2010 Dodge Caravan

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den

TL* THE CONTACT OWNS A 2010 DODGE CARAVAN. WHILE THE VEHICLE WAS AT CHAMPION CHRYSLER JEEP DODGE RAM (6525 W SAGINAW HWY, LANSING, MI 48917, (517) 225-6658) FOR A POWER STEERING FAILURE, THE TECHNICIAN NOTICED THAT THE STABILIZER BAR WAS CORRODED THROUGH AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 133,000. THE VIN WAS UNKNOWN.

NHTSA ID

11243678

Incident

Aug 13, 2019

Mileage

133,000 mi

MY STX GRAND CARAVAN STALLS WHILE DRIVING DOWN THE ROAD WITHOUT ANY WARNING. NO TROUBLE LIGHTS COME ON EXCEPT THE TRACTION LIGHT. THE LIGHT GOES OFF AS SOON AS YOU RESTART THE VAN. USUALLY HAPPENS WHEN I LET OFF THE GAS PEDAL TO SLOW DOWN. NO ONE KNOWS HOW TO FIX IT !! HAS HAPPENED IN THE CITY BUT MOSTLY WHILE DRIVING ON THE HIGHWAY WHEN I LET OFF THE GAS.

NHTSA ID

11235233

Incident

Jul 24, 2019

Mileage

125,175 mi

VEHICLE SHUTS OFF WHILE IN MOTION USUALLY WITHIN FIRST 10 MINUTES OF DRIVING. WE THOUGHT IT WAS DOING IT BECAUSE WE DID NOT WARM UP THE ENGINE ENOUGH IN WINTER BUT NOW IT HAPPENS IS WARMER WEATHER AS WELL. THE ENGINE JUST SHUTS OFF USUALLY WITHIN .25-2 MILES FROM THE START OF THE TRIP. THERE IS NO ENGINE CHECK LIGHT, AND NO ERROR IN LOG. THE CAR HAS ALREADY UNDERGONE THE IGNITION KEY RECALL REPAIR AND A 3 DAY DIAGNOSTIC AT A LOCAL DODGE DEALER IN SCHAUMBURG IL, WITHOUT THEM FINDING ANYTHING WRONG. THIS IS VERY DANGEROUS AS THE DRIVER LOOSES POWER STEERING, 2 TIMES WE ALMOST GOT INTO AN ACCIDENT BECAUSE THE CAR STALLED MID TURN. IT WILL STALL WHILE DRIVING STRAIGHT OR TURNING. USUALLY OF WE LET THE CAR SIT AND WARMING UP FOR 15-20 MINUTES THE PROBLEM WILL NOT SHOW UP, BUT IF WE START THE CAR AND PUT IT IN DRIVE WITHIN 1 MINUTE IT WILL MOST LIKELY STALL DURING THE DRIVE. WHILE THE CAR IS STILL ROLLING STRAIGHT THE WE CAN PUT THE CAR IN NEUTRAL AND RESTART THE VEHICLE AND CONTINUE DRIVING BUT USUALLY WE HAVE TO MAKE A FULL STOP IN THE MIDDLE OF THE TRAFFIC LANE BECAUSE THE WHEEL IS TOO HARD TO TURN TO PULL OVER. THERE IS MANY INSTANCES OF OTHER DODGE GRAND CARAVANS DOING THIS.

NHTSA ID

11209592

Incident

Mar 20, 2019

Mileage

125,000 mi

BOUGHT THE VAN FROM COOKS VOLKSWAGEN ON MAY 7TH, 2018. IN THE FIRST 3 MTHS OF ME OWNING IT I HAD TO GET 2 MOTOR MOUNTS AND A STARTER PUT IN. THEN FROM THAT POINT IT WAS ALL DOWN HILL! IT HAS HAD 3 TRANSMISSIONS(COOKS HAS DONE 2 AND I TOOK THE VAN TO THOMPSON FOR THEM TO DO THE THIRD), HUB ASSEMBLY, WELDED THE CORE SUPPORT, POWER STEERING PULLEY AND BARING, STRUTS FOR THE TRUCK HATCH, I HAD TO PAY FOR OUT OF POCKET FOR POWER STEERING PULLEY AND BARING AND ONE DAY OF RENTAL FOR A RENTAL CAR! I HAVE ALREADY CALLED MY LAWYER AND TO HAVE CHRYSLER/DODGE SUED FOR SELLING AN UNINSPECTED VEHICLE AND FILING A CIVIL SUIT AGAINST YOUR COMPANY!!!! AS OF MAY 13,2019 IT IS IN THE SHOP AGAIN AND HAVE ANOTHER RENTAL VAN AFTER GETTING IT BACK ON FRIDAY MAY 10, 2019 AFTER IT'S 3RD TRANSMISSION BEING INSTALLED AND TRIED TO DRIVE IT DOWN 95 NORTH ON MAY 11,2019 AND I GOT TO 6TH GEAR AND IT WENT STRAIGHT INTO LIMP MODE AND HAD TO TAKE IT BACK TO THOMPSON'S TO FIX IT!

NHTSA ID

11207268

Incident

May 13, 2019

Mileage

110,000 mi

MY ELECTRONIC THROTTLE CONTROL COMES ON AND I LOSE A POWER AND COULD CAUSE AN ACCIDENT

NHTSA ID

11186871

Incident

Mar 12, 2019

TL* THE CONTACT OWNS A 2010 DODGE CARAVAN. THE CONTACT STATED THAT THE DRIVER'S SIDE SLIDING DOOR MALFUNCTIONED AND COULD NOT BE OPENED. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE LOCAL DEALER (BOB MARIANO DODGE, 146 MANCHESTER ST, CONCORD, NH) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 132,000.

NHTSA ID

11166465

Incident

Jan 2, 2019

Mileage

132,000 mi

I WAS DRIVING AT APPROXIMATELY 45-50 MPH AND ALL THE WARNING LIGHTS CAME ON AND IN THE NEXT SECOND THE CAR JUST LOST ALL POWER. NOTHING! I PULLED OVER AND IT STARTED ABOUT 5 MINUTES LATER. HAVING TO DRIVE AN HOUR BACK HOME ON THE HIGHWAY WAS SCARED AND MY FATHER BEING A DISABLED VET - THIS IS THE VEHICLE THAT IS USED.

NHTSA ID

11163767

Incident

Dec 14, 2018

Mileage

10 mi

1 PUSH CRUISE CONTROL BUTTON 6-12 TIMES TO GET IT ON.WHEN CAR ON HIGHWAY 2 AUTO DOOR SENIOR IS HITTING RUBBER RAIL GUIDE AN STOPS DOOR FROM SHUTTING . SOMETIMES DRIVER SIDE SIDE DOOR HANGS UP WON'T OPEN MOST TIME WHEN ITS COLD OUT. HAPPENS IN PARKING LOT . BEEN GOING OFF AND ON SINCE 06 23 2016

NHTSA ID

11162540

Incident

Jun 23, 2016

Mileage

1,200,000 mi

PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE

PAD KIT - REAR DISC BRAKE, FRONT DISC BRAKE

Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.

Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair Kit Website to confirm part number and applicability. There is an error with the wiring diagrams in Service Library that is causing the incorrect repair kit part number to populate. Please use the Mopar Connector Repair Kit Website until this issue is resolved.

Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review Service Library for specifications so a suitable alternative can be used

If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils.