVE IT. FORD COULD NOT DUPLICATE THE ISSUE BUT THE CODE WAS RETAINED.P2111. THE ISSUE WAS NOT COVERED UNDER THE RECALL WHICH WAS DISAPPOINTING. IF IT'S A KNOWN ISSUE IT SHOULDNT MATTER THE YR AND VIN#. IT'S A DANGEROUS ISSUE. IT WAS COVERED UNDER MY EXTENDED WARRANTY LUCKILY AND WAS REPAIRED.

NHTSA ID

11355490

Incident

Sep 14, 2020

Mileage

33,000 mi

VEHICLE LOSSES POWER WHILE TRAVELING ON HIGHWAY AND CITY STREET. MUST PULLL OVER AND RESTART THE VEHICLE. NO SET SPEED. PRESS THE ACCELERATOR PEDAL VEHICLE CREEPS ALONG. VERY CONCERNED WITH THE SAFWTY OF THE VEHICLE TRAVELING ALONG THE HIGHWAY. HAVE SPOKEN WITH THE DEALER AND TWEHY ARE LOOKING INTO IT.

NHTSA ID

11342912

Incident

Jul 30, 2020

Mileage

100,000 mi

FROM A STOP OR AT LOW SPEEDS THE SUV LUNGES FORWARD WITHOUT WARNING. THIS HAS HAPPENED SEVERAL TIMES OVER THE PAST FEW MONTHS. WHEN SUV WAS PURCHASED NEW; THE TRANSMISSION FAILED AND I WAS WITHOUT A CAR FOR THEEE WEEKS. I HAVE MAINTAINED THE SUV AND ALL ISSUED RECALLS HAVE BEEN FIXED. THIS IS A MAJOR ISSUE AND ANYTIME I TAKE IT TO FORD DEALERSHIP THEY FIND NO ISSUE. LET ME TELL YOU; THIS IS AN ISSUE! MY LAST THREE VEHICLES HAVE BEEN FORDS AND WOULD APPRICIATE THIS ISSUE BE SOLVED

NHTSA ID

11331082

Incident

Apr 26, 2020