Opened Jun 22, 2006
Closed Dec 7, 2007
IN A DECEMBER 3, 2007 LETTER, FORD ADVISED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL TO REPLACE THE CAM POSITION SENSOR (CPS) IN APPROXIMATELY 1.2 MILLION SUBJECT VEHICLES TO ADDRESS REPORTS OF ENGINE STALLING.A NEW DESIGN CPS WITH IMPROVED PERFORMANCE AND DURABILITY WILL BE INSTALLED AS A REMEDY.OWNER NOTIFICATIONS WILL BEGIN IN DECEMBER 2007. THE SUBJECT VEHICLES ARE DURABLE, FULL-SIZED, MEDIUM DUTY TRUCKS COMMONLY USED FOR COMMERCIAL PURPOSES, RESCUE/EMERGENCY RESPONSE, AND COMMERCIAL OR RECREATIONAL TOWING.CPS FAILURE IS COMPARABLE TO UNEXPECTEDLY TURNING THE KEY OFF SINCE THE SIGNAL IT PRODUCES IS VITAL TO THE ELECTRONIC ENGINE CONTROL SYSTEM.CPS SIGNAL LOSS TERMINATES FUEL INJECTION RESULTING IN AN ENGINE STALL.ONCE STALLED, THE ENGINE MAY RESTART RIGHT AWAY, OR MAY RESTART AFTER A DELAY (TYPICALLY 5 TO 10 MINUTES), OR MAY NOT RESTART AT ALL.IN ADDITION TO EXPOSING THE DRIVER AND OTHER MOTORISTS TO CRASH RISK DUE TO LOSS OF MOTIVE POWER OR VEHICLE DISABLEMENT, ENGINE STALLING ALSO EFFECTS THE POWER ASSISTED STEERING AND BRAKING. THROUGH CONSUMER INTERVIEWS, ODI DETERMINED THAT CPS FAILURES OCCURRED WITHOUT ANY FORM OF WARNING, AT ANY VEHICLE SPEED (50% AT HIGHWAY SPEEDS), AND UNDER ANY DRIVING CONDITION, SUCH AS ACCELERATING.CONSUMERS REPORTED THAT ABOUT A THIRD OF THE VEHICLES FAILED TO RESTART, WITH ANOTHER THIRD REPORTING DELAYED RESTARTING.HALF THE VEHICLES THAT DID RESTART EXPERIENCED ANOTHER STALL ON THE SAME OR A SUBSEQUENT DRIVE CYCLE (BEFORE CPS REPLACEMENT) RE-EXPOSING THOSE CONSUMERS TO THE RISKS ASSOCIATED WITH A STALLING EVENT.IN THEIR VOQ REPORTS, HALF OF THE ODI COMPLAINANTS DESCRIBED DIFFICULTY CONTROLLING THE VEHICLE DUE TO LOSE OF POWER ASSIST SYSTEMS, ESPECIALLY THOSE WHO WERE TOWING AT THE TIME OF THE INCIDENT. THE ONE ALLEGED INJURY INCIDENT OCCURRED IN AN INTERSECTION WHEN A SUBJECT VEHICLE STALLED WHILE TURNING ACROSS ONCOMING LANES OF TRAFFIC.ALTHOUGH UNSUBSTANTIATED, THE COMPLAINANT ALLEGED AN INJURY TO A CHILD OCCUPANT DURING ODI'S INTERVIEW.THE OTHER CRASH ALLEGATIONS MOSTLY INVOLVED LOW SPEED, LOSS OF CONTROL INCIDENTS OFTEN CAUSED BY LACK OF POWER ASSIST; NO INJURIES ARE REPORTED IN THESE INCIDENTS, AND PROPERTY DAMAGE, IF ANY, WAS MINIMAL.CONSUMERS ALSO REPORTED OTHER INCIDENTS WITH SIGNIFICANT SAFETY RISKS, SUCH AS DISABLEMENT IN A LANE OR ON A SHOULDER OF A HIGH-SPEED ROADWAY OR INTERSTATE, OR EXTENDED DISABLEMENT IN REMOTE AREAS DURING SEVERE WEATHER CONDITIONS. THE POPULATION ABOVE IS FORD'S ESTIMATE OF THE 1.4 MILLION SUBJECT VEHICLES PRODUCED THAT ARE CURRENTLY REGISTERED.THE FORD COMPLAINT AND WARRANTY COUNTS NOTED ABOVE ARE CURRENT AS OF FORD'S LAST SUBMISSION DATED JUNE 21, 2007; THEY DO NOT INCLUDE F-450, F-550, OR ECONOLINE COUNTS AS THESE PRODUCTS WERE NOT FORMALLY WITHIN SCOPE OF THE INVESTIGATION WHEN FAILURE INFORMATION WAS REQUESTED.WARRANTY DATA ANALYSIS INDICATES THAT ABOUT HALF THE CLAIMS INVOLVED A STALL WHILE DRIVING EVENT ( FORD'S ASSESSMENT) AND THAT POOR CPS DURABILITY WAS A LONGSTANDING CONCERN.FORD REPORTED THAT THE NEW CPS DESIGN SHOULD MEET OR EXCEED THEIR 10 YEAR, 150K MILE LIFE EXPECTANCY DESIGN REQUIREMENT.
ENGINE AND ENGINE COOLING:ENGINE:DIESELLed to recall 07V553000 SPARK PLUG EJECTION FROM CYLINDER HEAD
Opened Sep 22, 2005
Closed Jan 4, 2006
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
ENGINE AND ENGINE COOLING:ENGINE
Opened Feb 15, 2005
Closed Nov 2, 2005
IN A JUNE 7, 2005 LETTER, FORD NOTIFIED ODI THAT IT WOULD BE CONDUCTING A SAFETY RECALL OF APPROXIMATELY 180,000 FORD F-SUPER DUTY, EXCURSION AND E-SERIES VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINES TO CORRECT TWO WIRING RELATED CONDITIONS THAT COULD RESULT IN ENGINE STALL (NHTSA RECALL NO. 05V-270, FORD NO. 05S34).THE AFFECTED VEHICLES WERE BUILT BETWEEN SEPTEMBER 29, 2003 AND MAY 31, 2004.ACCORDING TO FORD, VEHICLES WITH THE CONDITIONS MAY STALL WITHOUT WARNING AND MAY OR MAY NOT RESTART.FORD WILL INSTRUCT OWNERS OF VEHICLES INCLUDED IN THE RECALL TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE FUEL INJECTOR CONTROL MODULE WIRE HARNESS UPGRADED OR REPLACED AND OR HAVE A NEW INJECTION CONTROL PRESSURE SENSOR CONNECTOR INSTALLED.DURING A MAY 2005 PRESENTATION TO ODI, FORD IDENTIFIED A NUMBER OF POTENTIAL FAILURE MECHANISMS THAT COULD AFFECT ENGINE PERFORMANCE IN VARIOUS SEGMENTS OF THE SUBJECT VEHICLE POPULATION, INCLUDING THE WIRING CONDITIONS ADDRESSED BY 05V-270.THE WIRING CONDITIONS, WHICH BOTH AFFECT ENGINE FUELING, WERE THE MOST LIKELY CONDITIONS TO RESULT IN ENGINE STALL.THE RECALLED VEHICLES COMPRISE APPROXIMATELY 43% OF THE SUBJECT VEHICLE POPULATION AND ACCOUNT FOR 75 OF THE 113 ODI REPORTS THAT HAVE A VALID VIN (66%).THE VOQ COMPLAINT RATE FOR THE RECALL POPULATION IS 45/100K WHILE THE RATE FOR VEHICLES OUTSIDE THE RECALL POPULATION IS 17/100K AND THEIR TREND (BY DATE OF RECEIPT) IS DECLINING.BASED ON THE ANALYSIS, ODI BELIEVES FORD?S ACTIONS ARE SUFFICIENT TO ADDRESS THE CURRENT SAFETY RISKS AND THE INVESTIGATION IS THUS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY RELATED DEFECT DOES NOT EXIST.FURTHER ACTION WILL BE TAKEN IF WARRANTED BY FUTURE CIRCUMSTANCES.
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOODLed to recall 05V270000 PE04070ClosedPreliminary Evaluation ENGINE STALLING
Opened Oct 7, 2004
Closed Feb 15, 2005
TWENTY FIVE OF THE ODI FAILURE REPORTS ARE DUPLICATIVE OF FORD COMPLAINTS.TWENTY ODI REPORTS DO NOT CONTAIN A VIN (AND MAY OR MAY NOT BE DUPLICATIVE OF FORD REPORTS).THE 14 ALLEGED CRASHES AND 2 ALLEGED INJURIES WERE ALL MINOR.SUBMITTED DURING PRELIMINARY EVALUATION (PE) 04-070, FORD'S RESPONSE TO ODI'S INFORMATION REQUEST (IR) LETTER CONTAINED ABOUT 5,000 CONSUMER REPORTS (MORS) AND 8,700 FIELD REPORTS (CQIS).FORD REVIEWED THE COMPLAINTS AND CATEGORIZED THEM.THE MANUFACTURER REPORTS SHOWN ABOVE REPRESENT A COUNT OF UNIQUE VEHICLES THAT FORD CATEGORIZED AS ALLEGEDLY STALLING DUE TO A SUBJECT ENGINE COMPONENT ('A' CATEGORY, SEE FORD'S IR RESPONSE LETTER FOR FURTHER DETAIL); SOME OF THESE VEHICLES RECEIVED MULTIPLE REPORTS.ODI HAS NOT YET CONFIRMED FORD'S CATEGORIZATION OF THESE REPORTS, NOR HAS ODI CONFIRMED FORD'S CATEGORIZATION OF THE REMAINING REPORTS (WHICH FORD STATES DO NOT PERTAIN TO THE ALLEGED DEFECT).FORD SUBMITTED NEARLY 19,000 WARRANTY CLAIMS, MANY OF WHICH INVOLVED CLAIMS FOR A TECHNICAL SERVICE BULLETIN (TSB 04-13-08) AND FIELD SERVICE ACTION (FSA 03B05) WHICH FORD IDENTIFIED AS POTENTIAL REMEDIES FOR STALLING COMPLAINTS.ODI HAS NOT CONFIRMED THAT EITHER OF THESE ARE A REMEDY FOR ENGINE STALLING COMPLAINTS.SEVERAL OTHER DEALER COMMUNICATIONS RELATED TO ENGINE STALL WERE ALSO SUBMITTED AS WELL AS OVER 50 PRODUCT MODIFICATIONS, 15 OF WHICH INVOLVE REVISIONS TO THE SOFTWARE FOR THE ELECTRONIC ENGINE CONTROL UNIT.FURTHER INVESTIGATION IS REQUIRED AND ODI IS UPGRADING PE04-070 TO AN ENGINEERING ANALYSIS (EA).DURING THE EA, ODI WILL ESTABLISH AND UPDATE MANUFACTURER FAILURE REPORT COUNTS, FURTHER INVESTIGATE THE FREQUENCY AND TREND OF STALLING COMPLAINTS, AND DETERMINE THE SCOPE AND SAFETY IMPLICATION OF STALLING EVENTS.ODI WILL ALSO INVESTIGATE FORD'S REMEDIES, THEIR EFFECTIVENESS, AND WHETHER FURTHER ACTION IS REQUIRED.
ENGINE AND ENGINE COOLING:ENGINE:DIESEL