1997 Ford Mustang

ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.

There is no summary currently available

Unknown I lost control of my steering and almost wrecked

NHTSA ID

11528744

Incident

Jun 24, 2023

TL* THE CONTACT OWNS A 1997 FORD MUSTANG. THE CONTACT STATED THAT THE STEERING WHEEL WAS CRACKED IN THE LOCATION OF THE HORN. THE FAILURE CAUSED THE AIR BAG TO BECOME EXPOSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE AIR BAG WOULD NOT DEPLOY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

11265433

Incident

Jun 1, 2019

MUSTANGS DRIVER SIDE AIR BAG DID NOT DEPLOY DURING HEAD ON CRASH. *TR

NHTSA ID

10689543

Incident

Dec 18, 2014

TL* THE CONTACT OWNS A 1997 FORD MUSTANG. THE CONTACT STATED THAT WHILE TRAVELING 35 MPH, A FOUL ODOR STARTED TO EMIT INTO THE CABIN. THE CONTACT THEN MERGED TO THE SIDE OF THE ROAD BECAUSE HE BECAME DISTRAUGHT. THE VEHICLE WAS DRIVEN TO THE CONTACT'S HOME. THE VEHICLE WAS NOT TAKEN TO A MECHANIC AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 128,000 AND THE CURRENT MILEAGE WAS 130,000.

NHTSA ID

10478613

Incident

Sep 15, 2012

Mileage

128,000 mi

TL* THE CONTACT OWNS A 1997 FORD MUSTANG. THE CONTACT STATED THAT THE PLASTIC INTAKE MANIFOLD WAS CRACKED AND CAUSING COOLANT TO LEAK. THE CONTACT BELIEVED THAT THE FAILURE WAS CONTRIBUTED TO A DESIGN FLAW. THE DEALER WAS CONTACTED AND THEY ADVISED THE CONTACT THAT THEY WOULD NOT SERVICE ANY VEHICLES OVER TEN YEARS OF AGE. THE CONTACT STATED THAT THE INTAKE MANIFOLD FAILED TWICE SINCE OWNING THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 150,000.

NHTSA ID

10355543

Incident

Sep 7, 2010

Mileage

150,000 mi

I HAVE BEEN HAVING A PROBLEM WITH MY 1997 FORD MUSTANG. THIS IS A PROBLEM THAT HAS GOTTEN PROGRESSIVELY WORSE OVER THE PAST FEW YEARS. AT FIRST, WHEN STARTING MY CAR, THE ENGINE WOULD TURN OVER YET THE CAR WOULD IMMEDIATELY DIE. AFTER A COUPLE OF ATTEMPTS, THE CAR WOULD EVENTUALLY START AND STAY STARTED. NOW, WHEN ATTEMPTING TO START MY CAR, THE ENGINE TURNS OVER YET THE CAR DIES IMMEDIATELY. IN MOST CASES, THE CAR DOES NOT START UNTIL IT HAS BEEN SERVICED. IT HAS BEEN TAKEN TO 3 SERVICE PROVIDERS (INCLUDING FORD), WHO HAVE BEEN UNABLE TO DUPLICATE AND/OR FIX THE PROBLEM. RECENTLY, FORD REPLACED MY AIR FLOW VALVE AND SENSOR AND JUST AFTER PICKING THE CAR UP AND DRIVING IT FOR ABOUT 30 MINUTES, I WENT INTO A STORE JUST TO COME OUT AND FIND THAT MY CAR WON'T START. ONCE STARTED THE CAR ALWAYS CONTINUES TO RUN WITH NO PROBLEM. PLEASE PLEASE HELP! *TR

NHTSA ID

10207339

Incident

Oct 25, 2007

Mileage

82,100 mi

1997 FORD MUSTANG PASSENGER SIDE SEAT BELT WILL NOT RETRACT, DRIVERS SIDE RETRACTS ABOUT 98% OF THE TIME, 2% OF THE TIME, ITS RENDERED USELESS LIKE THE PASSENGER SIDE. FORD NOTIFIED, WAS TOLD IT WAS "OWNER ERROR". I DON'T THINK SO. *JB

NHTSA ID

10168103

Incident

May 22, 2006

Mileage

102,220 mi

TIE ROD FAILING 1997 FORD MUSTANG, VIN #[XXX], MILEAGE TO DATE 70,000. *JB UPDATED 07/17/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

10148166

Incident

Jan 1, 2006

Mileage

69,999 mi

SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE

EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. THE TERMS OF THE SETTLEMENT EXTEND THE COVERAGE OF THE ALL-COMPOSITE INTAKE MANIFOLD TO 7 YEARS FROM THE ORIGINAL WARRANTY START DATE OF THE VEHICLE, WITH NO LIMIT ON THE NUMBER OF MILES THAT THE VEHICLE HAS BEEN DRIVEN. *TT

GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT

INTERMITTENT LOSS OF POWER OR CRANK NO START - POSSIBLE PATS LAMP FLASHING AND DIAGNOSTIC TROUBLE CODES (DTCS) U1147 AND/OR U1262. *TT

REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT

MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT