2019 Honda Insight

On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehicle deceleration. Honda indicated that it is aware of a total of 412 reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and stated that some customers possibly had an inadequate understanding of the AEB system and its limitations. However, many consumer complaints received by ODI allege that Honda dealerships were unable to reproduce the condition or state that Honda dealerships informed the consumer that this is considered normal AEB operation. To date, ODI has received a total of 106 consumer complaints of inadvertent activation of AEB in the subject vehicles.In total, ODI reviewed 475 reports involving vehicles with unique VINs that may relate to the alleged defect. Of the reports reviewed by ODI, three (3) allege a crash caused by the inadvertent activation of AEB and two (2) allege injury. This Engineering Analysis is being opened to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further, the scope of the investigation is being expanded to include assessment of model year 2023 Honda Passport vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehicle deceleration. Honda indicated that it is aware of a total of 412 reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and stated that some customers possibly had an inadequate understanding of the AEB system and its limitations. However, many consumer complaints received by ODI allege that Honda dealerships were unable to reproduce the condition or state that Honda dealerships informed the consumer that this is considered normal AEB operation. To date, ODI has received a total of 106 consumer complaints of inadvertent activation of AEB in the subject vehicles.In total, ODI reviewed 475 reports involving vehicles with unique VINs that may relate to the alleged defect. Of the reports reviewed by ODI, three (3) allege a crash caused by the inadvertent activation of AEB and two (2) allege injury. This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA25002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further, the scope of the Engineering Analysis is being expanded to include assessment of model year 2023 Honda Passport vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

The car was last driven and parked at about 8:30pm local time. At around noon the next day, we noticed that the dashboard in the vicinity of the passenger airbag was melted with an approximately 12-inch hole. There was soot staining the interior of the vehicle, and the windshield was burned and cracked above the hole in the dashboard.

NHTSA ID

11749854

Incident

Jul 10, 2026

The A/C evaporator failed due to a refrigerant leak caused by corrosion. The component is available for inspection upon request at the dealership where it was diagnosed. The failure resulted in complete loss of air conditioning. In hot weather conditions, particularly during highway driving and stop-and-go traffic, loss of A/C poses a risk of heat-related illness to the driver, especially in high-temperature climates. The defect was confirmed by a Honda dealership technician during an inspection in May 2026. The service advisor explicitly stated that the evaporator is manufactured from the same defective material as the A/C condenser, which Honda already acknowledged as a manufacturing defect under Service Bulletin 21-016. A Honda corporate customer relations representative independently confirmed the same information — that the evaporator shares the same material and is subject to the same corrosion issue. No warning lamps or messages appeared prior to failure. The first symptom was warm air blowing from vents, which progressively worsened until A/C stopped functioning entirely. Honda repaired the condenser under Service Bulletin 21-016 at no charge but refused to cover the evaporator repair, quoting approximately $2,600 out of pocket despite acknowledging the same root cause. I am requesting NHTSA investigate whether a recall or additional service bulletin covering the A/C evaporator on 2019-2021 Honda Insight vehicles is warranted, as other owners are likely experiencing the same defect.

NHTSA ID

11745740

Incident

May 27, 2026

The daytime running lights started to fade it till there was nothing. I was told it would be over $2000 to fix

NHTSA ID

11744642

Incident

Jan 1, 2026

The contact owns a 2019 Honda Insight. The contact stated that while driving 75 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, several unknown warning lights were illuminated. The contact stated that the failure had occurred while driving on a busy highway. The vehicle was driven onto the off-ramp and turned off the vehicle. The vehicle was started; however, the failure reoccurred. The vehicle was taken to the dealer, where it was diagnosed with a corroded connector and broken pin at the leak detection pump in the rear of the vehicle. The contact was informed that the leak detection module and wiring harness needed to be replaced. The vehicle was not repaired. The contact stated that the failure was a known failure with the vehicle. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 81,000.

NHTSA ID

11723037

Incident

Mar 4, 2026

Mileage

81,000 mi

Car was put into reverse to perform a T turn to drive in the opposite direction on 1/14. The "D" button was depressed to place the car into Drive. The car quickly accelerated backwards and crashed into the mailbox. Service Advisor at the David McDavid Honda Dealership was contacted yesterday regarding the issue but no response has been received yet. It is unknown if the backup camera was visible since attempts were being made to try to stop the car. Not much time was allowed.

NHTSA ID

11711072

Incident

Jan 14, 2026

Back up camera stopped working, no blown fuses and the system updates I can do on the car from the touch screen say everything is up to date. My car has no open/not repaired recall for this.

NHTSA ID

11710546

Incident

Jan 12, 2026

The Honda Sensing suite's CMBS uses a combination of a front-facing camera and a radar sensor, it detected a sewerage as a hole and steel plates as a hole and made a sudden unsafe stop. Collision Mitigation Braking System (CMBS™) experiencing a false positive. We were going to like 15-20 over the steel plate and it made an emergency unsafe stop. It keeps doing it over and over. At this point it’s becoming really unsafe so I wanted to report it. It stopped all of sudden and made my neck in pain as my wife’s back. No the problem has not been talked to the dealer or they never told me about this kinds of problems will happen. No any warning lamps.

NHTSA ID

11707040

Incident

Dec 25, 2025

While stopped at a train track, I used the Brake Hold feature and it was on when suddenly without touching peddles the car went forward and I hit the car in front of me

NHTSA ID

11693066

Incident

Oct 10, 2025

Service Bulletin - The ACC system error message comes on while driving when outside temperatures are low/near freezing due to snow and ice getting stuck to the front of the millimeter wave radar. This can cause DTC P2583-76 (Temporary stop of Integrated Driver Support System [Misalignment Millimeter Wave Radar]) to be stored.

Service News - If an Adaptive Cruise Control System Problem comes back on when the vehicle is driven in freezing conditions, inform the customer it is likely due to snow or ice buildup on the radar. Advise the customer of the following procedure to clean the front grille where the radar is located.

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for any & all 2018-2022 Accord Hybrids, 2020-2022 CR-V Hybrids & 2019-2022 Insights that match the criteria listed below. Qualifiers AHM is interested ONLY if the vehicle meets the following requirements: 1. Manufactured date on the Driver’s door jamb must be between 1/2019 & 9/2021. 2. No DTC stored. 3. Electric Servo Brake (ESB) system has not been replaced previously.

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for any & all 2018-2022 Accord Hybrids, 2020-2022 CR-V Hybrids & 2019-2022 Insights that match the criteria listed below. Qualifiers AHM is interested ONLY if the vehicle meets the following requirements: 1. Manufactured date on the Driver’s door jamb must be between 1/2019 & 9/2021. 2. No DTC stored. 3. Electric Servo Brake (ESB) system has not been replaced previously.

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for any & all 2018-2022 Accord Hybrids, 2020-2022 CR-V Hybrids & 2019-2022 Insights that match the criteria listed below. Qualifiers AHM is interested ONLY if the vehicle meets the following requirements: 1. Manufactured date on the Driver’s door jamb must be between 1/2019 & 9/2021. 2. No DTC stored. 3. Electric Servo Brake (ESB) system has not been replaced previously.

Dealer Message - American Honda Motor Co., Inc. (AHM) is searching for any & all 2018-2022 Accord Hybrids, 2020-2022 CR-V Hybrids & 2019-2022 Insights that match the criteria listed below. AHM is interested ONLY if the vehicle meets the following requirements: 1. Manufactured date on the Driver’s door jamb must be between 1/2019 & 9/2021. 2. No DTC stored. 3. Electric Servo Brake (ESB) system has not been replaced previously.