2006 Ford F-250 Sd

THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.

FRONT END VIBRATION WHILE DRIVING AROUND 60MPH WHICH TURNS INTO A REAL BAD SHIMMY SOMETIMES. STEERING WHEEL SHAKES VIOLENTLY. HAVE RECEIVED A COUPLE OF NOTICES FROM FORD MOTOR CO. THAT TELL ME THEY ARE AWARE AND TO JUST SLOW DOWN WHEN IT HAPPENS. THIS HAS HAPPENED SEVERAL TIMES SINCE I HAD THE TRUCK SINCE 2011. NO SPECIFIC DATES.

NHTSA ID

11053449

Incident

Sep 1, 2016

CPSC: THE RIGHT FRONT TIRE DEVELOPED A TERRIBLE BOUNCE ATSPEEDS LESS THAN 30 MPH. I RETURNED THE TRUCK TO RICK'S TIRES AND HE CONTACTED FREESERVICE TIRES. *BF THE CONSUMER WAS ADVISED THE BELTS SEPARATED ON THE LEFT. THE TIRE WAS REPLACED. THE RIGHT REAR TIRE EXPLODED WHILE TOWING A BOAT. THE TIRED HAD A LARGE HOLE AND PART OF THE TREAD SEPARATED FROM THE INNER TIRE. THIS CAUSED DAMAGE TO THE RIGHT PICK UP BED OUTER WALL AND BRACING SUPPORTS. UPDATED 06/28/2017*JS

NHTSA ID

11002169

Incident

Mar 31, 2017

FUEL TANK STRAPS FAILED DUE TO CORROSION AND FUEL TANK FELL TO GROUND WHILE IN MOTION ON A HIGHWAY

NHTSA ID

10990988

Incident

May 5, 2017

Mileage

188,000 mi

EMERGENCY BRAKES DO NOT HOLD. HAVE HAD THEM CHECKED FOR ADJUSTMENT SEVERAL TIMES. IS A MAJOR PROBLEM WITH A MANUAL TRANSMISSION AS IT HAS NO PARK PINS. ALTHOUGH MY INSURANCE COVERED IT, IT ACTUALLY ROLLED INTO ANOTHER BUILDING ON MY PROPERTY. I HAVE TO US A WOOD BLOCK AGAINST THE WHEEL TO STOP IT FROM ROLLING ON ALL BUT THE SLIGHTEST INCLINE. THERE HAVE BEEN SEVERAL OCCURRENCES WHEN THIS HAS HAPPENED.

NHTSA ID

10978627

Incident

Dec 23, 2012

Mileage

85,000 mi

WHILE DRIVING AND GOING OVER A BUMP BETWEEN 60 AND 70 MPH ON THE HIGHWAY, THE TRUCKS FRONT END STARTS TO VIOLENTLY SHAKE CAUSING THE TRUCK TO LOSE CONTROL. NOTE ONLY DRIVING POSTED SPEED LIMIT. THIS HAS HAPPENED ON THREE (3) OCCASIONS MOSTLY RECENTLY 7/17/16 AND 7/19/16 WHILE TRAVELING S/B ON INTERSTATE 95 AND TRAVELING N/B ON INTERSTATE 95. THE DEFECT CAUSES YOU TO DRIVE AT REDUCED SPEEDS ON THE HIGHWAY. HAVE DONE RESEARCH AND IT IS A COMMON PROBLEM WITH FORD TRUCK WITH STRAIGHT FRONT AXLES. FORD IS AWARE OF THE PROBLEM.

NHTSA ID

10886051

Incident

Jul 17, 2016

Mileage

120,155 mi

I HAVE BF GOODRICH RUGGED TRAIL T/A 275 70 R18 TIRES ON MY 2006 FORD F250 WHICH WERE PURCHASED 25 MONTHS AGO AND HAVE 22000 MILES ON THEM. WHILE TOWING MY TRAVEL TRAILER I EXPERIENCED A SLIGHT VIBRATION WHILE DRIVING. I IMMEDIATELY PULLED OVER AND CHECKED THE VEHICLE AND CAMPER FOR NY VISIBLE SIGNS OF A PROBLEM. EVERYTHING A APPEARED TO BE IN GOOD WORKING ORDER SO I CONTINUED ON DRIVING SLOWER. AFTER ABOUT 10 MILES THE TIRE COMPLETELY BLEW UP DAMAGING MY VEHICLE AND SENDING THE TREAD OF THE TIRE ACROSS THE OTHER LANES TRAFFIC WHICH ALMOST CAUSED A MAJOR VEHICULAR ACCIDENT. I THOUGHT IT WAS BAD LUCK. I CHANGED THE TIRE AND CONTINUED DOWN THE ROAD. AFTER APPROXIMATELY ANOTHER 200 MILES I STARTED GETTING THE SAME VIBRATION FROM THE REAR DRIVERS SIDE TIRE. FEARING ANOTHER BLOW OUT AND HAVING NO SPARE TIRE I PULLED OVER AND SPENT THE NIGHT IN A CAMPGROUND. THE NEXT MORNING I WENT OUT TO GET TIRES AND UPON THE TIRE PERSONAL INSPECTING THE TIRE THEY SAID THAT IT HAD A AIR BUBBLE UNDER THE TREAD AND THAT IT TOO WOULD HAVE MORE THAN LIKELY BLOWN OUT ON ME. I DIDN'T THINK THAT THIS WAS COINCIDENCE ANYMORE. SO UPON GETTING HOME I CALLED BF GOODRICH AND MADE A COMPLAINT. THEN I RESEARCHED THE TIRES AND SAW THAT A BUNCH OF THEM WERE RECALLED. JUST THAT MINE WAS NOT WITHIN THE THE MANUFACTURE'S DATE CODE WITH IN A FEW WEEKS. I FEEL THAT IF I HADN'T HAD THAT CAMPER BEHIND ME THAT I PROBABLY COULD HAVE LOST CONTROL OF MY TRUCK WITH POSSIBLE CATASTROPHIC CONSEQUENCES.

NHTSA ID

10884819

Incident

Jul 9, 2016

Mileage

22,000 mi

HEADS WENT BAD NOW I HAVE TO REPLACE THE HEADS AND NEW HEAD STUDS BECAUSE THE OLD HEAD STUDS STRETCHED AND THE HEADS WARPED , ALSO HAD TO DO AN EGR DELETE . I WAS TOLD IT WAS BUILT PROOFING AND IT HAS TO BE DONE TO ALL 6.0 LTRS.

NHTSA ID

10874521

Incident

Oct 21, 2015

Mileage

155,000 mi

LIKE TOYOTA CARS, IF "WINTER-STYLED, RUBBER FLOOR MAT ON DRIVERS SIDE BECOMES UNHOOKED & SLIDES FORWARD, IT CAN LODGE THE ACCELERATOR DOWN CAUSING A HIGH SPEED. IT HAS HAPPENED TO ME SEVERAL TIMES, ALMOST CAUSING ME TO LOOSE CONTROL. THESE ARE FORD FACTORY INSTALLED MATS I PAID EXTRA FOR AT TIME VEHICLE WAS PURCHASED NEW. OCCURS WHEN I ACCELERATED HARD, SUCH AS TO PASS ANOTHER CAR OR ENTER/MERGE ONTO AN INTERSTATE. HAD TO PUT CAR IN NEUTRAL AND PULL MAT BACK. HAS HAPPENED SEVERAL TIMES SINCE VEHICLE WAS PURCHASED.

NHTSA ID

10863294

Incident

Jun 1, 2009

Mileage

5,000 mi

When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. After 30-Jun-2023, MERCON SP ATF will no longer be manufactured and will only be available until inventory depletes.

Some 2005-2021 F-Super Duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. A knuckle seal shield kit is now available for customer purchase. The kit is designed for severe duty and is non warrantable. The knuckle seal shield kit GC3Z-54024A38-A includes an installation instruction sheet

These SKUs are Trailer Brake Control Modules. The customer communication requested return of unsold inventory due to an internal software issue. The internal software issue leads to a false check trailer brake message and Trailer Brake Controller fault whenever the brake pedal is pressed. This will cause the part to be replaced, due to repetitive dashboard warning light, even though it sends signals to the trailer brakes properly.

Some 2005-2020 F-Super Duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. A knuckle seal shield kit is now available for customer purchase. The kit is designed for severe duty and is non warrantable. The knuckle seal shield kit GC3Z-54024A38-A includes an installation instruction sheet

This SKU is a Spare Tire Hoist. Test results identified that the pull force parameter was not within specification, as a precautionary measure unsold inventory was requested to be returned for testing and containment. We don't have evidence that these test results have contributed to a product failure.

This SKU is a Spare Tire Hoist. Test results identified that the pull force parameter was not within specification, as a precautionary measure unsold inventory was requested to be returned for testing and containment. We don't have evidence that these test results have contributed to a product failure.