RoadVitals

1981 Ford F-150

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Jan 24, 2011
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Latest Mar 15, 1982
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 2 NHTSA owner-reported complaints for the 1981 Ford F-150, most frequently naming the fuel system and tires & wheels categories. 3 safety recalls have been issued covering this model year; and 8 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Fuel system150.0%
  • Tires & wheels150.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

3 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
82V024000

EQUIPMENT:MECHANICAL:CARRIER/RACK

Mar 15, 1982
12,500 units potentially affected
The defect: THE REINFORCEMENT FOR THE IN-BOX SPARE TIRE CARRIER MAY HAVE BEEN ATTACHED USING INCORRECT HEX HEAD BOLTS. IF THE CARRIER AND REINFORCEMENT ATTACHING BOLTS ARE INCORRECT, THE POTENTIAL EXISTS FOR THE TIRE SIDEWALL TO BE DAMAGED OR WEAKENED BY EXTENDED CONTACT WITH THE SHARP EDGES OF THE BOLT HEADS.
The remedy: DEALER WILL REPLACE BOLTS AND ANY DAMAGED SPARE TIRES AT NO COST TO OWNER.
FORD MOTOR COMPANYView on NHTSA.gov
81V061000

STRUCTURE

May 21, 1981
130 units potentially affected
The defect: THE INVOLVED TRUCKS WERE MANUFACTURED WITH A CERTAIN PORTION OF SPECIFIED FLOOR PAN INSULATION MATERIAL (BENEATH THE RIGHT FRONT PASSENGER SEAT) OMITTED. BECAUSE OF THIS OMISSION, A SECTION OF THE SHEET METAL FLOOR PAN WAS LEFT EXPOSED OVER THE EXHAUST SYSTEM IN AN AREA OF POSSIBLE PASSENGER CONTACT.
The remedy: THE DEALER WILL INSTALL A REVISED DESIGN FLOORPAN INSULATOR PAD AT NO CHARGE TO OWNER.
FORD MOTOR COMPANYView on NHTSA.gov
80V145000

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING

Nov 10, 1980
6,260 units potentially affected
The defect: DURING A CHANGE IN ASSEMBLY PROCEDURES, CERTAIN OF THE MID-SHIP FUEL TANK STRAPS MAY HAVE BEEN IMPROPERLY INSTALLED OR MISLOCATED. AS A RESULT, THEY FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY". IN THE EVENT OF A COLLISION, EXCESSIVE FUEL SPILLAGE MAY OCCUR.
The remedy: DEALER WILL INSPECT AND, IF NECESSARY, RELOCATE FUEL TANK STRAPS WITHOUT CHARGE TO OWNER.
FORD MOTOR COMPANYView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Tires & wheels
Filed Jan 24, 2011

I PURCHASED FOUR USED SX 5000 STARFIRE (COOPER) 255/70-15 TIRES FOR MY 1981 FORD F-150 IN MARCH OF 2010. THE TIRES WERE MOUNTED TO WHAT I BELIEVE ARE 15X8 STEEL WHEELS BY THE INDEPENDENT TIRE SHOP THAT I PURCHASED THE TIRES FROM. I THEN DROVE FROM SAINT PETERSBURG, FL TO AUSTIN, TX ON THE TIRES WITH NO PROBLEMS. OVER THE NEXT TWO OR THREE MONTHS, I DROVE ABOUT 500 MILES ON THE TIRES WITH NO ISSUES, UNTIL ONE DAY ONE OF THE FRONT TIRES WAS FLAT IN MY DRIVEWAY, WITH THE TREAD SEPARATED IN ONE AREA. I REPLACED BOTH FRONT WHEELS WITH SPARE WHEELS AND TIRES (UNKNOWN EXACT SPECIFICATIONS, BUT SMALLER), AND WITHIN A COUPLE OF WEEKS, ONE OF THE REAR TIRES (AGAIN, IN MY DRIVEWAY) WAS FLAT, WITH THE TREAD SEPARATED. I PLACED TWO OTHER SPARE WHEELS/TIRES ON THE REAR AND PLACED THE SX 5000S IN MY GARAGE. WITHIN A WEEK, THE TWO SX5000S THAT HAD AIR IN THEM HAD BLOWN, AGAIN WITH THE TREAD SEPARATED. THE FAILURES OCCURRED WHEN THE WEATHER OUTSIDE TURNED HOT (SUMMER). TIRE PRESSURES WERE MAINTAINED NEAR (UNDER) THE MAXIMUM SIDEWALL SPECIFICATIONS, AND THE F-150 WAS NEVER OVERLOADED. THE TRUCK IS PRIMARILY USED FOR FAMILY TRANSPORTATION. I CALLED COOPER AT 1-800-854-6288 BECAUSE RECALL # 147 CLOSELY MATCHED THE PROBLEMS I EXPERIENCED, BUT I WAS TOLD MY TIRES WERE MANUFACTURED IN 2003 AND WERE NOT COVERED BY THE RECALL. THE TIRE INFORMATION IS: DOT 3DM2 B7W3903 C14R. I WAS ADMONISHED BY THE COOPER REPRESENTATIVE ABOUT PURCHASING AND USING USED TIRES, BUT GIVEN THE CIRCUMSTANCES OF ALL FOUR TIRES ESSENTIALLY BLOWING OUT WITH TREAD SEPARATION IN UNEXPECTED FASHION WITHIN A FEW WEEKS (OF SUMMER TEMPERATURES), I FEEL THAT THE UNDERLYING PROBLEM IS THE DESIGN OF THE TIRES, AND NOT THAT THE TIRES WERE ABUSED. UNTIL THE FAILURES, THE AIR PRESSURE IN THE TIRES DID NOT FALL OR RISE EXCEPT DUE TO AIR TEMPERATURES AND DRIVING FORCES, AND THE TREAD LIFE WAS AT LEAST 50%. *TR

NHTSA ID
10378457
Incident
Jul 1, 2010
Fuel system
Filed Sep 28, 1999

THERE IS A HOLE IN THE GAS TANK. DEALER HAS BEEN CONTACTED. *AK

NHTSA ID
848872

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

01157

INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC

98246

ELECTRICAL SYSTEM

FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC

9888

POWER TRAIN:AUTOMATIC TRANSMISSION

INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC

97511

POWER TRAIN:AUTOMATIC TRANSMISSION

FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD

9747

STRUCTURE

FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD

97310

SUSPENSION:FRONT:SPRINGS:LEAF SPRING ASSEMBLY:HANGER,BRACKET

NOISE- "POPPING/CREAKING"- FRONT FRAME OR SUSPENSION BRACKETS- FRAME- "POPPING/CREAKING"- FASTENER REPLACEMENT. *JD

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Ford F-150 by model year
YearComplaintsRecallsInvestigationsIssue Index
2026410—
202510012062.6
202418310068.1
202339612060.7
202257423268.2
202197429163.2
202070911164.2
20191,3029164.0
20182,26519266.3
20171,40118370.1
20162,01014467.5
20151,67114568.3
20141,5158262.6
20132,9703361.0
20121,7764458.8
20112,1846458.8
20108421042.6
20093242050.5
20083681151.0
20074887159.4
200658514263.9
20051,11214362.1
20042,02816460.6
200342211366.8
200282110366.2
20011,23619670.9
20001,07417474.6
19991,04418565.6
19981,381181165.5
19972,758261866.9
19963247267.6
19956267164.4
199467613266.4
199358613260.0
19924709867.2
199130461268.8
199027551168.3
19892244567.8
19881392670.4
1987913271.1
1986611461.0
1985281260.8
1984151255.9
1983101159.8
1982500—
1981Viewing230—
1980340—
19792100—
19784100—
1977360—
1976020—
1975140—
1973010—
1968100—
1966100—
1955100—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.