2009 Lincoln Navigator

DOES NOT GIVE ME ANY INFO ON ANY VIN NUMBER IS PUT IN. GET THE 4 COLORED BLOCKS CIRCLING AND THEN STATES LOOKING FOR MORE INFORMATION ON THIS VEHICLE? NHTSA OFFERS MORE SAFETY INFORMATION BASED ON A VEHICLE'S YEAR, MAKE AND MODEL. CHECK SAFETY RATINGS, RECOMMENDED TECHNOLOGIES AND OTHER SAFETY ISSUES.

NHTSA ID

11414250

Incident

Apr 28, 2021

WHEN BRAKING WHILE MOVING (AT ANY SPEED), THE BRAKE PEDAL BEGINS BRAKING AT ITS NORMAL PRESSURE POINT AND THEN SINKS TO THE FLOOR WITH REDUCED BRAKING EFFECT. SUNNYVALE LINCOLN HAS CHECKED THE WHOLE SYSTEM FOR LEAKS AND BLED SOME VERY TINY AIR BUBBLES OUT OF THE ABS CONTROL MODULE. THE PROBLEM RETURNED AFTER ABOUT FOUR DAYS. THEY REPLACED THE HCU LINES BECAUSE SOME VERY MINOR "WETNESS" WAS FOUND AT THE CONNECTORS AND BLED THE ABS CONTROL MODULE AGAIN. THE PROBLEM RETURNED AGAIN AFTER ABOUT FOUR DAYS. WE HAVE DONE THREE CYCLES OF THE BLEEDING NOW AND THIS FIXES THE PROBLEM, BUT ONLY FOR FOUR DAYS. SUNNYVALE LINCOLN IS CURRENTLY TRYING TO FURTHER DIAGNOSE THE PROBLEM. THE NAVIGATOR ONLY HAS 32,000 MILES ON IT AND HAS ONLY BEEN SERVICED BY THE DEALER. I AM AFRAID TO DRIVE IT UNTIL THE PROBLEM IS PERMANENTLY RESOLVED. THESE SYMPTOMS SOUND VERY SIMILAR TO THE F-150 BRAKE INVESTIGATION. THE NAVIGATOR USES THE F-150 BRAKE SYSTEM.

NHTSA ID

10840311

Incident

Nov 24, 2015

Mileage

31,000 mi

THE VEHICLE RANDOMLY GETS STUCK IN PARK AND IS UNABLE TO SHIFT INTO GEAR WHEN THE VEHICLE IS STATIONARY. I READ SOMETHING ABOUT THE BREAK SWITCH RECALL BUT AFTER CALLING FORD THEY TOLD ME THE RECALL WAS VIN SPECIFIC AND MY VEHICLE WASN'T A PART OF IT. MAKES NO SENSE TO ME IF MY VEHICLE IS DOING EXACTLY WHAT THE RECALL ENTAILED.

NHTSA ID

10819366

Incident

Dec 2, 2015

Mileage

75,000 mi

FRONT PASSENGER WINDOW WILL NOT OPEN OR CLOSE. IF ATTEMPTED, WINDOW WILL MAKE CRACKING NOISE.

NHTSA ID

10730442

Incident

May 1, 2015

Mileage

94,700 mi

WHEN AIR CONDITION IS SET BELOW 72, PASSENGER FRONT SIDE IS MAKING LOUD CLICKING NOISE FOR ABOUT 1 MINUTE THEN GOES AWAY.

NHTSA ID

10730441

Incident

Feb 16, 2015

Mileage

93,000 mi

WHEN DRIVING FROM UP GRADE AT ABOUT 1200 RPM, THERE IS A RATTLE NOISE COMING FROM ENGINE

NHTSA ID

10730434

Incident

Oct 9, 2014

Mileage

90,500 mi

TL* THE CONTACT OWNS A 2009 LINCOLN NAVIGATOR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT HORN FAILED TO RESPOND WHEN ENGAGED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE WIRES CONNECTED TO THE HORN NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 57,114.

NHTSA ID

10487980

Incident

Dec 10, 2012

Mileage

57,114 mi

WHILE UNLOADING THE BACK OF MY TRUCK, I WAS BURNED BY THE TAIL PIPE THAT PROTRUDES FROM THE BACK RIGHT SIDE OF THE TRUCK. THE BURN IS A 1/2 ROUND SHAPE ON MY RIGHT LEG. TOOK THE TRUCK IN FOR SERVICE AND LINCOLN DEALERSHIP SAID THAT IS HOW IT WAS DESIGNED FOR MY MODEL YEAR AND NO FIX WAS AVAILABLE. I HAVE REPORTED THE PROBLEM TO LINCOLN BUT HAVE NOT HEARD BACK FROM THEM AS OF THIS WRITING. *TR

NHTSA ID

10410348

Incident

Jun 8, 2011

Mileage

23,000 mi

Ford and Lincoln vehicles equipped with wired keyless entry keypad systems and accessory wireless keyless entry keypad systems may or may not come with a wallet card containing the master code. Unlike the integrated wired keypad, the accessory wireless keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool or from the label printed on the body control module (BCM). The Factory Keyless Entry Code application within the diagnostic scan tool will not provide an applicable master code for the accessory wireless keypad. If the wallet card for an accessory keypad is not available, the "Wireless RF Keypad Diagnosis Guide" can be referenced and provides direction on how to retrieve the master code. This guide is located under the Workshop Manual tab > Accessories > Installation > Wireless RF Keypad Diagnosis Guide > PPT C > Step C2.<br /><br /> Note: The only available keypad for some vehicles from the assembly plant is the accessory wireless keyless entry keypad. The integrated wired keypad cannot be installed on vehicles not equipped from the factory with a wired keyless entry k

This article supersedes TSB 22-2219 to update the Parts List and Service Procedure to clarify applicable steps by vehicle application. Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 (non-Raptor) vehicles equipped with 4WD may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure to remove and cap the vacuum supply line or to reprogram the transfer case control module (TCCM) and replace any worn vacuum and/or IWE components.

All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during initial delivery. Unlike the integrated (wired) factory keypad, the accessory keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool. If the wallet card for an accessory keypad is lost, follow these steps to recover the code. Dealer Key Code access is granted through the Dealer Program Enrollment System (DPES); dealership management can authorize users. The authorized user must go to FMCDealer.com > Parts and Service > Parts Product Line Information > Keys/Entry Devices > Aftermarket Keyless Entry Keypad Code Access. Follow the instructions on the screen to obtain the master code for the accessory keypad.

For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.

Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 (non-Raptor) vehicles equipped with 4WD may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure to remove and cap the vacuum supply line or to reprogram the transfer case control module (TCCM) and replace any worn vacuum and/or IWE components.

Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 vehicles equipped with TOD transfer cases may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure steps to remove and cap the vacuum supply line.