2021 Hyundai Sonata

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing.  There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DESCRIPTION OF SAFETY DEFECT & IMMEDIATE HAZARD:My 2021 Hyundai Sonata SEL is currently exhibiting the most severe, catastrophic symptoms of the fuel tank expansion defect covered under NHTSA Campaign 25V796000. The fuel tank has expanded so drastically that it physically warped the structural interior of the cabin, violently popping the rear passenger seat completely out of its assembly while the vehicle was in motion. Furthermore, there is a constant, heavy, raw gasoline odor inside and around the vehicle. The vehicle is a documented, active fire, explosion, and vapor inhalation hazard. It is currently physically located at Sterling Hyundai in Lafayette, LA.DESCRIPTION OF MANUFACTURER NON-COMPLIANCE & REFUSAL TO REMEDY:Hyundai Motor America and Sterling Hyundai are in direct violation of their legal obligation to provide a safe, accessible remedy or interim safety accommodations under federal recall guidelines. An Executive Case Manager from Hyundai Corporate has officially refused to provide a direct-billed rental vehicle or a dealer loaner.Initially, a third-party rental vehicle was provided. However, that vehicle was compromised in an accident and wrecked through absolutely no fault of my own. Despite my lack of fault, Hyundai Corporate and the dealership are now explicitly using that accident to refuse any further direct-billed rental accommodations or dealer loaners.Instead, they are demanding that I pay out-of-pocket for a rental vehicle at a rate of $60/day for a repair process expected to take multiple weeks, knowing I do not possess the upfront financial means to cover these costs. By imposing this insurmountable financial barrier due to an accident I did not cause, Hyundai has effectively stranded me. Because I must maintain my livelihood and have no other means of transportation, Hyundai’s bad-faith refusal to direct-bill an accommodation is actively forcing me to retrieve and operate a verified, explosive fire hazard.REMEDY SOUGHT:I request that the NH

NHTSA ID

11766388

Incident

Sep 23, 2026

The contact owns a 2021 Hyundai Sonata. The contact received notification of NHTSA Campaign: 25V796000 (Fuel System, Gasoline); however, parts were on back order. The contact stated that while driving at an undisclosed speed, the vehicle jerked with an abnormal gasoline odor inside the vehicle. An unknown warning light was temporarily illuminated. Upon further inspection, the contact became aware that the fuel level had dropped. The vehicle was taken to a local dealer where it was diagnosed with an expanded fuel tank. The contact stated that the O2 sensor, spark plugs, and ignition coils were replaced by a local independent mechanic; however, the failures persisted. The contact had headaches while driving the vehicle. Medical attention was not needed. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

NHTSA ID

11765048

Incident

Sep 15, 2025

Mileage

100,000 mi

Transmission replaced twice and all of them continue to fail. Several Hyundai service centers are unable to determine the cause and are only able to update/relearn and replace whenever they are able to replicate the issue. The issue is that at a cold start, the car makes a popping sound, jerks and shakes. The car hesitates to accelerate. You can hear the noise of acceleration but RPM does not go past 3 and MPH doesn't go past 30mph. I'm unable to upload docs because of the upload limit. If there's another way to send docs, please let me know

NHTSA ID

11764277

Incident

Jan 26, 2023

Massive loss of coolant in closed loop cooling system Heat soak. Fail safe mode

NHTSA ID

11759867

Incident

Apr 15, 2026

The contact owns a 2021 Hyundai Sonata. The contact received notification of NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the vehicle independently accelerated and decelerated while the accelerator pedal was depressed. The check engine warning light was illuminated. The vehicle was towed to a local dealer where it was diagnosed with an expanded frame due to an expanded fuel tank. The vehicle was deemed too expensive to repair per the local dealer and was towed for a buy-back. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 55,000.

NHTSA ID

11758588

Incident

Dec 15, 2025

Mileage

55,000 mi

I took my vehicle in for the safety recall due to an expanding fuel tank on 08/03/2026. I received my vehicle back on 8/12/2026. Hyundai performed an improper repair on the vehicle that will not correct the fuel tank expansion. They replaced the same check valve that was replaced last time I brought the vehicle in for recall on 11/20/2024 repair order # 107221 at Jones Hyundai of Belair. This valve did not and will not correct the fuel tank expansion issue. The expansion issue is caused by fuel getting past the check valve and entering the purge control system. The correct repair is to replace the fuel tank and the purge control system, as the check valve has already allowed fuel to bypass it and enter the system causing the expansion issue. . Replacing the valve that failed & allowed fuel into the system & caused the tank to expand will not correct the issue caused by the failed valve. My fuel tank has not decompressed. I still have the same problem I brought the vehicle in for because the repair Hyundai advised NHTSA on was NOT performed.

NHTSA ID

11757244

Incident

Aug 12, 2026

Gas tank expansion and pcv melted. Car smells like gas when I was driving earlier, and my garage was flooded with the fumes of gasoline.

NHTSA ID

11755570

Incident

Aug 7, 2026

The Left blinker switch keeps going in and out, working about 50% of the time. Both the light and the blinker sound do not turn on. When getting it checked out at an auto repair shop, the maintenance tech said this was more and more common for 2021 sonatas and it was not due to anything I did. It was a multifunction switch problem.

NHTSA ID

11755451

Incident

Aug 1, 2026

This bulletin provides information related to a Transmission Control Unit (TCU) software update for some vehicles equipped with an 8-speed wet dual clutch transmission (8WDCT). The software update revises the touch point learning variation, improving drivability and judder symptoms. Some 8WDCTs (indicated by a new part number) received an updated clutch spring. The correct TCU software update must be matched with the correct corresponding 8WDCT hardware, otherwise, drivability concerns may occur. This service procedure should be performed prior to any 8WDCT replacements done for drivability/judder concerns.

Some vehicles may exhibit difficulty starting in cold weather. This bulletin provides the procedure to perform an inspection on the starter magnetic switch for potential freezing and, if necessary, replace the starter magnetic switch (solenoid) assembly.

The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or non‑certified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious injuries and fatalities. Please see attached announcement, provided by NHTSA, for more details.

The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts. These dangerous inflators have ruptured during deployment, posing a serious risk of injury or death due to metal fragments entering the vehicle cabin. To date, Hyundai is aware of three people who have died while driving a Hyundai vehicle with one of these substandard replacement airbag inflators that deployed in what likely would have been a survivable crash. NHTSA has issued a public advisory urging vehicle owners and service professionals to have vehicles inspected if there is reason to believe that a non-genuine replacement airbag may have been installed. Vehicles with salvage or rebuilt titles, prior airbag deployments, or unknown repair histories may present a higher risk. NHTSA strongly cautions against self-inspection by vehicle owners and recommends inspection by trained technicians.

Some Santa Cruz (NXT), Santa Fe (TMA, MX5A), and Sonata (DN8A) models may require replacement of the 8-speed wet dual clutch transmission (8WDCT) when the vehicle sets one of the high pressure electric oil pump (HP EOP) DTCs listed below. This bulletin provides instructions to replace the 8WDCT.

Some 2019MY and newer vehicles equipped with a front view camera may illuminate certain warning lights and trigger DTC C272246 fault code for the front camera. In the following cases, the front camera auto-calibration range may be exceeded while driving: • If the front camera is not properly installed and is completely or partially detached. • In case of excessive changes affecting the vehicle's balance (e.g., loading excessively heavy cargo in a specific location of the vehicle, or significant under-inflation of the tires). • Specific road conditions affecting the vehicle's balance (e.g., excessive road crown) This TSB provides instructions on how to service the vehicle when the front camera related warning light(s) are triggered due to system out of calibration (DTC_C272246).