2014 Ford Expedition

I bought this 2014 ford expedition. I didn't know at the time the Triton 5.4 had a transmission Lead Frame defect. I asked them to cover it under NHTSA 26V237 but they refused because they dsaid it wasn't part of the recall although this vehicle shares the same exact components. I also asked them to cover it under Safety Recall 26S28. I ended up having to pay $1842.00 to get this fixed.

NHTSA ID

11747325

Incident

Jun 29, 2026

While driving on interstate at highway speeds (70mph), the transmission experienced sudden downshift, which increased the engine RPMs to redline and rapidly decelerated the vehicle. Occupant safety was put at risk while other drivers were forced to quickly avoid collision due to our much slower speed. Transmission would not select proper gear which made it difficult to proceed to a safe pull-off point. After restarting the vehicle, the situation repeated itself several times while attempting to drive home. Reoccurring problems include rapid deceleration and high engine revs when transmission suddenly shifts at high speeds, or stalling & lack of acceleration when transmission shifts improperly at low speeds (which makes moving the vehicle safely from the roadway difficult). Researching the problem, it appears to be an issue with the leadframe internal to the 6R80 transmission. Apparently there are safety recalls for other Ford SUVs and trucks with the same leadframe part all related to unexpected transmission shifts.

NHTSA ID

11733946

Incident

Apr 22, 2026

While driving the truck will shift into 1st gear. It will also shift back and forth between gears randomly. When this happens, the wheels may lock up or just skid. The service engine light will come on, the speedometer will drop to zero while still moving and the "miles to empty" will show at zero miles. Sometime the tire indicator will turn on as well. This may/may not reset when the vehicle turns off and back on. Other times the vehicle will stick in first gear when leaving from a stop. It will also stick in 3rd or 4th gear as well. There have been times where it seems to stick like it was on cruise control but will disengage when the brake it tapped. This all occurs anywhere between a stop position and 50 MPH. The problem has been confirmed by a shop as the "Molded lead Frame" in the 6r80 transmission.

NHTSA ID

11726391

Incident

Jan 30, 2025

Minor side impact. All repairs were make and no issues noted

NHTSA ID

11695111

Incident

Jan 16, 2019

Was driving 80MPH down the highway when instantly the rear wheels locked up, green wrench came on dashboard and my car came to a screeching halt. Complete loss of power, and am VERY lucky it did not create a major pile up on the highway! Had to "bunny" hop it over 4 lanes of traffic and barely survived the most terrifying experience of my life. Had it towed and the mechanic shop said the throttle body/actuator had magnetic problem which is VERY common, ARE YOU KIDDING ME?! But there are no recalls on it, and they had to replace the entire unit, and now I am scared to death to drive the vehicle ever again. I am also very lucky it did not happen on snow, ice, or rain!!!!! SO DANGEROUS and SO SCARY!!!! And I could barely hop it out of oncoming traffic.... How can a vehicle go from 80MPH to ZERO in .02 seconds due to a faulty part and there is no recall???? SO GRATEFUL TO BE ALIVE!!!! Ford needs to take some responsibility before there are deaths from a very simple preventative measure due to a part completely failing. After looking it up online I read hundred's of people having the same issue.

NHTSA ID

11687286

Incident

Sep 5, 2025

Backup camera intermittently blacks out or becomes distorted.

NHTSA ID

11687179

Incident

Sep 1, 2025

While driving at highway speeds very quickly the speedometer went to 0 , the fuel low warning came on , the transmission locked up dragging the rear wheels and engine goes to high rpm , this has happened numerous times , I’ve checked with local ford dealership and they tell me there are no updates for my vehicle , when this situation happens I pull over to the side of the road and shut vehicle off , count to ten and restart , drive away and wait for the next instance. I have read where earlier ford products have had this same issue. One additional item on this unit , it has a sporadic 1.5 amp drain that will kill the battery sometimes , very sporadic. Myself and two others have tried to find this drain but unsuccessfully , took to dealership and $500 later still same issue so I found a electronic battery shutoff with a key fob that disconnects the battery to prevent battery draw , but doing this prevents codes from storing , I have recently started leaving vehicle hooked up to automatic tricle charger to prevent battery from being drained so I can get codes stored up for dealership to troubleshoot at a cost to me off $150 to plug up and read codes. Does that come with lube or will that cost extra ?

NHTSA ID

11667713

Incident

Jun 17, 2025

The contact owns a 2014 Ford Expedition. The contact stated while driving at an undisclosed speed, the transmission unexpectedly downshifted. The contact stated that the check engine and Advancetrac warning lights were illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the transmission lead frame needed to be replaced. The contact researched and was became aware of an unknown recall; however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 148,000.

NHTSA ID

11660526

Incident

Apr 12, 2025

Mileage

148,000 mi

Ford and Lincoln vehicles equipped with wired keyless entry keypad systems and accessory wireless keyless entry keypad systems may or may not come with a wallet card containing the master code. Unlike the integrated wired keypad, the accessory wireless keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool or from the label printed on the body control module (BCM). The Factory Keyless Entry Code application within the diagnostic scan tool will not provide an applicable master code for the accessory wireless keypad. If the wallet card for an accessory keypad is not available, the "Wireless RF Keypad Diagnosis Guide" can be referenced and provides direction on how to retrieve the master code. This guide is located under the Workshop Manual tab > Accessories > Installation > Wireless RF Keypad Diagnosis Guide > PPT C > Step C2.<br /><br /> Note: The only available keypad for some vehicles from the assembly plant is the accessory wireless keyless entry keypad. The integrated wired keypad cannot be installed on vehicles not equipped from the factory with a wired keyless entry k

While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions.

This article supersedes TSB 22-2219 to update the Parts List and Service Procedure to clarify applicable steps by vehicle application. Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 (non-Raptor) vehicles equipped with 4WD may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure to remove and cap the vacuum supply line or to reprogram the transfer case control module (TCCM) and replace any worn vacuum and/or IWE components.

All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during initial delivery. Unlike the integrated (wired) factory keypad, the accessory keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool. If the wallet card for an accessory keypad is lost, follow these steps to recover the code. Dealer Key Code access is granted through the Dealer Program Enrollment System (DPES); dealership management can authorize users. The authorized user must go to FMCDealer.com > Parts and Service > Parts Product Line Information > Keys/Entry Devices > Aftermarket Keyless Entry Keypad Code Access. Follow the instructions on the screen to obtain the master code for the accessory keypad.

For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.

Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 (non-Raptor) vehicles equipped with 4WD may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure to remove and cap the vacuum supply line or to reprogram the transfer case control module (TCCM) and replace any worn vacuum and/or IWE components.