1995 Cadillac Seville

ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.

THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.

There is no summary currently available

IF A 1995 CADILLAC INTERIOR IS EXPOSED TO SIGNIFICANT WATER INTRUSION, SUCH AS FROM WATER LEAKS, A WINDOW LEFT OPEN IN THE RAIN, OR DRIVING THROUGH HIGH WATER UP TO THE CARPET LEVEL, THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) SYSTEM SENSING AND DIAGNOSTIC MODULE (SDM) CAN BE DAMAGED.IF THIS OCCURS, BOTH THE DRIVER AND PASSENGER AIR BAGS CAN DEPLOY WHEN THE IGNITION SWITCH IS TURNED ON, EVEN IF THERE HAS BEEN NO FRONTAL IMPACT OR CRASH.AS A RESULT OF THESE DEPLOYMENTS, GM CONDUCTED AN ADVISORY LETTER CAMPAIGN, NUMBER 51-01-08 ENTITLED INADVERTENT DEPLOYMENT OF AIR BAGS WHEN INTERIOR EXPOSED TO WET CONDITIONS, IN FEBRUARY 1996.LETTERS TO OWNERS MAILED PURSUANT TO THIS COMPAIGN WARNED OWNERS TO NOT START THEIR ENGINES IF THE VEHICLE INTERIOR HAD BEEN EXPOSED TO SUBSTANTIAL AMOUNTS OF WATER.ODI HAS RECEIVED A TOTAL 8 REPORTS OF INADVERTENT AIR BAG DEPLOYMENT IN 1995 CADILLAC VEHICLES.

'TAKATA RECALL' I WAS DRIVING MY 1995 CADILLAC SEVILLE OUT OF A SHOP-RITE PARKING LOT ON SEPTEMBER 30TH, 2017 AND WAS INVOLVED IN A CRASH. I WAS DRIVING VERY SLOWLY AS I WAS APPROACHING A STOP SIGN AND ROUTE 46 (A BUSY HIGHWAY). MY AIRBAGS DEPLOYED INADVERTENTLY AND I HIT THE CAR IN FRONT OF ME. THE AIRBAGS SMASHED THE WINDSHIELD. ACCORDING TO NHTSA CAMPAIGN NUMBER 98V115000, 1995 CADILLAC SEVILLE 'PASSENGER VEHICLES INADVERTENT DEPLOYMENT OF THE AIRBAGS CAN OCCUR DUE TO WATER INTRUSION.' I THEN CONTACTED GENERAL MOTORS WHO STATED THAT MY PARTICULAR VEHICLE WAS NOT SUBJECT TO THE RECALL. THEY PERFORMED AN INVESTIGATION AND INFORMED ME THAT THEY WOULD NOT ASSIST ME WITH THE REPAIRS BUT REFUSED TO GIVE ME A REASON. ACCORDING TO THE NHTSA WEBSITE: 'FRONTAL AIRBAGS ARE GENERALLY DESIGNED TO DEPLOY IN 'MODERATE/SEVERE' FRONTAL OR NEAR-FRONTAL CRASHES, WHICH ARE DEFINED AS CRASHES THAT ARE EQUIVALENT TO HITTING A SOLID, FIXED BARRIER AT 8-14 MPH OR HIGHER. (THIS WOULD BE EQUIVALENT TO STRIKING A PARKED CAR OF SIMILAR SIZE AT ABOUT 16-28 MPH OR HIGHER.)' SINCE I WAS GOING MUCH SLOWER THAN 8-14 MPH, I BELIEVE MY CAR SHOULD HAVE BEEN INCLUDED IN THIS RECALL AND GM IS NOT TAKING RESPONSIBILITY. IS THERE ANYTHING YOU CAN DO TO ASSIST ME OR ADVISE ME?

NHTSA ID

11080709

Incident

Sep 30, 2017

Mileage

115,284 mi

WANT START AFTER 2OR3 DAYS CAN'T UNDERSTAND IT. GAS PADDLE CHICKS WHEN YOU TURN SWITCH OFF.

NHTSA ID

10883176

Incident

Jan 9, 2015

Mileage

81,000 mi

TL* THE CONTACT OWNS A 1995 CADILLAC SEVILLE. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, STRONG FUEL FUMES EMITTED INTO THE VEHICLE. THE PROBLEM RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 119,000. UPDATED 3/24/15*CN

NHTSA ID

10653947

Incident

Oct 30, 2014

Mileage

119,000 mi

TL* THE CONTACT OWNS A 1995 CADILLAC SEVILLE. THE CONTACT STATED THAT THE FRONT DRIVER SIDE SEAT BELT WAS SHORT AND UNABLE TO BE FASTENED. AS A RESULT, THE CONTACT HAD TO DRIVE THE VEHICLE WITHOUT THE SEATBELT FASTENED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS ADVISED THAT THE SEAT BELT EXTENDER WOULD BE NEEDED HOWEVER, IT WAS DISCONTINUED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 57,600.

NHTSA ID

10648195

Incident

Oct 15, 2014

Mileage

57,600 mi

TL* THE CONTACT OWNS A 1995 CADILLAC SEVILLE. THE CONTACT STATED THAT THERE WAS A STRONG FUEL ODOR EMITTING FROM THE ENGINE AND THE SERVICE ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS TAKEN TO THE DEALER TO BE REPAIRED UNDER NHTSA CAMPAIGN NUMBER 04V110000 (FUEL SYSTEM, GASOLINE) BUT THE CONTACT WAS INFORMED THAT THE RECALL EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.

NHTSA ID

10584175

Incident

Feb 3, 2014

Mileage

180,000 mi

AFTER DRIVING THE CAR FOR APPROXIMATELY SIX MONTHS, I BEGAN TO DETECT A FAINT ODOR OF GASOLINE WHICH SEEMED TO BE COMING FROM UNDER THE HOOD. I KEPT DETECTING THIS ODOR OFF AND ON FOR THE NEXT FEW MONTHS. THEN ONE DAY I WAS SURPRISED AND CONFUSED TO SEE MY GAS GAUGE MOVING STEADILY TOWARD EMPTY AS I DROVE ALONG. I THOUGHT THE GAUGE WAS BROKEN, BUT IT WAS NOT. INSTEAD, IN ABOUT TWO MILES, I HAD JETTISONED AN ENTIRE TANK OF GASOLINE AS I DROVE. THE PROBLEM TURNED OUT TO BE A RUPTURED PLASTIC LINE LEADING TO ONE OF THE FUEL INJECTORS. SINCE THAT TIME, EACH OF THE FUEL LINES HAS RUPTURED ONE BY ONE EVERY 2 - 10 MONTHS FOR FIVE YEARS. THEN I LEARNED THERE WAS A RECALL. I HAVE SEEN THE RECALL LETTER WHICH STATES ALL 1995 CADILLAC SEVILLES HAVE THIS PROBLEM, AND MINE CERTAINLY DOES. THE DEALER AND GM SAY MY CAR IS NOT ON THE RECALL LIST. I HAVE FILED A FORMAL COMPLAINT WITH GM AND THEY STILL REFUSE TO FIX MY CAR, STATING THAT MY VIN# DOESN'T SHOW UP ON THEIR LIST. *TR

NHTSA ID

10485267

Incident

Nov 30, 2007

Mileage

190,000 mi

TL* THE CONTACT OWNS A 1995 CADILLAC SEVILLE. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A FUEL LINE FAILURE TWICE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO PERFORMED A DIAGNOSTIC THAT ADVISED THAT THE FRONT DRIVER SIDE FUEL LINES WERE CRACKED AND LEAKING FUEL. THE VEHICLE WAS REPAIRED. THE FUEL LINES WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 04V110000 (FUEL LEAKAGE). THE FAILURE MILEAGE WAS 91,468, AND THE CURRENT MILEAGE WAS 92,616.

NHTSA ID

10444090

Incident

Mar 3, 2010

Mileage

91,468 mi

TL*THE CONTACT OWNS A 1995 CADILLAC SEVILLE. THE CONTACT STATED THAT THE ENGINE BEGAN TO FREEZE WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY REPLACED THE HEAD BOLTS ON THE ENGINE. A WARNING LIGHT ILLUMINATED INDICATING THAT THE COOLANT LEVEL NEEDED TO BE CHECKED. THE DEALER STATED THAT THERE WERE NO RECALLS OR WARRANTY; THEREFORE THE CONTACT WOULD BE RESPONSIBLE FOR PAYING $3500 TO HAVE THE VEHICLE REPAIRED. THE MANUFACTURER WAS NOT CALLED. THE FAILURE MILEAGE WAS 90,000.

NHTSA ID

10321361

Incident

Mar 19, 2010

Mileage

90,000 mi

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.