2019 Ford F-150 Powertrain (other) Problems

The truck has 55,000 miles on it. The truck shifted very harshly when slowing down creating a traction hazard. The harsh shifting cannot be mitigated by adjusting how it is driven. After a few days a wrench symbol appeared on the dash screen while driving on the interstate, I immediately drove the truck to the Ford dealership after the wrench symbol appeared. Code P07F7 was recovered. I was told that the torque converter is bad and the CDF hub is failing. I was told that the transmission will have to be replaced or rebuilt. The Ford dealerships own transmission specialist showed me how the faulty design is the cause for the break and showed me the new design Ford uses for the replacement parts.

NHTSA ID

11766537

Incident

Sep 20, 2026

The contact owns a 2019 Ford F-150. The contact stated that the vehicle was difficult to shift into gear. The transmission was a hard shifting and vibrating. While driving 35-45 MPH, the transmission unexpectedly downshifted. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where the transmission was flushed and fluids were replaced. After 3 days, the failure reoccurred. The Ford customer service was contacted. The dealer informed the contact that there were no recalls associated with the VIN. The failure mileage was approximately 151,000.

NHTSA ID

11766299

Incident

Aug 1, 2023

Mileage

151,000 mi

2019 f150 with 115,600 miles equipped with 10r80 transmission recently experienced a 10th gear shift down to 1st gear while doing 65mph down a bridge almost causing a really bad accident. Since then truck has randomly and sporadically shifted out of higher gears into lower gears I cannot afford to repair a factory defect.

NHTSA ID

11765705

Incident

Sep 20, 2026

I am writing to formally escalate my ongoing complaint regarding my Ford truck and the repeated problems I have experienced with it over the years. At this point, this is no longer simply a matter of dissatisfaction with a dealership repair. I am asking Ford Motor Company at the corporate level to take responsibility for reviewing the complete history of this vehicle and the repeated unsuccessful attempts to correct the problems I have experienced. Most recently, my truck was brought to **Salem NH Ford on August 25, 2026, because of the ongoing powertrain malfunction and sudden loss-of-power problem**. This was the **fifth time** I have brought the truck in for this same ongoing powertrain problem. The dealership kept my truck for **ten full days**, from August 25 through September 4, 2026. During that time, Ford provided me with a loaner vehicle. I was eventually contacted by the dealership and told that my truck was ready to be picked up. I was also told that they believed they had fixed the powertrain problem. Unfortunately, that was not the case. ### THE POWERTRAIN MALFUNCTION RETURNED ALMOST IMMEDIATELY After picking up my truck on **September 4, 2026**, I began driving it again. Then, on **September 7, 2026 — only three days after picking it up from Ford — the powertrain malfunction happened again**. This was extremely upsetting and frustrating. Ford had my truck for ten days. This was already the **fifth service visit for the same ongoing powertrain problem

NHTSA ID

11765619

Incident

Sep 19, 2026

I had my Transmission serviced at my local Ford dealership. After the service I was told the vehicle may shift "weird" for a while as the computer learns my driving. During this time unbeknown to me the service caused my CDF drum to fail. In the time after the service the vehicle shifted hard, which I though it was "learning" as they stated it would. As I was driving I came to a redlight. When the light turned green I started to make my right hand turn. The vehicle moved into the intersection and then shifted to neutral. During this time the lights indicating the gear started jumping around and finally the transmission went into third gear and started to move. By this time cars were waiting for me to get out of the intersection. I then decided I should not drive the vehicle anymore and get it back to the dealer. Before I reach my residence I have to cross a two lane highway. This crossing is at the bottom of steep decent through woods with lots of turns. There is a turn approximately 600 feet above the crossing. From the time you see a vehicle until it reaches the intersection is about 7 seconds. As I started out into this intersection the transmission went into neutral again and the vehicle came to a stop. Again the shift lights bounced between gears and finally settled in third gear and the vehicle started to move. I am not sure how long I was in the intersection but luckily there was no vehicles in sight. Had one been coming down the hill I probably would have been hit. I then took the vehicle back to the dealer and found out what was actually happening with the transmission. I also found out that these transmissions have a high failure rate for this same issue. Luckily I live in a rural area where there is not a lot of traffic. I feel this issue could be a safety concern and though I should bring it to the NTSBs attention.

NHTSA ID

11763574

Incident

Aug 30, 2026

I reported transmission issue to my dealer years ago. It started when I would start the truck in the morning and put it in reverse. It would do nothing than al of a sudden lunge in reverse. Than it would clear up and not do it for several months. I pretty much got the blow off from the dealer. Cold Oil, linkage sticking bs. Of course, now it’s out of warranty. The transmission shifts hard and even slips out of gear. It stalled tonight at a stop light because it banged into gear. I have less than a hundred thousand miles on this truck. It’s not even safe to drive down the road. You never know when it’s going to shift out of gear . Or lunge forward when it shifts into the next gear.

NHTSA ID

11762928

Incident

Mar 16, 2023

We were about 75 miles from the destination when going down hill the transmission would not shift to the lower gear until we were going to fast and then it would down sift very hard. While going up a hill it would down shift ok but as we got up to speed the transmission would not shift up but stay in the lower gear. Finally at very high RPM it would shift up to the higher gear with a very loud clunk. As soon as we got to our destination we took it to a ford dealer and they said we were lucky because the transmission was on verge of failing completely. Ford has a 60k power train warranty and they said even though it was less than 60K miles my warranty ran out of time 6 weeks ago. If the transmission had failed completely, the car could have had a major safety issue with the trailer behind us. We were not pulling weight more than rated but going up the mountains and the down with only brakes would have been very dangerous. I read that many ford owners are having problems with their 10R80 ten speed transmission in the larger heavy vehicles such as Expedition or F150. Ford Authority reported expeditions pulling trailers have the 10R80 transmission failing after 30K miles.

NHTSA ID

11762924

Incident

Aug 31, 2026

The contact owns a 2019 Ford F-150. While the contact’s husband was reversing at 5 MPH, the transmission slammed hard into reverse. The vehicle was shifting hard into reverse, and the vehicle struck a pole, causing a dent on the rear panel of the vehicle. The dealer was contacted and stated that the vehicle was operated as intended. The failure mileage was approximately 36,000.

NHTSA ID

11762710

Incident

Aug 8, 2026

Mileage

36,000 mi

10 speed cvt transmission. Truck was struggling with 1-3 shift, reving, hesitating, and then jumping. Hard shifts, and clunking. Took it to transmission shop got valve body replacement... less than a week later transmission could not hold 10th at highway speed kept down shifting to 9 and then going back to 10 again and again. After 15 min the display showed it in NO GEAR then 1st GEAR at highway speed and then through a wrench warning light and went into limp mode. Back to transmission shop... cdf drum failure, bad bushings and an over haul to get it back up and running again. 8,000.00. First repair 7-24 second repair 8-22.

NHTSA ID

11760334

Incident

Jul 24, 2026

Despite several transmission services there remains a clunky shift between gears 7 and 8. The problem continues. Other owners of this model have told me that this problem eventually broke their vehicle, and they were left stranded beside the road. Stranded beside the road is a safety risk.

NHTSA ID

11760295

Incident

Mar 30, 2020

My truck has just under 130k miles. Bought it at 18k miles. At 47k miles I had to have the cam phasers replaced and timing chain fixed. At 76k miles the trans (10r80) blew and had it replaced. At 105k miles I had to have the cam phasers replaced again. Multiple times I was denied through ford warranty. And now ford is turning there back after I had it inspected at Koch 33 ford for a reimburment in just the trans! Please help! When the transmission blew I was doing 65mph and it just dropped to first gear and i had a rear wheel lock up and skid all over. After i stopped i had no foward or backwards.

NHTSA ID

11760246

Incident

Aug 28, 2026

The transmission started to clunk into gear very heavily when I started my drive and then as I was driving down the highway going 60mph, the 10r80 transmission suddenly downshifted from 7th gear to 1st gear, and jolted the truck and I lost all power and it took around 5-7 seconds before the throttle was registering again to pick up speed. A car was a ways behind me but if it had been closer, there is no doubt I would have likely been hit. After this happened, in trying to increase speed back to the speed limit, the transmission would not shift back into 7th gear, and a wrench and code popped up on the dash.

NHTSA ID

11758723

Incident

Jul 21, 2026

Beginning approximately one year ago, my Ford F-150 has intermittently experienced a serious transmission problem during acceleration. The transmission appears to momentarily lose the connection between the engine and drivetrain. When this occurs, the truck hesitates or fails to deliver power when I press the accelerator, then suddenly and very harshly engages the next gear. The problem can occur when the vehicle is cold or fully warmed up. This creates a significant safety concern because the vehicle can unexpectedly fail to accelerate when needed, particularly when merging onto a highway, climbing a hill, or accelerating from a traffic light with other vehicles behind me. The sudden, harsh engagement that follows the hesitation is also unexpected and could affect the vehicle's stability or the driver's ability to control the vehicle. I contacted my Ford dealer on August 17, 2026, regarding the problem. The dealer indicated that they are familiar with this type of problem on this transmission and stated that their repair procedure is to replace the entire transmission rather than attempt to repair it. I was told the estimated cost would be approximately $10,000–$12,000. The truck currently has approximately 71,000 miles. Although it is no longer under warranty, I am concerned that a major transmission component is experiencing a potentially serious safety-related failure at this mileage. I believe Ford should investigate this issue and determine whether there is a defect or widespread failure affecting these transmissions. Given the nature of the problem and the potential safety consequences, I also believe Ford should provide financial assistance toward the repair, particularly if this is a known or recurring transmission problem.

NHTSA ID

11757857

Incident

Aug 10, 2026

CDF drum failure and torque converter failure. Started at 70,000 miles by shifting hard going into 8th gear. Now it has completely failed at 81,000 miles. It is a safety concern because now the vehicle goes straight to 4th gear when you shift out the park. Fourth gear is too steep to leave from a stop and can lead to somebody getting rear-ended. This is a well-documented problem for the 10r80 transmission and something needs to be done about it.

NHTSA ID

11757829

Incident

Aug 18, 2026

The contact owns a 2019 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted. There was an abnormal sound coming from the vehicle. The vehicle was pulled over to the shoulder of the roadway. The accelerator pedal was depressed, and the RPM became elevated. The check engine warning light was illuminated, and the vehicle failed to go forward or backwards. The contact stated that the transmission failed to shift into the intended gear. The vehicle was driven to the residence. The contact stated that the failure was persistent. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The contact stated that the vehicle was taken to the dealer several times since being purchased in 2019; however, the failure was not duplicated. The contact stated that the failure was persistent. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 15,407.

NHTSA ID

11757482

Incident

May 14, 2019

Mileage

15,407 mi

The transmission consistently slips, stalls, and shifts very aggressively between gears, specifically between gears 3-4, 7-8, and 6-5. This occurs at various speeds and levels of acceleration. This puts everyone on the road at risk as it makes it difficult to control the speed of the vehicle. Vehicle is available for inspection upon request. This was inspected at a Ford dealership and confirmed to be a problem by the transmission specialist. There are no warming lamps or error messages.

NHTSA ID

11757156

Incident

Aug 14, 2026

The transmission slipped out of gear while entering an intersection. Several slipping issues with transmission and Ford dealers refused to look into issue. They have recalled the 10 speed automatic transmissions for several years but not the mine?

NHTSA ID

11756988

Incident

Apr 17, 2026

What happened is i bought a truck that Ford knows good & well has a defective CDF drum and outer shell but they refuse to issue a recall to fix the transmissions in those year models! Yet in late 2022 they acknowledged the problem and updated the 22+ year models with the correct parts while leaving those of us with the prior 4yrs of trucks out in the cold! My truck is currently undergoing getting a new transmission and it hasn't even reached 70K yet. At 61K I had to have all timing components along with a new oil pump replaced due to the common oil consumption issues on the 13th gen models. Now 8K miles later I'm having to have a new transmission because it started with all the common problems and known issues that everyone else has had with the 13th gen trucks. This is absolutely ridiculous and no if's, and's or but's about it Ford should be liable for it! Every single one of us especially those of us below 100K should be reimbursed. It is a disgrace to own and pay for a vehicle that spends more time at the shop than it does in your driveway! I am fuming mad. Due to my age and health condition this was supposed to be the last vehicle I ever buy yet being on a fixed income I now have a truck that I cannot trust to get me safely to my Dr's appointments or even the local places I have to visit on a weekly basis. Absolutely ludicrous! I have all invoices of all work that has been done and that info has also been put into the Carfax records. The shop i use is very proficient when it comes to recording the information. Within a week once the new transmission is installed I will have that invoice as well as it being loaded into the Carfax records.

NHTSA ID

11756866

Incident

Aug 10, 2026

I bought my 2019 F-150 a few months ago used. Since then it’s been nothing but problems and honestly, terrifying one’s. The truck has shifted and driven rough since I bought it. But on some occasions it goes from rough driving to potentially accident causing. The truck will randomly decide it does not want to shift from a gear, meaning I can’t speed up on busy 95 traffic or move out of the way of aggressive drivers when needed. The truck also will occasionally shift up or down on its own without warning causing me to slow down quickly while already at interstate speeds. At this point, because I have no choice but to drive it to work, it’s a matter of waiting for the day it downshifts too far while in the interstate causing a crash. The fact that I am scared at times to drive my own vehicle and the manufacturer not being willing to fix it is alarming. Alarming because if this is something they can get away with now, what will they get away with in the future.

NHTSA ID

11756385

Incident

Aug 4, 2026

I started noticing hard and delayed shifts from 7th into 8th gear. My RPM's were not increasing when this happened, and then on a very crowded major road I lost all power, vehicle shut off and drifted, then started up and jerked again very hard. This failure could have caused a severe accident and jeopardized the well being of my wife, daughter, her friend and myself along with any other people that could of potentially been involved in a collision if one had occurred. My dash showed no warning lights. After lots of research and consultation with a private owned mechanic shop, I learned the 2019 F150 has a sever and known transmission issue with the learning tables and the transmission control module resulting in failure. Further research reveled a law suit against ford ([XXX] v. Ford Motor Company (Case No. [XXX] in the U.S. District Court for the Northern District of Illinois, targets Ford over alleged defects in the 10R80 10-speed automatic transmissions equipped in 2017–2020 Ford F-150 trucks) regarding this exact issue I was having with my truck, with only 72,000 miles on it! Bob Bell Ford in Glen Burnie Maryland, was less than helpful and the staff was rude when I was explaining what was happening and the information I learned, and quoted me a price of around $12,000.00 to replace the transmission, and that they knew there was a problem with that transmission. I had the vehicle repaired by Glen Burnie Transmission in Glen Burnie Maryland for $8,200.00. That shop told me that they replace several of these transmissions a month (confirming it is a sever issue) and the service tech could tell me what the 8th digit in my vin was based on the symptoms, and he was spot on! I was told the CDF drum and bushings failing—that cause harsh, erratic shifting, sudden lunging, jerking, hesitation, and gear slipping This repair costed me $8200.00 to replace, and another $450 to Bob Bell Ford for them to repeat to me what I already told them. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.

NHTSA ID

11756353

Incident

Jul 10, 2026

vehicle shifted from 1st to 3rd gear and as I accelerated the engine RPMs drastically increased. The transmission jumped from 3rd to 8th gear and then immediately dropped to 1st gear while I was at 40-45 mph. Due to the speed the back tires locked and the vehicle jumped from 1st to 3rd gear and I stopped. Thankfully I did not have a vehicle behind me, or they would have him me. Dealership determine and confirmed hard/harsh shifting between 3rd, 5th, 6th while skipping 4th and 5th. No codes or warnings found upon download by the technician. Technician could not replicate it shifting from high gears to 1st and locking the tires. Recommended and completed adaptive learn procedure, but vehicle is still hard shifting 3rd and 4th gear. Very concerned the vehicle could downshift from higher gears and lock the tires again which will cause an accident.

NHTSA ID

11756184

Incident

Jul 29, 2026

My transmission slips from 3rd to 4th gear and sometimes when on the highway from 7th to 8th or it will get stuck in 7th gear when going 75mph. The check engine light went on once and has been off ever since.

NHTSA ID

11756138

Incident

Aug 10, 2026

I am filing a safety complaint regarding the transmission in my 2019 Ford F-150 equipped with the 5.0L V8 and 10-speed automatic transmission. My vehicle currently has approximately 88,000 miles. The transmission began experiencing abnormal shifting, including skipping/hesitating between gears, harsh shifting, shuddering, and delayed engagement. At times it would appear to skip 2nd gear and go directly into 3rd. I brought the vehicle to a Ford dealership for diagnosis. Ford of Spartanburg performed testing and a road test. Their written diagnosis states that the PCM was tested and had no related DTCs. The technician documented delayed 1-2-3, 2-4 and 3-4 shifts, a 400-500 RPM flare during the 2-4 and 3-4 shifts, and a shudder during the 1-2 shift. The technician checked the transmission fluid and documented that the level was good but that the fluid appeared “super burnt.” The technician further stated “suspect CDF drum bushing shifted” and recommended replacement of the entire transmission assembly. The Ford dealership's estimate for the recommended transmission replacement is $8,737.05. I am concerned that a major internal transmission failure involving the CDF drum/bushing can occur at approximately 88,000 miles and result in delayed, erratic, harsh or unexpected shifting. I am particularly concerned about the potential safety implications if the vehicle unexpectedly loses acceleration or does not respond normally while entering traffic, passing, or traveling at highway speeds. I am requesting that NHTSA document this complaint and investigate whether this represents a broader safety-related defect affecting Ford vehicles equipped with this transmission. I have retained the Ford dealership's diagnostic documentation and can provide it if needed.

NHTSA ID

11756109

Incident

Aug 10, 2026

Shifted into 1st gear from 10th while driving 70mph

NHTSA ID

11756083

Incident

Jul 25, 2026

When driving, especially from a low gear (2-5), the transmission will downshift to 1, high revving, and then slam back into 4 or 5th, depending on where it downshifted. Sometimes the rapid acceleration causes the back of the truck to start to break lose. I notice this alot when trying to get up to speed, and can usually take my foot off pedal and it will slow the vehicle and upshift.

NHTSA ID

11756057

Incident

Dec 23, 2022