2011 Ford F-250 Sd

The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.

I WAS TRAVELLING DOWN THE INTERSTATE AT APPROXIMATELY 72MPH AND THE VEHICLE STARTED SHAKING VIOLENT AND I ALMOST LOST CONTROL. MY WIFE DROVE IT AND I WAS BESIDE HER ON THE INTERSTATE AND IT HAPPENED TO HER ALMOST CAUSING HER TO WRECK THE VEHICLE. I HAD TO CALL HER TO CALM HER DOWN. PLEASE HELP FIX THIS PROBLEM BEFORE SOMEONE GETS KILLED.

NHTSA ID

11222820

Incident

Jun 22, 2019

Mileage

100,000 mi

THE FUEL RAIL PRESSURE SENSOR STARTED SPRAYING DIESEL FUEL ALL OVER THE TOP OF THE MOTOR . THE FUEL IS COMING OUT OF THE TOP OF THE SENSOR .THIS IS ON 05/25/19 .. THIS TRUCK ONLY HAS 132214 ON THE MILEAGE . I AM GETTING TIRED OF PAYING FOR A BROKEN TRUCK EVERY WEEK . LAST WEEK ON 05/05/17/19 THE INNER COOLER BOOT DUCT BLEW APART . THAT WAS A $480 FIX .

NHTSA ID

11209949

Incident

May 25, 2019

Mileage

132,214 mi

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE 'DEATH WOBBLE' WHEN DRIVING HIGHWAY SPEEDS AND OVER UNLEVELED LAND. THE VEHICLE WAS UNSAFE TO DRIVE OVER 35 MPH DUE TO THE VIOLENT SHAKING AND VIBRATION. AN INDEPENDENT MECHANIC DIAGNOSED THE FAILURE AS THE 'DEATH WOBBLE' AND REPLACED THE TRACT BAR, BALL JOINTS, STEERING STABILIZER, STEERING DAMPER, AND PERFORMED AN ALIGNMENT; HOWEVER, THE FAILURES CONTINUED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 45,423.

NHTSA ID

11204371

Incident

Dec 4, 2018

Mileage

45,423 mi

TRUCK CONTINUES TO HAVE THE DEATH WOBBLE AS I DRIVE AT HIGHWAY SPEEDS AND HIT A SMALL PORTHOLE OR BUMP IN THE ROAD. THE WOBBLE BECOMES SO SEVERE THAT I HAVE LITTLE TO NO CONTROL OVER THE TRUCK. THIS HAS BEEN GOING ON AFTER 6MONTHS FROM PURCHASE DATE (NEW) BUT FORD SAYS THEY CAN NOT DUPLICATE. IT HAPPENS ABOUT 1-5X A WEEK AND I'VE NEARLY HIT SEVERAL OTHER VEHICLES ON THE HIGHWAY EACH TIME BY SWIRLING DURING THE WOBBLE. I LOOSE DIRECTIONAL CONTROL. I HAVE HAD A CRASH AS A RESULT OF THIS.

NHTSA ID

11204247

Incident

Apr 28, 2019

EXTREME SHAKING OF THE STEERING WHEEL WHEN ENCOUNTERING A SHIFT IN ROAD SURFACE SUCH AS AN EXPANSION JOINT, ETC AT AROUND 55 MPH AND TURNING SLIGHTLY LEFT. THIS HAS OCCURRED ON FREEWAYS, HIGHWAYS AND ROADS. LINK TO VIDEO: HTTPS://WWW.YOUTUBE.COM/WATCH?V=UVTUQV60JNU

NHTSA ID

11171153

Incident

Jul 8, 2018

Mileage

69,000 mi

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. WHILE DRIVING OVER UNEVEN LAND AND BUMPS IN THE ROAD, THE VEHICLE SHOOK VIOLENTLY. ALSO, THE STEERING WHEEL VIBRATED AND THERE WAS A STRONG VIBRATION FELT IN THE FRONT OF THE VEHICLE WHILE DRIVING HIGHWAY SPEEDS. GERMAIN FORD OF BEAVERCREEK (2356 HELLER DR, DAYTON, OH 45434, 1-(937) 429-1300) WAS NOTIFIED OF THE FAILURE AND COULD NOT DETERMINE THE CAUSE OF THE FAILURE WITHOUT GUIDELINES FROM THE MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 58,000.

NHTSA ID

11150119

Incident

Oct 31, 2018

Mileage

58,000 mi

MICHELIN LTX MS/S2 275/70 R18 TIRE WITH LESS THAN 25K HAD TO BE REPLACED BECAUSE OF TREAD SEPARATION. WHILE AT DISCOUNT TIRE, SPOKE WITH ANOTHER CUSTOMER WITH SAME VEHICLE - 2012 INSTEAD OF 2011 F-250 WHO HAD 3 TIRES WITH TREAD SEPARATION ISSUES.

NHTSA ID

11139904

Incident

Oct 1, 2018

Mileage

74,000 mi

MY FORD WAS PURCHASED AS A ONE OWNER TRUCK WITH 44,000 MILES FROM A DEALERSHIP IN FLORIDA. OWNED BY A PERSON BRAND NEW ALSO IN FLORIDA. I LIVE IN SOUTH WESTERN VA PLEASE TAKE A LOOK AT MY BRAKE CALIPERS. I NEVER SEEN ANYTHING LIKE THIS. HUGE DANGER ESPECIALLY WHEN THIS TRUCK IS MADE TO PULL HEAVY WEIGHT THAT NEEDS GOOD BRAKES. MY TRUCK HAS 107,000 MILES FOUND OUT BY REPLACING BRAKE PADS FOR SECOND TIME

NHTSA ID

11089575

Incident

Apr 23, 2018

Ford and Lincoln vehicles equipped with wired keyless entry keypad systems and accessory wireless keyless entry keypad systems may or may not come with a wallet card containing the master code. Unlike the integrated wired keypad, the accessory wireless keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool or from the label printed on the body control module (BCM). The Factory Keyless Entry Code application within the diagnostic scan tool will not provide an applicable master code for the accessory wireless keypad. If the wallet card for an accessory keypad is not available, the "Wireless RF Keypad Diagnosis Guide" can be referenced and provides direction on how to retrieve the master code. This guide is located under the Workshop Manual tab > Accessories > Installation > Wireless RF Keypad Diagnosis Guide > PPT C > Step C2.<br /><br /> Note: The only available keypad for some vehicles from the assembly plant is the accessory wireless keyless entry keypad. The integrated wired keypad cannot be installed on vehicles not equipped from the factory with a wired keyless entry k

Certain 2011-2022 Model Year Super Duty Vehicles Equipped with 6.7L Engine - Emission Control Information Label Update for Qualified Vehicles

All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during initial delivery. Unlike the integrated (wired) factory keypad, the accessory keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool. If the wallet card for an accessory keypad is lost, follow these steps to recover the code. Dealer Key Code access is granted through the Dealer Program Enrollment System (DPES); dealership management can authorize users. The authorized user must go to FMCDealer.com > Parts and Service > Parts Product Line Information > Keys/Entry Devices > Aftermarket Keyless Entry Keypad Code Access. Follow the instructions on the screen to obtain the master code for the accessory keypad.

Certain 2011-2012 Model Year F-Series Super Duty Vehicles Equipped with a 6.7L Diesel Engine State Inspection and Maintenance Test Failure Due to DTCs P2073 and/or P2074 Adding owner letter and corrected dealer bulletin. First Part submitted 11/01/23

Certain 2011-2012 Model Year F-Series Super Duty Vehicles Equipped with 6.7L Diesel Engine State Inspection and Maintenance Testing Failure Due to DTCs P2073 and/or P2074

Customer Satisfaction Program 22N14 – Supplement #1 Certain 2011-2012 Model Year F-Series Super Duty Vehicles Equipped with a 6.7L Diesel Engine - State Inspection and Maintenance Test Failure Due to DTCs P2073 and/or P2074