2000 Lincoln Navigator

ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.

IN ITS LETTER DATED JANUARY 27, 2005 TO ODI, FORD INDICATED THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL # 05V-017) TO REMEDY AN OVERHEATING SPEED CONTROL DEACTIVATION SWITCH IN APPROXIMATELY 738,490 SUBJECT VEHICLES.THE VEHICLES AFFECTED BY THE RECALL ARE CERTAIN 2000 MODEL YEAR (MY) FORD F150, FORD EXPEDITION AND LINCOLN NAVIGATOR EQUIPPED WITH SPEED CONTROL AND CERTAIN 2001 MODEL YEAR F150 SUPERCREW VEHICLES BUILT THROUGH AUGUST 7, 2000.SINCE OPENING PE04-078, ODI HAS IDENTIFIED OTHER REPORTS OF KEY OFF ENGINE COMPARTMENT FIRES IN FORD VEHICLES WITH SIMILAR SPEED CONTROL DEACTIVATION SWITCHES THAT WERE NOT THE SUBJECT OF THIS PRELIMINARY EVALUATION OR FORD'S RECALL 05V-017.FORD'S RESPONSE TO THE ODI INFORMATION REQUEST LETTER DATED DECEMBER 3, 2004, PROVIDED AN ADDITIONAL 107 ALLEGATIONS OF KEY OFF ENGINE COMPARTMENT FIRES THAT WERE ALSO IN VEHICLES NOT SUBJECT TO THIS INVESTIGATION OR INCLUDED IN THE FORD RECALL 05V-017.AN ENGINEERING ANALYSIS (EA) IS WARRANTED TO DETERMINE IF A SAFETY DEFECT TREND EXISTS RELATING TO KEY OFF ENGINE COMPARTMENT FIRES IN VEHICLES OUTSIDE THE SCOPE OF THIS PRELIMINARY EVALUATION.ODI WILL EXPAND THE SCOPE OF IT'S INVESTIGATION AT THE EA PHASE TO INCLUDE THE 1995 THROUGH 2002 MODEL YEARS OF THE FORD F150, FORD EXPEDITION AND LINCOLN NAVIGATOR VEHICLES.

ON OCTOBER 4, 2017 AT APPROXIMATELY 3:45 PM, I DEPARTED FROM THE SACRAMENTO CHILDREN'S HOME THROUGH AN ADJACENT ALLEY TRAVELING THROUGH THE SOUTH BOUND ENTRANCE. AS I MADE THE LEFT TURN INTO THE ALLEY AS I GRADUALLY GOT UP TO SPEED MY VEHICLE SUDDENLY BEGAN TO ACCELERATE. I WAS STARTLED BY THE SUDDEN INCREASE OF SPEED AND IMMEDIATE MADE AN ATTEMPT TO PUT THE VEHICLE IN NEUTRAL AND SHUT THE VEHICLE DOWN AND APPLY THE BRAKES. BEFORE I COULD MAKE THE CORRECTIONS THE VEHICLE HAD VEERED OFF TO THE LEFT HAND SIDE OF THE ALLEY AND STRUCK AN OAK TREE. TO MY GUESS THE VEHICLE WAS TRAVELING AT A RATE OF SPEED OF ABOUT 25-30 MPH. ON IMPACT I SLAMMED INTO MY MOTOROLA SPEAKER THAT WAS ATTACHED TO MY SUN VISOR AND SPLIT MY HEAD OPEN WHICH REQUIRED 8 STAPLES TO CLOSE.

NHTSA ID

11032090

Incident

Oct 4, 2017

Mileage

290,000 mi

TL* THE CONTACT OWNS A 2000 LINCOLN NAVIGATOR. WHILE DRIVING 65 MPH SPEED AND TAKE YOUR FOOT OF THE GAS PEDAL AND CAR CONTINUES TO GO 65 MPH ALL OF SUDDEN NO POWER STEERING OR POWER BRAKES. IN ADDITION, THE CONTACT STATED THAT THE ELECTRICAL SYSTEM FAILED TO OPERATE INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000. THE CONSUMER STATED THE VEHICLE CONTINUED TO GO 65 MPH, EVEN WHEN HE REMOVED HIS FOOT FROM THE ACCELERATOR. THE RPM METER AND THE MOTOR SPEED DROPPED DOWN TO 500 RPM AND THE ENGINE SHUT OFF. THERE WAS NO POWER STEERING AND NO POWER BRAKES, BUT THE VEHICLE CONTINUED GOING 65 MPH. ALSO, THE RADIO AND AIR CONDITIONER BURNED OUT. THE DEALER STATED THE BURN HAPPENED INSIDE THE WIRE HARNESS. UPDATED 03/08/17.*JB...UPDATED 03/08/17 *BF UPDATED 09/18/2017*JS THE CONSUMER STATED THE RADIO, AC-FANS, TURN SIGNALS, ELECTRIC WINDOWS, BRAKE LIGHTS, TURN SIGNALS, HAZARD LIGHTS, TAIL GATE, WINDOW WIPER, ACTUATOR, OVER HEAD STOP LIGHT, DOOR LOCK, THE TAIL GATE WOULD NOT OPEN, AIR SPRINGS/AIR COMPRESSOR, HEATER CONTROLS, AND THE WIRE FUSE CAUSED A FIRE. *JS *TR

NHTSA ID

10939175

Incident

Jan 1, 2017

Mileage

115,000 mi

VEHICLES WIPERS WILL NOT CUT OFF. WIPER MOTOR SMOKES BAD FROM UNDER HOOD.

NHTSA ID

10893538

Incident

Aug 4, 2016

TL* THE CONTACT OWNS A 2000 LINCOLN NAVIGATOR. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE VEHICLE STARTED SHAKING. THE VEHICLE WAS TAKEN TO THE DEALER, WHO APPLIED PINS ON THE SUSPENSION AND REPLACED THE TIRES BUT THE FAILURE RECURRED. THE CONTACT ALSO STATED THAT THERE WAS A CRACK ON THE WHEELS THAT CAUSED THE BOLT JOINTS TO FAIL. THE CONTACT ALSO STATED THAT THE AIRBAG WARNING LIGHT WAS ILLUMINATED AND THE AC AND HEAT WAS INOPERABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 124,000.

NHTSA ID

10617197

Incident

Jul 6, 2004

Mileage

124,000 mi

VEHICLE WAS PARKED AND TURNED OFF WHEN IT SUDDENLY EXPLODED. *TT

NHTSA ID

10582914

Incident

Mar 20, 2014

Mileage

175,000 mi

DROVE CAR TODAY AND IT HAD BEEN SITTING PARKED FOR 5 HOURS . NEIGHBORS CALLED MY CELL TO TELL ME THE TRUCK WAS ON FIRE AND THE FIRE DEPARTMENT HAD BEEN CALLED TO TRY TO PUT IT OUT . THE FIRE DEPARTMENT HAD TO CHAINSAW THE HOOD AND THEY WERE FINALLY ABLE TO PUT IT OUT WITHOUT THE FIRE DESTROYING THE PASSENGER COMPARTMENT. THE TRUCK HOWEVER HAD BURNED FOR ABOUT 15 MINUTES IN THE ENGINE COMPARTMENT . THIS TRUCK HAD SELF STARTED ITS OWN FIRE BEING LEFT ALONE IN THE DRIVEWAY FOR 5 HOURS . *TR

NHTSA ID

10535903

Incident

Aug 17, 2013

Mileage

145,000 mi

TL* THE CONTACT OWNS A 2000 LINCOLN NAVIGATOR. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO BE REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 05V388000 (VEHICLE SPEED CONTROL) BUT THE VEHICLE STILL HAD A PROBLEM WITH THE WIRING. THE CONTACT ALSO STATED THAT THERE WAS A BURNING WIRE ODOR. THE DEALER STATED THERE WAS NO PROBLEM WITH THE VEHICLE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS UNAVAILABLE. THE CURRENT MILEAGE WAS 127,000. *TR

NHTSA ID

10509073

Incident

Nov 7, 2005

TL* THE CONTACT OWNS A 2000 LINCOLN NAVIGATOR. THE CONTACT STATED THAT THE ENGINE COMPARTMENT IGNITED IN FLAMES WITHOUT WARNING. THE FIRE DEPARTMENT WAS CONTACTED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE CAUSE OF THE FIRE WAS UNKNOWN TO THE CONTACT. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 157,000.

NHTSA ID

10457201

Incident

May 1, 2012

Mileage

157,000 mi

This article supersedes TSB 19-2026 to update the vehicle model years affected. Some 2000 and newer Ford/Lincoln/Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended.

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition

Some 2000 and newer Ford, Lincoln and Mercury vehicles equipped with aluminum body panels may exhibit corrosion concerns appearing as bubbled and/or peeling paint with or without accompanying white dust. Panel replacement is recommended. Follow the Service Procedure steps to correct the condition

ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE (DTC) PEWEE, P0302, P0303, P0304, P0305, P0306, P0307, P0308, AND P0316. *TT

WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT

SAFETY BELT RETRACTION SPEED. *TT