1996 Dodge Caravan

CFAS SENT A FOLLOW-UP LETTER ON DECEMBER 12, 1996, TO CHANGE THE INTENT OF THE PETITION TO AIRBAG AGGRESSIVITY AND DEPLOYMENT VARIABILITY.NHTSA RECEIVED THE LETTER ON 12/12/96; ACCORDINGLY, THE PETITION DUE DAY WAS CHANGED TO APRIL 12, 1997.CFAS PETITIONED THE AGENCY TO CONDUCT AN INVESTIGATION TO DETERMINE WHETHER THE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS FOR THE 1991-92 CHEVROLET CORSICA/BERETTA, 1990-92 FORD TAURUS, AND 1994-96 CHRYSLER MINIVANS ARE DEFECTIVE.CFAS ALLEGE THAT INFORMATION ON LOW SPEED CRASHES HERE OCCUPANTS HAVE SUFFERED FATAL INJURIES SUGGESTS [THAT THE ABOVE VEHICLES] HAVE DEFECTIVE AIRBAG CRASH SENSOR AND/OR DEPLOYMENT SYSTEMS.

There is no summary currently available

There is no summary currently available

There is no summary currently available

The contact owns a 1996 Dodge Caravan. The contact stated while driving at an undisclosed speed, there was a strong gasoline odor inside the vehicle. The contact stated that after parking the vehicle, he opened the hood and noticed a fuel leak on top of the engine. No warning lights were illuminated. The contact made a local dealer aware of the failure; however, the vehicle was not yet diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 130,000.

NHTSA ID

11499901

Incident

Dec 27, 2022

Mileage

130,000 mi

WHILE TURNING INTO A PARKING SPACE I TOUCHED BREAK AND THE VAN ACCELERATED TO FULL THROTTLE. THE VAN JUMPED THE CURB AND WAS HEADING TOWARD 3 PEOPLE, I TURNED THE STEERING WHEEL ENOUGH TO HIT A LIGHT POLE INSTEAD OF THEM. THE VAN QUIT RACING FOR A FEW SECONDS AND THEN REVVED UP AGAIN. THE LIGHT POLE FELL AND I WAS AGAIN HEADED TOWARD THE PEOPLE. I PUT BOTH FEET ON THE BREAK AND WAS ABLE TO STOP THE VAN, BUT NOT BEFORE HITTING THE PEOPLE. LUCKILY THEY WERE JUST BRUISED BECAUSE I JUST BUMPED THEM AND DIDN'T RUN OVER THEM. THIS ALL HAPPENED IN A MATTER OF SECONDS. I ALMOST KILLED SOME PEOPLE AND NO LONGER HAVE TRANSPORTATION BECAUSE THE VAN WAS TOTALED.

NHTSA ID

10724131

Incident

May 9, 2015

TL* THE CONTACT OWNS A 1996 DODGE CARAVAN. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT NOTICED THAT THE HORN FAILED TO FUNCTION. IN ADDITION, THE ODOMETER DISPLAYED AN INCORRECT READING AND THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CLOCK SPRING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 02V293000 (AIR BAGS), BUT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10715313

Incident

Feb 1, 2015

I PURCHASE THIS VEHICLE FROM OWNER IN DEC. 2013 AND START HAVING PROBLEM THE OWNER I PURCHASE IT FROM PURCHASE IT FROM A BANK BACK IN 2006. THEY DID KNOW ABOUT AN RECALL OR ETC. ABOUT THIS VEHCLE. THE ELECTRIC HAS PROBLEM AND AIRBAGS, THE FUEL TANK IS LEAKING AND FUEL INJECTION AND ETC,. WHERE CAN I CAN GET HELP FOR THESE PROBLEMS.ETC.,. *TR

NHTSA ID

10562062

Incident

Jan 20, 2014

THIS VEHICLE HAS A CHRONIC DESIGN PROBLEM WITH THROWING ITS SERPENTINE BELT WHENEVER THE TENSION PULLEY GETS WET. SOON AS THE BELT IS THROWN THERE IS NO POWER STEERING, AND IT STEERS 10 TIMES WORSE THAN A MACK TRUCK. THE LACK OF STEERING IS A DEFINITE SAFETY HAZARD TO EVERY OTHER VEHICLE ON THE ROAD. AS IT HAPPENS SUDDENLY BY DRIVING THROUGH A WATER PUDDLE, ETC. THERE IS VIRTUALLY NO TIME TO REACT. IN ADDITION TO LACK OF STEERING THERE IS NO ALTERNATOR OUTPUT, RESULTING IN RAPID BATTERY DRAIN. ALSO THERE IS NO COOLANT SYSTEM FAN RESULTING IN RAPID ENGINE OVERHEATING. THIS DESIGN FAULT HAS BEEN KNOWN FOR WELL OVER A DECADE, NO MAKE THAT 2 DECADES, BUT CHRYSLER HAS NEVER ACKNOWLEDGED A PROBLEM. THE PROBLEM DATES BACK TO ALL CHRYSLER MINI-VAN DESIGNS FROM THE EARLY 1990S TO AT LEAST 2000. IF THE LACK OF STEERING IS NOT A SAFETY RELATED DEFECT I DON'T KNOW WHAT IS. WE HAVE A USED WHEELCHAIR CONVERSION CARAVAN VAN TO TRANSPORT MY WIFE. THIS LATEST INCIDENT WAS THE PAST SATURDAY NIGHT AS WE LEFT A RESTAURANT TO RETURN HOME. IT HAD BEEN RAINING PROFUSELY AND SUDDENLY I HAD NO STEERING. I KNEW IMMEDIATELY WHAT THE PROBLEM WAS SINCE THIS IS THE 3RD OCCURRENCE IN THE PAST 6 MONTHS. DO YOU EXPECT YOUR VEHICLE TO BECOME INOPERABLE JUST BECAUSE YOU DRIVE IN THE RAIN? WHY HAS NOT CHRYSLER BEEN MADE TO ACKNOWLEDGE THIS PROBLEM AND ISSUE A REPAIR RECALL? I DON'T CARE IF THE VAN IS OVER A DECADE OLD. THIS DEFECT IS ONE WHICH ENDANGERS EVERYONE ELSE ON THE ROAD AND WHICH CHRYSLER SHOULD HAVE BEEN REQUIRED TO ADDRESS WELL OVER A DECADE AGO. *TR

NHTSA ID

10522678

Incident

Jun 30, 2012

Mileage

72,000 mi

STRUT TOWER CORROSION 10090457 RIGHT / LEFT STRUT TOWER RUSTED OUT ON 96 DODGE CARAVAN. TOOK VAN INTO REPAIR SHOP TO FIND OUT STEERING ISSUE THEY FOUND A COMPLETELY RUSTED OUT STRUT HOUSING SAID ITS A KNOWN ISSUE WITH VEHICLE AND SAFETY BULLETIN WAS ISSUED SINCE ITS A KNOWN PROBLEM. SUSPENSION/BODY - STRUT TOWER CORROSION NUMBER: 23-044-02 GROUP: BODY DATE: OCT. 14, 2002 SUBJECT: NS STRUT TOWER CORROSION . *TR

NHTSA ID

10410393

Incident

Jul 2, 2011

CAR STOP HAVING ELECTRICAL OUTPUT. *TR

NHTSA ID

10401400

Incident

May 14, 2011

Mileage

141,775 mi

TL*THE CONTACT OWNS A 1996 DODGE GRAND CARAVAN. THE CONTACT STATED THAT FUEL WAS LEAKING FROM HIS TANK IN LARGE AMOUNTS. THE VEHICLE WAS INSPECTED BY A INDEPENDENT MECHANIC AND THEY ADVISED HIM THAT HE NEEDED TO REPLACE THE TANK AND THE FUEL PUMP. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED HIM THAT THE RECALL WAS EXPIRED AND COULD NOT ASSIST HIM. THE FAILURE MILEAGE WAS APPROXIMATELY 151,000. UPDATED 03/24/11*LJ UPDATED 05/02/11

NHTSA ID

10383216

Incident

Feb 17, 2011

Mileage

151,000 mi

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

Repair Parts Used For Structural Repairs This bulletin involves discussing FCA US LLC position with regard to structural repair parts usage.

Use of Aftermarket Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of aftermarket parts.