2008 Hyundai Santa Fe

The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.

Engine rattles noise when starting the car after sitting for more than an hour it makes that sound another issue is that when i turn the headlights on all interior lights shuts off including the instrument cluster radio and ac climate control buttons

NHTSA ID

11725733

Incident

Mar 17, 2026

I have taken my car to my local dealership for the Service Campaign 976 (Oil Gasket leak) back in Nov 2023. Ever since then my car has had starting issues until one day it needed a jump start in 2024 during the summer. Didn't think anything of it at the time, until the beginning of 2025. Car needed a jump start in the winter before leaving for work in the morning and before going back home from work. My brother who is a auto mechanic suggested I needed a new battery by now so I did that. Once I replaced the battery on my car I noticed that I didn't have headlights, power steering or heat working in my car. He came to my home and checked my engine and noticed that my alternator was covered in oil. I remembered that I took my car to the dealership for this issue with the Service campaign. I've been back and forth with this issue between the dealership and corporate to look at this issue. The dealership can't provide any photo proof or documentation stating what work was done. The dealership claimed that Hyundai doesn't need photo proof as of 2023 and started needing it in 2024, they simple state that the work was done and sign the car off on the recall. I don't see how this isn't a safety issue when the description of the campaign says that my vehicle can shut off while driving causing a crash. I have a family that I drive in this vehicle and our safety isn't being a concerning issue with this matter because "It's outside of the warranty" that shouldn't matter if the dealership can not provide any proof that work was done besides putting a oil shield on the vehicle. The head gasket leak didn't seem to be resolved if the alternator is saturated in oil enough that it doesn't hold a charge.

NHTSA ID

11720879

Incident

Jun 10, 2025

I took the car to get this recall done: Hyundai has decided to conduct a service campaign to inspect (and if necessary replace) the alternator and replace the front valve cover gasket on certain 2007-2009 model year Santa Fe vehicles. The recall was done, replacing the gasket and alternator. 2 years later the car started to stall in the middle of traffic. I returned to the dealer, dealer inspected and reported "oil found on the new alternator and oil leak found on the real valve cover gasket". I have been going back and forth on the phone with Hyundai costumer care. They said they will not redo the recall. It was not done correctly and slowly leak again. the vehicle now cut off everyday specially when i stop and go at short drives. It has also cut off in traffic. making it very dangerous. But Hyundai is telling me nothing for them to do.

NHTSA ID

11695026

Incident

Oct 19, 2025

My speedometer has stopped working, I had the sensor replaced and fuses checked but it is still not working

NHTSA ID

11679065

Incident

Jul 24, 2025

Seem like it burns oil quick

NHTSA ID

11676652

Incident

Jul 28, 2025

The contact owns a 2008 Hyundai Santa Fe. The contact stated that the vehicle was taken to a local dealer for an undisclosed recall repair, and the contact was informed that the valve cover gasket, and the alternator were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 88,000.

NHTSA ID

11675922

Incident

May 21, 2025

Mileage

88,000 mi

My suv was involved in a Roll Over accident. The front driver tire blew out causing the driver to hit the curb which caused the SUV to roll 4 times. The driver was ejected from the vehicle while wearing a seat belt and not one air bag deployed. Major safety issues

NHTSA ID

11666888

Incident

May 16, 2025

The contact owns a 2008 Hyundai Santa Fe. The contact stated that the vehicle was experiencing difficulty charging. The contact stated that while driving 50-60 MPH, the vehicle stalled. The contact was able to pull to the side of the road. The contact stated that the failure had occurred several times while driving on the highway. The vehicle was able to be jump-started. The contact stated that a mobile mechanic had inspected the vehicle and informed the contact that there was oil leaking onto the spark plugs. The contact stated that the vehicle was chugging while driving. The contact became aware that the VIN was included in Hyundai Campaign Number: 976. The vehicle was taken to the dealer for repair. The dealer diagnosed that the valve cover gasket was leaking onto the alternator and onto other unknown parts. The dealer replaced the valve cover gasket and the alternator under Hyundai Campaign Number: 976. The contact stated after driving 7-8 minutes after picking up the vehicle from the dealer, the contact noticed an abnormal odor and smoke coming from underneath the hood. The contact pulled into a gas station and parked the vehicle. The manufacturer was notified of the failure and advised the contact to take the vehicle back to the dealer. The contact stated she drove to the nearby residence of a friend instead because she needed to report to work. The contact stated upon opening the hood and starting the vehicle the following day, the contact noticed flames in the engine compartment. The contact was able to extinguish the fire with a fire extinguisher. No police report was filed. There was no injury sustained. The vehicle was towed to the dealer, where the contact was informed that the fire had occurred due to an old oil leak; however, the contact stated there was also a noticeable new oil leak under the hood. The dealer later informed the contact that the starter had failed, and that the fire had not caused any further damage to the vehicle. The vehicle was not repaired. The manufacturer was contacted and

NHTSA ID

11655464

Incident

Nov 30, 2024

Mileage

87,000 mi

The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or non‑certified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious injuries and fatalities. Please see attached announcement, provided by NHTSA, for more details.

The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts. These dangerous inflators have ruptured during deployment, posing a serious risk of injury or death due to metal fragments entering the vehicle cabin. To date, Hyundai is aware of three people who have died while driving a Hyundai vehicle with one of these substandard replacement airbag inflators that deployed in what likely would have been a survivable crash. NHTSA has issued a public advisory urging vehicle owners and service professionals to have vehicles inspected if there is reason to believe that a non-genuine replacement airbag may have been installed. Vehicles with salvage or rebuilt titles, prior airbag deployments, or unknown repair histories may present a higher risk. NHTSA strongly cautions against self-inspection by vehicle owners and recommends inspection by trained technicians.

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside the lamp assembly. Lamp assembly replacement is NOT necessary in most cases. This condition can be eliminated by turning on the lamps with the engine running for several minutes or during normal driving operation.

Some Santa Fe (CM) vehicles may have an engine that potentially leaks oil from the front cylinder bank’s valve cover onto the alternator. Oil could damage the alternator resulting in illumination of the charging system warning lamp and disablement of the charging system. If the vehicle is continually driven without recharging the battery, the engine will eventually shut off, increasing the risk of a crash. This bulletin outlines the procedures to inspect for T-joint leakage and install an oil protector to address this issue.

Some Santa Fe (CM) vehicles may have an engine that potentially leaks oil from the front cylinder bank’s valve cover onto the alternator. Oil could damage the alternator resulting in illumination of the charging system warning lamp and disablement of the charging system. If the vehicle is continually driven without recharging the battery, the engine will eventually shut off, increasing the risk of a crash. This bulletin outlines the procedures to inspect for T-joint leakage and install an oil protector to address this issue.

This bulletin contains information about the proper removal of the windshield wiper blade protective cover on all models. If the protective cover is not removed correctly, there is a possibility of the rubber insert and rail spring becoming partially separated on the inner side of the wiper blade, which could lead to poor wiping performance and/or possible scratching of the windshield glass. Follow the procedure in this bulletin to properly remove the windshield wiper blade protective cover on all new wiper blades.