RoadVitals

2006 GMC Canyon

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
48
Latest Mar 24, 2025
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
4
Latest Nov 18, 2010
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
5
3 injuries, 0 deaths reported

Overview

Our database contains 48 NHTSA owner-reported complaints for the 2006 GMC Canyon, most frequently naming the electrical, brakes and engine categories. 4 safety recalls have been issued covering this model year; 1 NHTSA investigation names it; and 728 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Electrical1723.0%
  • Brakes1216.2%
  • Engine912.2%
  • Fuel system68.1%
  • Visibility56.8%
  • Body & structure56.8%
  • Interior & seats56.8%
  • Exterior lighting45.4%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

4 campaigns cover this model year

View all 4

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
10V575000

CHILD SEAT

Nov 18, 2010
192,676 units potentially affected
The defect: GM IS RECALLING CERTAIN MODEL YEAR 2004-2011, CHEVROLET COLORADO, GMC CANYON, MODEL YEAR 2006, ISUZU I-280/I-350, AND MODEL YEAR 2007-2008, I-290/I-370, REGULAR CAB VEHICLES AND EXTENDED CAB VEHICLES WITHOUT A REAR SEAT AND EQUIPPED WITH A FRONT 60/40 SPLIT BENCH SEAT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT IS NOT ACCESSIBLE AND THE OWNER MANUAL DOES NOT INCLUDE INSTRUCTIONS REGARDING HOW TO USE THE TOP TETHER.
The risk: BOTH NHTSA AND GM DISCOURAGE PLACEMENT OF A CHILD IN A FRONT SEAT. NEVERTHELESS, THERE ARE INDIVIDUAL CIRCUMSTANCES THAT MAY REQUIRE PLACEMENT OF A CHILD IN A RESTRAINT IN THE FRONT CENTER SEATING POSITION OF THIS VEHICLE THAT DOES NOT OFFER A REAR SEAT. LACK OF ACCESS TO THE TOP TETHER ANCHOR AND A LACK OF INSTRUCTIONS AS TO HOW TO USE IT, MAY RESULT IN IMPROPER INSTALLATION OF A CHILD RESTRAINT. IMPROPER INSTALLATION OF A CHILD RESTRAINT CAN RESULT IN A REDUCTION IN THE RESTRAINT'S PERFORMANCE IN THE EVENT OF A CRASH AND AN INCREASED RISK OF INJURY OR DEATH TO THE CHILD SEATED IN THE RESTRAINT.
The remedy: DEALERS WILL CUT A HOLE INTO THE BACK PANEL TRIM COVER TO ALLOW ACCESS TO THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT POSITION AND WILL PROVIDE SUPPLEMENTAL INFORMATION AS TO USE IN THE OWNER'S MANUAL. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR VISIT GM'S WEBSITE AT WWW.GMOWNERCENTER.COM.
GENERAL MOTORS CORP.Manufacturer number 10367View on NHTSA.gov
09V310000

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

Jul 29, 2009
185,903 units potentially affected
The defect: GM IS RECALLING 185,903 MODEL YEAR 2004-2009 COLORADO, GMC MODEL YEAR 2009-2004 CANYON, MODEL YEAR 2006 I-280, I-350, MODEL YEAR 2007-2008 I-290, AND I-370, PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALABAMA, ARIZONA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, PUERTO RICO, SOUTH CAROLINA, TEXAS, U.S. VIRGIN ISLANDS AND UTAH. SOME OF THESE VEHICLES HAVE A BRAKE LAMP SWITCH THAT MAY NOT WORK AS DESIGNED DUE TO CONTAMINATION IN THE SWITCH.
The risk: THIS CONDITION COULD CAUSE THE SIMULTANEOUS LOSS OF ALL BRAKE LAMPS OR CAUSE ALL OF THE BRAKE LAMPS TO STAY ON CONTINUOUSLY. BOTH OF THESE CONDITIONS COULD FAIL TO WARN OTHERS OF THE DRIVER'S INTENTIONS AND COULD LEAD TO A VEHICLE CRASH.
The remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS AS SPECIFIED IN THE RECALL BULLETIN FREE OF CHARGE. GM ANTICIPATES THAT PARTS WILL BE AVAILABLE BY JUNE 2010. A SPECIAL COVERAGE FOR VEHICLES REGISTERED IN ALL OTHER STATES WILL BE IMPLEMENTED IN THE SAME TIME FRAME. IN THE INTERIM, OWNERS WHO EXPERIENCE THE FAILURE CAN OBTAIN A FREE REPAIR, HOWEVER THEY WILL BE REQUIRED TO RETURN WHEN THE NEW DESIGN PART BECOMES AVAILABLE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.
GENERAL MOTORS CORP.Manufacturer number 09049View on NHTSA.gov
06V139000

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH

Apr 27, 2006
404,733 units potentially affected
The defect: CERTAIN PICKUP TRUCKS MAY EXPERIENCE THE PERMANENT LOSS OF BRAKE LAMP FUNCTION OR BRAKE LAMPS THAT ARE ILLUMINATED AT ALL TIMES. THE CENTER HIGH-MOUNTED STOP LAMP (CHMSL) IS AFFECTED IN BOTH INSTANCES. ALSO, IF EQUIPPED, THE CRUISE CONTROL WILL BECOME INOPERATIVE. ANY TRAILER BRAKE LAMPS WHICH ARE CONNECTED TO THE VEHICLE'S BRAKE LAMP WIRING WILL MIMIC THE VEHICLE'S BRAKE LAMPS WHEN EITHER CONDITION OCCURS.
The risk: A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED, AND A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.
The remedy: DEALERS WILL REPLACE THE BRAKE LAMP SWITCH ASSEMBLY. THE RECALL BEGAN ON DECEMBER 5, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463 OR ISUZU AT 1-800-255-6727.
GENERAL MOTORS CORP.Manufacturer number 06030View on NHTSA.gov

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect.

RQ09001ClosedRecall Query

BRAKE LAMP SWITCH MALFUNCTION

Opened Feb 25, 2009
Closed Jul 30, 2009

ON JULY 28,2009, GM INITIATED A REGIONAL RECALL CAMPAIGN ON CERTAIN MODEL YEAR (MY) 2004-2009 CHEVROLET COLORADO AND GMC CANYON VEHICLES AND MY2006-2008 ISUZU I-SERIES VEHICLES.THE STATES AND U.S. TERRITORIES INVOLVED ARE AL, AZ, FL, GA, HI, LA, MS, NV, NM, PR, SC, TX, VI AND UT.A TOTAL OF 185,903 VEHICLES WILL BE RECALLED WITH 92,272 VEHICLES WITHIN THE SCOPE OF THIS INVESTIGATION.IN ADDITION, A SPECIAL COVERAGE/EXTENDED WARRANTY PROGRAM WILL BE INITIATED FORVEHICLES REGISTERED IN ALL OTHER STATES. GM DETERMINED THAT BRAKE LAMP SWITCH FAILURES ARE MORE LIKELY TO OCCUR IN VEHICLES IN WHICH CUSTOMERS USED INTERIOR CLEANERS CONTAINING SILICON AND THAT RESIDE IN HOT GEOGRAPHICAL LOCATIONS.BRAKE LAMP SWITCH CONTAMINATION FAILURE CAN CAUSE LOSS OF THE BRAKE LAMPS OR THE BRAKE LAMPS TO STAY ON CONTINUOUSLY, INCREASING THE RISK OF REAR-END CRASHES.GM HAS REPORTED NO CRASHES OR INJURIES DUE TO THE FAILURE OF THE BRAKE LAMP SWITCH.ODI INITIALLY REPORTED ONE CRASH INCIDENT, BUT LATER DOWNGRADED THE REPORT DUE TO THE ABSENCE OF ACTUAL PROPERTY DAMAGE OR COST INCURRED WHEN THE VEHICLE WAS LIGHTLY TAPPED FROM BEHIND AT LOW SPEED.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V0310).

EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCHLed to recall 09V310000

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 48
ElectricalEngineFuel system
Filed Mar 24, 2025

The Passlock System intermittently fails and prevents the fuel pump from pumping fuel to the engine. Even after paying GMC to repair the truck, the problem persists.

NHTSA ID
11650301
Incident
Jan 1, 2010
Body & structure
Filed Nov 30, 2023

Frame is severely rusting, especially on the driver’s side. Vehicle has only approximately 75,000 miles and has been well maintained. Purchased new by my Father and when he died, it was passed on to me. I feel it may becoming unsafe to drive.

NHTSA ID
11557682
Incident
Nov 30, 2023
Brakes
Filed Nov 20, 2021

My ABS on Rightside of my truck is not working that is what they said anyways not sure what is wrong

NHTSA ID
11441148
Incident
Nov 1, 2021
Body & structure
Filed Jul 9, 2021

The contact owns a 2006 GMC Canyon. The contact stated that the rear sub-frame was rusted. The vehicle was taken to an independent mechanic however, the vehicle was not diagnosed nor repaired. The local dealer was not contacted. The manufacturer was notified of the failure. The failure mileage was 135,000.

NHTSA ID
11424055
Incident
Dec 1, 2020
Mileage
135,000 mi
ElectricalFuel system
Filed Mar 8, 2021

TL* THE CONTACT OWNS A 2006 GMC CANYON. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, THE VEHICLE FAILED TO START-UP. THE SECURITY WARNING LIGHT WAS ILLUMINATED. THE CONTACT STATED THAT AFTER WAITING AN HOUR, THE VEHICLE RESTARTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH A SECURITY SYSTEM FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FAILURE PERSISTED. THE LOCAL DEALER WAS NOT MADE AWARE OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 264,124.

NHTSA ID
11399758
Incident
Jan 4, 2019
Mileage
264,124 mi
Electrical
Filed Feb 11, 2021

I HAVE A 2006 GMC CANYON AND THE ISSUE IS THE CAR SWITCHES INTO SECURITY MODE A FOR NO REASON VEHICLE WILL NOT START OR WON'T CRANK AT ALL AND IT ONLY GETS WORSE THERE ARE A FEW YOUTUBE VIDEOS SHOWING HOW TO BYPASS SECURITY SYSTEM , BUT I FEEL GM SHOULD SEND OUT NOTICES TO CUSTOMERS ON HOW TO FIX OR DISABLE THIS PROBLEM

NHTSA ID
11395847
Incident
Feb 17, 2007
Mileage
126,000 mi
Filed Dec 20, 2020

I LIFTED THE TRUCK ON A HYDRAULIC LIFT TO FIND THE SOURCE OF A RATTLE THATS USUALLY A HEAT SHIELD THAT HAS COME LOOSE BUT TO MY SURPRISE I ALSO FOUND THE FRAME OF THIS TRUCK HAS LITERAL HOLES ROTTED THROUGH WITH THE RESPECTIVE SUPPORT STRUCTURES FOR THE TRANSMISSION/TRANSFER CASE, FUEL TANK AND FRONT LEAF SPRING ATTACHMENT POINTS. IN SOME PLACES THE FRAME HAS ROTTED AWAY TO MAYBE 40% OF THE FRAME IS STILL INTACT. VERY DANGEROUS. THE AFFECTED AREAS ARE NOT VISIBLE FROM OUTSIDE THE VEHICLE THE DAMAGE IS ONLY VISIBLE FROM UNDERNEATH. FROM OUTSIDE IT LOOKS LIKE TYPICAL SURFACE RUST COMING THROUGH THE UNDERCOATING. BUT THIS IS FAR FROM TYPICAL

NHTSA ID
11384244
Incident
Dec 19, 2020
Mileage
116,000 mi
Brakes
Filed May 10, 2020

ABS FAULT LIGHT IS ON TO INFORM THAT THERE IS A PROBLEM. THIS OF COURSE DISABLES THE ABS BRAKE SYSTEM. THE COMPUTER READS ABS WHEEL SPEED SENSOR. THEY HAVE BEEN REPLACED AND THE LIGHT IS STILL ON. THERE ARE SEVERAL PEOPLE WITH THIS SAME PROBLEM ALL OVER THE INTERNET AND NO ONE HAS FOUND A FIX YET. IS THERE A NEW RECALL ON THIS ISSUE OR IS THERE A WAY TO FIX IT? THANK YOU *TR

NHTSA ID
11324031
Incident
Apr 10, 2020
Mileage
142,000 mi

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

PIP5601C

This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

PIT5074R

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

PIT5074R

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

PIT5074R

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

PIP5358D

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the noise for assessment by engineering. Technician will need to call General Motors Technical Assistance Center for further assistance.

PIT5074Q

This Preliminary Information communication provides information to the technician about the use of J-35616-64B terminal test probe, replacement terminals, and terminated leads. The J-35616-64B is the latest test probe released for checking tension or probing the .64 series terminals. The test probe terminal has been released in the terminal repair kit (J-38125-620H) located in Lear Tray 7 part number 963716-2. There are 5 terminated leads in a package part number is 13505346, which can be ordered through your normal General Motors Customer Care and Aftersales parts channel.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

GMC Canyon by model year
YearComplaintsRecallsInvestigationsIssue Index
2026620—
2025820—
20242053048.8
2023563052.6
2022241045.2
2021112062.3
2020130041.7
2019160042.2
2018521044.7
2017651041.8
20162674054.1
20153018159.3
2013000—
2012232046.7
2011125040.3
2010820—
2009273046.1
2008382046.4
2007423049.2
2006Viewing484155.7
20051133253.3
2004803254.1

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.