2012 Lexus IS

The dashboard (instrument panel) on this 2012 Lexus IS 250 has degraded and deteriorated, developing a shiny, reflective surface. In daylight and bright conditions, this degraded surface reflects onto the windshield and produces a significant glare that obstructs the driver's view of the road. The glare materially impairs forward visibility and makes safe operation of the vehicle dangerous, particularly given the driver's reduced tolerance for compromised visibility. This is a known and widespread defect. Lexus formally acknowledged the cracking/melting dashboard condition through Customer Support Program ZLZ, which covered approximately 584,800 vehicles. The defect is understood to result from the dashboard material breaking down over time due to heat exposure. Numerous owners of affected Toyota and Lexus vehicles have reported the identical hazard to NHTSA: a degraded dashboard casting a glare on the windshield that impairs the driver's view. In this vehicle, the condition did not manifest until 2025–2026 — after the support program's coverage window had closed — which is consistent with the latent, heat-driven nature of the defect. The owner contacted Lexus and requested repair. Lexus declined, stating the vehicle was outside the program's coverage limits, and on escalation confirmed it would not take responsibility. The owner is filing this report because the condition is an active safety hazard affecting road visibility, not merely a cosmetic issue, and because Lexus has declined to remedy it despite having formally recognized the defect across hundreds of thousands of vehicles. No crash / no injury / no fire (assuming that's accurate — the form will ask; answer honestly).

NHTSA ID

11755221

Incident

Jul 6, 2026

2012 Lexus IS 250 Complaint Category: Interior/Seat Belts/Air Bags → Interior Component: Interior Moldings/Trim/Panels Narrative This is a safety issue. The dashboard on my 2012 Lexus IS 250 has developed significant cracking and is actively decomposing into a gelatin-like texture, despite the vehicle being garage-kept, low mileage, and well-maintained throughout my ownership. This is not the result of any accident, impact, or misuse — it appeared spontaneously and has progressively worsened. The degrading dashboard material is emitting fumes, which are causing a haze to form on the interior surface of the windshield. This directly impairs driver visibility, particularly at night, creating a glare and obstruction hazard while driving. Lexus acknowledged this as a known defect by establishing Customer Support Program ZLZ, which provided extended coverage specifically for dashboard, instrument panel, and interior trim panel cracking on certain Lexus models. The existence of this program confirms that Lexus was aware of a systemic manufacturing or materials defect affecting these vehicles. My vehicle fell outside the ZLZ coverage window by a matter of months. Despite my appeal to Lexus National Headquarters citing my long-term ownership, the vehicle's low mileage, and the timing of the condition's appearance, Lexus has declined to provide any assistance and has stated this is their final position. Supporting Witness Statement [XXX], a window tinting professional, inspected the windshield and dashboard on XXX, at my residence. He observed that the dashboard surface has deteriorated to a gelatin-like, decomposing texture, and assessed that the haze visible on the interior of the windshield is consistent with off-gassing from the degrading dashboard material, rather than from window tint film, cleaning residue, or normal glass wear. (Contact: [XXX]) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11748952

Incident

Jul 7, 2026

The dashboard on my 2012 Lexus IS 250 has developed significant cracking across the surface despite the vehicle being garage-kept, low mileage, and well-maintained throughout my ownership. The cracking is not the result of any accident, impact, or misuse — it appeared spontaneously and has progressively worsened over time. Lexus acknowledged this as a known defect by establishing Customer Support Program ZLZ, which provided extended coverage specifically for dashboard, instrument panel, and interior trim panel cracking on certain Lexus models. The existence of this program confirms that Lexus was aware of a systemic manufacturing or materials defect affecting these vehicles. My vehicle fell outside the ZLZ coverage window by a matter of months. Despite my appeal to Lexus National Headquarters citing my long-term ownership, the vehicle’s low mileage, and the timing of the condition’s appearance, Lexus has declined to provide any assistance and has stated this is their final position. I am filing this complaint to document this defect and contribute to the record of affected owners. Dashboard cracking of this nature is not only a cosmetic issue — a deteriorating dashboard can cause glare, distraction, and potential visibility impairment for the driver, which raises legitimate safety concerns. I am requesting that NHTSA review whether Customer Support Program ZLZ adequately addressed the full scope of affected vehicles and owners, and whet

NHTSA ID

11745928

Incident

Jun 23, 2026

The dashboard is sticky/melting causing it to be extremely shiny. It is available for inspection upon request. Due to the shininess of the dashboard, it causes a glare on the windshield during the daytime. This glare causes difficulty with being able to safely see through the windshield.

NHTSA ID

11593384

Incident

Sep 4, 2023

I own a Lexus 2012 IS250 and currently active duty member stationed at Aviano Air Base, Italy. I was not notified that my vehicle is overdue on a safety recall until today when I am trying to ship the vehicle back to the US. What further actions can I do to get the recall done? Can I get the vehicle waivered to get the recall accomplished when it reaches the US?

NHTSA ID

11454221

Incident

Feb 25, 2022

While stopped at a stop light vehicle RPM went very high. It reached the red zone. Vehicle started moving forward (while still on Drive and the brake pedal fully pressed). I immediately put the vehicle in Park. RPM continued to remain high. I removed my foot off the brake when the vehicle was in park. I turned the engine off, waited couple of seconds and turned it back on. At that point everything worked normally. Outside temperature was about 38 deg F. Car was not fully warmed up at the time. Floor mat had nothing to do with this incident. After restarting the engine it is working fine without any adjustment to the floor mat. Incident could have resulted in major crash or injury. Luckily it happened when the vehicle was stopped at at red light. Putting the car in PARK and turning off the engine resolved the issue. This is a serious issue on 2012 IS250. Check engine light is not on. Vehicle will be taken to the Lexus dealer for checking. If the car was in drive, this kind of revving up of the engine would have caused serious accident. Also, if I had not put the car in Park, it would have overcome the braking power and pushed the car to the intersection at red light. Engine RPM went way too high (in the red zone). This is the first incident. This 2012 Lexus IS250 has 69364 miles.

NHTSA ID

11446748

Incident

Jan 8, 2022

VEHICLE IN MOTION GOING 80MPH ON HIGHWAY WHEN SUDDENLY JOLTED AND VEHICLE DID NOT RESPOND TO ACCELERATOR AND CHECK ENGINE/BATTERY LIGHTS ALL CAME ON AND SLOWED TO A STOP. RESTARTING ENGINE DID NOT WORK AS IT SPUTTERED AND WENT BACK TO IDLE IMMEDIATELY. FUEL TANK WAS 1/4 FULL, NOT DUE FOR OIL CHANGE FOR ANOTHER 4000 MILES, TIRE PRESSURE WAS FIXED A DAY PRIOR TO INCIDENT, AND NO OTHER PROBLEMS WITH THE VEHICLE. CAR TOWED TO TOYOTA DEALERSHIP WHERE THEY TESTED AND SAID FUEL PUMP MALFUNCTION. TOYOTA AND LEXUS ALREADY HAVE 2 MILLION CARS WITH FUEL PUMP RECALL, HOWEVER MY SPECIFIC MODEL IS NOT INCLUDED YET.

NHTSA ID

11376646

Incident

Nov 26, 2020

Mileage

96,129 mi

LEXUS IS250 HAS A MELTING DASHBOARD AND IT'S REALLY HARD TO DRIVE WHEN THE SUN IS OUT ... IT GLARES OUT YOUR VISION WHEN DRIVING ...I WAS RESEARCHING AND SAW SOME PEOPLE GOT A RECALL FOR THE MELTING DASHBOARD SINCE IT'S REALLY UNSAFE TO DRIVE IT WITH THE DASHBOARD STARTING TO MELT .. IN THE PICTURE I ADDED YOU CAN SEE HOW MY DASHBOARD IS SHINY BECAUSE ITS MELTING AND STICKY TOO

NHTSA ID

11363776

Incident

Mar 19, 2020

Some 2005 – 2026 Lexus vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Service Bulletin is to provide general guidelines and procedures for odor remediation. This Service Bulletin provides a guide on how to prepare and treat the interior of the vehicle for odor remediation. Refer to the applicable model and model year Repair Manuals and the EPA (Environmental Protection Agency) website for the most up-to-date safety and precautionary guidelines. This Service Bulletin is to provide a general overview and direction for the odor remediation process.

Some 2016 – 2020 model year GS F, 2008 – 2014 model year IS F, 2022 – 2025 model year IS 500, 2018 – 2025 model year LC 500, 2021 – 2025 model year LC 500c, and 2015 – 2025 model year RC F vehicles with 2UR-GSE engines may exhibit a MIL ON condition with one or more of the following Diagnostic Trouble Codes (DTCs): •P0505 – Idle Control System •P2111 – Throttle Actuator Control System – Stuck Open The throttle body assembly with motor and ventilation hoses no. 2 and no. 3 have been modified to address these conditions.

Some 2010 – 2026 model year Lexus vehicles may exhibit paint stains after the removal of Rapgard™. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard™. The wrinkles may trap water and cause the paint to stain from the trapped moisture, especially on horizontal surfaces such as the hood, roof, and trunk.

Some 2010 – 2026 model year Lexus vehicles may exhibit paint stains after the removal of Rapgard™. The paint stains may appear to be under the clear coat but are usually under wrinkles in the Rapgard™. The wrinkles may trap water and cause the paint to stain from the trapped moisture, especially on horizontal surfaces such as the hood, roof, and trunk.

Some 2005 – 2024 Lexus vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Service Bulletin is to provide general guidelines and procedures for odor remediation. This Service Bulletin provides a guide on how to prepare and treat the interior of the vehicle for odor remediation. Refer to the applicable model and model year Repair Manuals and the EPA (Environmental Protection Agency) website for the most up-to-date safety and precautionary guidelines. This Service Bulletin is to provide a general overview and direction for the odor remediation process.

Some 2005 – 2024 Lexus vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Service Bulletin is to provide general guidelines and procedures for odor remediation. This Service Bulletin provides a guide on how to prepare and treat the interior of the vehicle for odor remediation. Refer to the applicable model and model year Repair Manuals and the EPA (Environmental Protection Agency) website for the most up-to-date safety and precautionary guidelines. This Service Bulletin is to provide a general overview and direction for the odor remediation process.