2012 BMW X5

In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects approximately 33,214 vehicles built from March 12, 2008 through June 27, 2013, corrects the remedy and expands the scope of a prior BMW recall (12V-550) which addressed idle pulley bolt failure in approximately 29,800 MY 2009 through 2012 BMW X5 xDrive35d vehicles built from September 1, 2008 through November 15, 2012. BMW's analysis indicates that due to a number of contributing factors it is possible that the bolt's pre-stressing force could drop to an extent that it results in the bolt becoming loosened over time. A loosening of the bolt could cause additional bending stress on top of the bolt. As a result, the bolt could break. If this were to happen, then a sudden loss of power steering assist could occur.If there were a loss of power steering assist, manual steering capability would be retained, although the effort required to steer the vehicle would be greater, and therefore may increase the risk of crash.ODI's analysis of the complaints it has received from the public (VOQ's) and BMW complaint data submitted in response to the information request letter for RQ18-001 identified a total of 93 unique VIN reports alleging failure of the idler pulley bolt after recall 12V-550 was completed on the vehicle, including 31 VOQ's and 72 BMW consumer complaints (5 complaints received by NHTSA and BMW, 3 unique VIN's submitted multiple complaints to BMW, and 1 unique VIN submitted multiple complaints to NHTSA).BMW is developing a new idler pulley fastening system as the remedy for 18V-336.The remedy is planned to begin in February 2019.Based on BMW's safety recall, this recall query is closed.The 31 VOQ's referenced in this resume are: 10499780, 10559422, 10579534, 10655424, 10661614, 10702323, 10819617, 10903433, 10948014, 10984353, 11002447, 11010667, 11013643, 11041551, 11054759, 11054909, 11066063, 11083479, 11097562, 11098865, 11113332, 11128649, 11130277, 10552773, 10817406, 10937632, 10956710, 11032006, 11042259, 11063010, 11091513.

I own a 2012 BMW X5 that is experiencing a Footwell Module (FRM) failure. BMW issued an Extended Limited Warranty for the FRM extending coverage to 15 years or 186,000 miles. My vehicle falls within those limits. The FRM failure has rendered the headlights, high beams, turn signals, brake lights, and power windows inoperative. As a result, the vehicle cannot be safely operated on public roads. Other motorists may not be able to see when the vehicle is braking or turning, creating a significant safety concern. BMW of Brooklyn and BMW of North America have informed me that I must pay a $360 diagnostic fee upfront before they will determine whether the repair is covered under BMW's FRM Extended Limited Warranty. BMW's warranty letter states that the FRM warranty is subject to the same eligibility requirements and limitations as the BMW New Vehicle Limited Warranty. In my view, requiring a substantial upfront diagnostic fee to evaluate a known defect covered by an extended warranty creates an unreasonable barrier to obtaining warranty repairs. I understand diagnostic charges may be appropriate if the failure is ultimately determined to be unrelated to the FRM. However, I do not believe owners should be required to pay a significant upfront fee simply to determine whether a known and potentially covered defect qualifies for warranty coverage. I respectfully request that NHTSA review both the safety implications of FRM failures and BMW's administration of this warranty program.

NHTSA ID

11744308

Incident

Jun 13, 2026

Two nights ago I was at Domino’s Pizza. I put my car in reverse and the car died and the steering wheel locked up like the power steering was giving out I was able to start the car again, but still with no power steering assist and drove the car home about a mile away, but every time I slowed down or came to a stop sign or a stoplight, the car would die, and the battery light would flash on the dash and it would say charging malfunction once I got home we took a look at the engine and noticed that none of the belts were working at all and then I started to google what could possibly be the problem and a couple of different recalls came up recall number 12V550000 and that is engine and engine cooling engine diesel what the name of it is and the recall date is 1127 2012 and then the next one is 2012 BMW X5 diesel SUVs from the model year 2012 923 BMW X fives have been recalled because they have defective engine belt, tensioners and cracks that develop along the welds if the belt tensioner fails there could be a sudden loss of power steering assist that is sounds like exactly what happened to my car and then there’s another one recall number B121918 which is from September 2019 and it is called idler pulley bolt and come to find out that actually was a recall on my vehicle, but the previous owner is the one that had it repaired so I’m not sure if BMW is willing to repair it again but there’s not a lot of miles on this cards a 2012 I bought it with 95,000 miles on it and it currently only has 131,000 miles on it. I’m just hoping for some kind of resolution here this is the fifth Bmw that I bought in my lifetime and I for the most part I’ve had pretty good ultimate driving experience and good customer service and some good financing but I can’t see why just recall wouldn’t cover my vehicle. It’s currently in the shop. They’re doing a diagnostic on it and I will be getting that back later on today and I can report that back to you folks, hopefully it could be recalled. M

NHTSA ID

11735154

Incident

Apr 28, 2026

My car was sitting on the driveway and spontaneously caught on fire. It has not been driven for the last week or two. Nobody was home, when it caught on fire. Our neighbors called 911

NHTSA ID

11708556

Incident

Jan 2, 2026

The contact owns a 2012 BMW X5. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact stated that the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the interior lights flickered on and off. The failure was intermittent. The contact later received an extended warranty notification for the foot well. The vehicle was taken to the dealer where it was diagnosed with a misfire in cylinders #3 and #4. The contact was informed that the failure was not related to the extended warranty program. The contact was informed that ignition coils and plugs in cylinders #3 and #4 needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was unknown.

NHTSA ID

11704702

Incident

Dec 12, 2023

Front passenger side occupancy seat sensor is bad and computer detected an air bag malfunction. Timing chain broke without warning.

NHTSA ID

11680551

Incident

Feb 20, 2023

I received a message of Restraint system malfunction and when I called the local dealer I was told the part is not availabel anywhere in the USA. What am I supposed to do with this. I was told the air bags and seatbelts may malfunction. The vehicle only has 85k miles. its a 2012. At this point who will take the car as a trade? It's not safe and they don't have an answer except to say I'm [XXX] and i guess you need to get a new vehicle!! Can you believe this? I have to get a whole new vehicle because they don't have a part! You can't make this stuff up. I spoke with BMW USA and was told they only honor 4yr and 50k miles and after 10years they are not responsible for parts to be made. The I was told to get it further diagnosed to the tune of 250.00 so they can "MAYBE" have the parts manufactured. What the heck! this company is saying our cars are garbage after 10yrs! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11678691

Incident

Jun 20, 2025

The contact owns a 2012 BMW X5. The contact stated that when the vehicle was parked, the contact noticed coolant leaking on the ground underneath the vehicle. The contact stated that the low coolant warning light was illuminated. The contact refilled the coolant reservoir. The vehicle was taken to an independent mechanic where it was diagnosed with coolant pump failure. The contact was informed that the coolant pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact referenced NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the VIN was not associated with the recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 98,744.

NHTSA ID

11671552

Incident

Jul 4, 2025

Mileage

98,744 mi

Water entering into the vehicle, causing vehicle to reduce power in traffic, due to traction control issues.. Not able to drive vehicle when it’s raining., along with other issues, pls see first report..

NHTSA ID

11665571

Incident

Feb 10, 2025

The Footwell Module (FRM) limited warranty for defects in materials and / or workmanship has been supplementarily increased to 15 years / 186,000 miles as determined from the original first in-service / delivery date.

This bulletin outlines the Customer Care Package program that has been designed exclusively for BMWvehicles with the N63 engine. Vehicles with the N63 high performance engine are engineered with EfficientDynamics that provides fueleconomy without compromising on its “class leading” power and performance. To ensure these engines keep delivering the ultimate performance, we have designed this Care Package thatincludes a 6 point check, and if necessary, the replacement of one or more of the following powertraincomponents: Hot-Film Air Mass Sensors PIEZO High Pressure Fuel Injectors Engine Vacuum Pump Fuel System Low Pressure Sensor/Feed Line Fresh Air Intake Turbo Seals Crankcase Ventilation Lines (Hoses)

The Footwell Module (FRM) limited warranty for defects in materials and / or workmanship has been supplementarily increased to 15 years / 186,000 miles as determined from the original first in-service / delivery date.

The Footwell Module (FRM) limited warranty for defects in materials and / or workmanship has been supplementarily increased to 15 years / 240,000 miles as determined from the original first in-service / delivery date.

The basic conditions for initializing the power windows are not met.

The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.