1998 Dodge Caravan

THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND REPLACE THE CLOCKSPRING ASSEMBLY ON ALL MY 1998.5-2000 DAIMLERCHRYSLER MINIVANS, BUILT BETWEEN MARCH 1998 AND AUGUST 2000, WITH 70,000 MILES OR LESS.IT WILL ALSO PROVIDE A LIFETIME WARRANTY FOR THIS COMPONENT ON MY 1998.5-2000 MINIVANS, REGARDLESS OF MILEAGE.THE DETAILS OF THE CORRECTIVE ACTION ARE DESCRIBED IN DAIMLERCHRYSLER'S LETTER (SEE RECALL NO. 04V-480).THE AGENCY BELIEVES THAT FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS WITH RESPECT TO THOSE VEHICLES COVERED ONLY BY THE LIFETIME WARRANTY.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE PAGE 2 FOR ADDITIONAL INFORMATION.

COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF DAIMLERCHRYSLER'S RECALL OF MODEL YEAR 1996-1998.5 MINIVANS (RECALL NO. 02V-293).THIS RECALL QUERY HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-013).

THIS INVESTIGATION WAS OPENED JANUARY 16, 2002, BASED ON SEVEN REPORTS ALLEGING THE THIRD ROW SEAT BELT RETRACTORS FAILED ON CERTAIN 1997 AND 1998 MODEL YEAR CARAVAN AND VOYAGER VEHICLES.THE REPORTS INDICATED A TAR LIKE SUBSTANCE ENTERED THE RETRACTOR MECHANISM, THUS CAUSING THE RETRACTOR TO JAM OR BIND.IN THIS CONDITION THE SEAT BELT IS RENDERED INOPERABLE, AS THE WEBBING CANNOT RETRACT OR BE WITHDRAWN FROM THE RETRACTORS FOR USE.RECALL SCOPE:THE AFFECTED VEHICLES ARE 1997 THROUGH 1999 DODGE CARAVAN, PLYMOUTH VOYAGER, AND CHRYSLER TOWN & CONTRY BUILT ON A SHORT WHEEL BASE CHASSIS.THE INCLUSIVE DATES OF PRODUCTION ARE JUNE 1996 THROUGH OCTOBER 31, 1999.RECALL REMEDY: DAIMLERCHRYSLER DEALERS WILL REPLACE THE MASTIC SOUND BARRIER PATCHES WITH FOAM BLOCKERS, AS WELL AS, INSPECT AND REPLACE ALL THIRD ROW REAR SEAT BELT ASSEMBLIES CONTAMINATED BY THE MASTIC PATCH.

There is no summary currently available

AIRBAG LIGHT ON NO TURN SIGNALS AND NO REVERSE LIGHTS DUE TO FAILED AIRBAG CLOCKSPRING

NHTSA ID

11196029

Incident

Jan 10, 2019

TL* THE CONTACT OWNED A 1998 DODGE CARAVAN. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT'S VEHICLE CRASHED INTO A SECOND VEHICLE. THE FRONT END WAS SEVERELY DAMAGED. THE DRIVER'S SIDE AIR BAG DID NOT DEPLOY. THE PASSENGER SIDE AIR BAG DEPLOYED ALTHOUGH NO PASSENGER WAS PRESENT IN THE VEHICLE. THE VEHICLE WAS DESTROYED AND TOWED. THE DRIVER SUSTAINED A HEAD LACERATION ABOVE THE RIGHT EYE, A CONCUSSION, A BRUISED HEART AND LUNG, LEFT KNEE LACERATION, AND CHEST BRUISES FROM THE SEAT BELTS. ALSO, BOTH WRISTS AND ELBOWS WERE INJURED. A POLICE REPORT WAS FILED. THE LOCAL DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 135,000.

NHTSA ID

11160520

Incident

Nov 29, 2018

Mileage

135,000 mi

THE INDICATOR LAMP AIR BAG IS ON CONTINUOUSLY. I DRIVE A VEHICLE ALL THE TIME, AND MY TRIP 50% HIGHWAY AND 50% CITY.

NHTSA ID

11052123

Incident

Dec 3, 2017

Mileage

104,580 mi

TL* THE CONTACT OWNS A 1998 DODGE CARAVAN. WHILE DRIVING VARIOUS SPEEDS, THE POWER STEERING SEIZED WITHOUT WARNING. THE FAILURE WAS PERSISTENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SERPENTINE BELT FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED SEVERAL TIMES, BUT THE FAILURE WAS PERSISTENT. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10917173

Incident

Apr 12, 2016

TL* THE CONTACT OWNS A 1998 DODGE CARAVAN. THE CONTACT STATED THAT WHEN DRIVING ON WET ROADS, THE POWER BRAKES AND STEERING FAILED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE PULLEY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

NHTSA ID

10819663

Incident

Nov 12, 2015

Mileage

150,000 mi

TL* THE CONTACT OWNS A 1998 DODGE CARAVAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 11V139000 (ELECTRICAL SYSTEM); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. ..UPDATED 05/20/15 *BF UPDATED 11/19/15*JS

NHTSA ID

10703316

Incident

Apr 2, 2015

TL* THE CONTACT OWNS A 1998 DODGE CARAVAN. WHILE DRIVING APPROXIMATELY 25 MPH, THE DRIVER AND PASSENGER SIDE AIR BAGS DEPLOYED INDEPENDENTLY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.

NHTSA ID

10676972

Incident

Jan 7, 2015

Mileage

55,000 mi

I WAS BACKING OUT OF A PARKING SPACE IN 2012, WHEN THE BRAKES COMPLETELY FAILED, I HAD TO PUT MY VEHICLE INTO GEAR IN ORDER FOR IT TO STOP. EVEN THOUGH I WAS ONLY GOING 5 MPH OR LESS, I WAS ON A DOWNHILL SLOPE. THERE WASN'T AN ACCIDENT NOR ANY DAMAGE, SO I DON'T HAVE THAT TO REPORT. THE VAN WAS TAKEN TO TOWBIN DODGE IN HENDERSON, NV THAT WEEKEND I BELIEVE AND I WAS TOLD THAT THE RECALL DEFECT HAD BEEN FIXED. HOWEVER, THE HORN, AIRBAG LIGHT AND ABS STILL DO NOT WORK. MY VIN #[XXX], MY QUESTION IS THIS. IF THE RECALL PROBLEM IS STILL DEFECTIVE EVEN THOUGH IT'S BEEN REPAIRED, WHAT AM I SUPPOSED TO DO? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10672754

Incident

Mar 15, 2012

Mileage

132,000 mi

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.