2019 Ford F-150 Suspension Problems

While driving on a straight road, flat surface the ball joint failed/broke causing the lower control arm to drop which in turn caused a collapse of the driver side front suspension. The front quarter panel sustained significant damage due to the collapse. It was all I could do to try and keep the truck under reasonable control. The control bar broke off, traveled under the truck causing some damage, to the under carriage, punctured the rear right passenger tire before denting the back right panel behind the wheel where it exited. Fortunately this was in a rural area, early morning so no other vehicles were involved. Should we keep the pieces so they can be tested/inspected

NHTSA ID

11739701

Incident

May 17, 2026

I noticed the rear axel or back suspension on this truck is making a very load uncomfortable sound, like when two pieces of metal are rubbing up against each other... Its under tension and making a bind on the back passenger side. I got the truck with my mechanic few and body/auto repair guy and observed a 1/4 inch UBolt that holds the lead spring I believe hitting up against another bolt on the rear suspension and I cant access or open the drain plug too check the differential. Also there are a lot of loose wires under the dashboard, that already made me trip once, and Im a disabled veteran. Can you please help me get that taken care of?

NHTSA ID

11711897

Incident

Dec 30, 2025

The coil spring on the front end suspension snapped on my Ford F-150. The truck is a 2019 with just over 43,000 miles. The truck has not had any performance or suspension modifications over the life of the vehicle. Coil springs are an essential component of the suspension system, absorbing impacts and maintaining vehicle stability. As the coil spring snapped completely, this is a hazard to the driver of the vehicle and anyone driving alongside the road. The vehicle is now at a independent service center, once they identified the coil had snapped, they contacted me immediately noting the vehicle is no longer safe for driving. There were no warning lamps or messages that arose due to the issue. The only warning sign was a "squeaking noise" at low speeds which I requested the mechanic review when doing a routine oil change.

NHTSA ID

11691619

Incident

Oct 6, 2025

Vehicle sitting in driveway and the left front coil spring broke causing the left front of the vehicle to sag and render undriveable. Fortunately the truck was stationary and no other damage was incurred. This could have been catastrophic if anyone had been driving at highway speeds.

NHTSA ID

11678481

Incident

Aug 4, 2025

Right front coil spring broke, which greatly reduces handling. Repair has made made by local Ford dealer. No warnings.

NHTSA ID

11660822

Incident

May 4, 2025

Passenger front coil spring broke causing vehicle stability and suspension issues at driving speeds. Item is currently available for inspection. Problem has been confirmed as the part is broken in half. No warnings were presented prior to the failure. This appears to be recurring problem around 30k miles on this vehicle according to online forum post [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11544918

Incident

Sep 10, 2023

I HAD JUST RETURNED TO MY WORK. CUSTOMER CAME IN SAID MY TRUCK MADE A NOISE AND RIGHT SIDE DROPPED. AFTER TOWING TO DEALER THEY SAID SPRING FAILED. IF I HAD BEEN DRIVING O WHAT AN ACCIDENT. OTHERS HAVE REPORTED THIS ONLINE BUT I BELEIVE A RECALL SHOULD BE LOOKED AT. WHAT IF MY OTHER SPRINGS FAIL WHILE DRIVING? WHAT IF I DIDNT HAVE EXTENDED WARRANTY THIS IS A SERIOUS CONCERN PS I DRIVE 2 MILES TO WORK MY TRUCK HAS 18700 MILES ON IT

NHTSA ID

11524582

Incident

May 22, 2023

Rear Left Upper Shock Absorber Mount Splintered into three and sheared off. This problem is happening to other late model F-150 owners https://www.f150forum.com/f118/broken-shock-frame-mount-496255/ Someone just posted that the left rear upper shock mount sheared off on his 2022 F-150 FX4 I have no left rear shock and I took it to the Ford dealer and they didn't even attempt to warranty repair the truck. I do not understand anything over the phone due to my hearing, please email me at [XXX] On the evening of March 11, I had just ate dinner at a Italian restaurant and saw my left rear shock absorber laying on the ground. This shouldn't be happening on a truck that is not even five years old and doesn't even have 100,000 miles on it. Ford should be fixing my truck period. This is a safety issue. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID

11514108

Incident

Mar 11, 2023

The tie rod broke while driving causing the truck to collapse and significant damage to the rest of the suspension. There were no warning lights on. The truck has been inspected by a dealer and insurance representative and the damage and cause has been confirmed. This incident put the driver’s and passenger’s safety, including children, and potentially lives in danger.

NHTSA ID

11497867

Incident

Dec 13, 2022

WHEN DRIVING 5 MPH TO 15 MPH AND GOING OVER BUMPS THERE IS A POPPING NOISE FROM THE LEFT FRONT WHEEL AREA. THE WHEEL ALIGNMENT IS ALSO OFF. THE POSITION OF THE STEERING WHEEL IS ABOUT 5 DEGREES TO THE LEFT.

NHTSA ID

11344197

Incident

Jul 12, 2020

Mileage

8,100 mi