2021 Hyundai Elantra

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing.  There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

On August 8, 2022, the Office of Defects Investigation (ODI) opened this Recall Query (RQ) based on 3 incidents alleging front seat belt pretensioners that may rupture during deployment, on model year (MY) 2020-2022 of various Hyundai and Kia Models, resulting in 3 injuries (note: one incident occurred outside the U.S. and its territories).Between October 2021 and March 2023, Hyundai and Kia have filed the following 11 safety recalls for pretensioner rupture: NHTSA Recall No. 21V-796, 22V-069, 22V-123, 22V-127, 22V-218, 22V-354, 22V-447, 22V-458, 22V-816, 23V-094, and 23V-210.Hyundai/Kia have stated that the abnormal deployment of the pretensioners is due to over-pressurization of the pretensioner pipe that can cause metal fragments to enter the vehicle occupant compartment, which can result in injury to vehicle occupants.The various makes/models covered by the above recalls include approximately 405,900 certain 2020-2022 Hyundai Accent, 2021-2022 Hyundai Elantra and Elantra HEV, 2021-2022 Hyundai Santa Fe HEV, 2022-2023 Hyundai Santa Fe PHEV, 2020-2022 Hyundai Venue, 2021-2023 Genesis G80, 2023 Genesis G80 EV, 2023 Genesis G90, 2023 Genesis GV60 EV, 2022-2023 Genesis GV70, 2021-2023 Genesis GV80, 2021-2022 Kia Sorento HEV, and 2022 Kia Sorento PHEV.In response to ODI's investigation, in December 2022, Hyundai notified ODI that they would be conducting testing to validate subject vehicle seat belt pretensioners. This evaluation included sled testing and software testing which was performed by Hyundai and its suppliers. The tests were intended to evaluate pretensioner deployment characteristics based on the unique deployment signature of the subject and peer vehicles. ODI met with representatives from Hyundai on several occasions during the investigation to discuss testing progress and data. As a result of the testing, Hyundai was able to simulate the pretensioner failures. It was determined by Hyundai during testing, the front driver-side and/or passenger-side seat belt pretensioners may explode upon deployment in the event of a crash which can cause metal fragments to enter the vehicle occupant compartment.Hyundai thus notified ODI of their decision to proceed with a safety recall, to expand the scope of the previous safety actions.In view of the recall actions taken by Hyundai and Kia, ODI concerns have been addressed. The agency reserves the right to take additional action if warranted by future circumstances.

Vehicle was serviced to remediate Recall 271- backup camera replacement in January, 2025. In June 2026, vehicle is exhibiting the same issue. Rear camera is non functional in the following ways: 1. Vehicle is shifted to reverse, backup camera does not function; 2. Vehicle is in park backup camera button is pressed, backup camera does not function.

NHTSA ID

11756440

Incident

Jun 12, 2026

See attached document for complaint.

NHTSA ID

11746507

Incident

Mar 30, 2026

Door Lock Actuator, the door latch is stuck on unlock and it won’t close or lock when the lock button is pressed on key fob.

NHTSA ID

11745530

Incident

Jun 21, 2026

I am filing a complaint regarding a safety recall repair for my vehicle that is not being handled in a timely or reasonable manner by an authorized dealership Delray Hyundai 655 NE Sixth Ave, Delray Beach. Vehicle Information: 2021 Hyundai Elantra SE VIN: [XXX] Recall Information: NHTSA Recall #24V879000 Recall #271 – Backup Camera Inspection/Replacement This recall involves a failure of the backup camera system, which directly impacts visibility while reversing and poses a safety risk. The manufacturer has indicated that a remedy is available; however, the dealership I contacted is refusing to perform recall repairs on weekends and is only offering an appointment more than a month out (scheduled for May 4th). Given that this is a safety-related recall affecting rear visibility, this delay is unreasonable and places me at continued risk while operating the vehicle. I rely on my vehicle daily and should not be required to wait an extended period for a safety recall repair that is already available. Additionally, limiting recall repairs to weekday-only appointments creates an unnecessary barrier for consumers who work standard business hours. I am requesting that this issue be reviewed, and that appropriate action be taken to ensure dealerships are providing timely access to safety recall repairs, especially when the defect impacts vehicle safety. Thank You INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11731788

Incident

Apr 17, 2026

The contact owns a 2021 Hyundai Elantra. The contact stated that while driving approximately 70 MPH, there was an abnormal sound coming from the vehicle. No warning lights were illuminated. The vehicle was towed to a dealer to be diagnosed; however, the cause of the failure was not determined. The vehicle was not repaired. The vehicle was towed back to the dealer to be diagnosed; however, the cause of the failure was still not yet determined. The vehicle was not repaired. The vehicle was towed back to the dealer, where it was diagnosed with a coolant leak, and the thermostat needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure. The failure mileage was unknown.

NHTSA ID

11731188

Incident

Nov 14, 2021

Subject: Vehicle Safety Complaint – Engine Failure – Hyundai To Whom It May Concern, I am submitting a vehicle safety complaint regarding a serious engine failure involving my Hyundai vehicle. The engine experienced a failure significant enough to require replacement. This raises serious safety concerns, as sudden engine failure can result in loss of power while driving, increasing the risk of an accident. In addition: •Hyundai Motor America has not adequately addressed the issue •My case (#xxxx) remains unresolved despite escalation •I have experienced delays, lack of transparency, and no meaningful resolution Given Hyundai’s known history of engine-related issues, I believe this may represent a broader safety concern affecting other drivers. I respectfully request that NHTSA: 1.Review this incident as a potential safety defect 2.Investigate whether this issue is part of a larger pattern 3.Take appropriate action to ensure consumer safety I am available to provide documentation and further details if needed. Sincerely, [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11730162

Incident

Mar 1, 2025

I am filing a complaint regarding an unresolved and ongoing issue with my 2021 Hyundai Elantra N Line. The vehicle currently has approximately 80,100 miles. This issue began when the vehicle had under 60,000 miles. At that time, I brought the vehicle to a Hyundai dealership because the check engine light was on and I was informed it was related to the EVAP system, specifically the purge valve. I spent approximately five hours at the dealership and was told the issue had been repaired. However, shortly after leaving the dealership, the check engine light returned with the same issue. Since then, I have attempted multiple times to resolve this problem. I even purchased a new purge valve and had it installed by an independent mechanic. Despite replacing the purge valve, the check engine light remains on and continues to report EVAP system issues. I also had a mechanic perform a smoke test on the system, which did not reveal any leaks in the EVAP system. The mechanic stated they could not determine why the system continues to show a purge valve or EVAP-related code and suggested that only Hyundai may have the tools necessary to properly diagnose the issue. I contacted Hyundai corporate customer service for assistance, but they informed me that each dealership is privately owned and they could not intervene or assist further. This issue has now been ongoing for approximately two years. I continue to experience the check engine light and now the vehicle is beginning to have drivability problems including vibration and jerking during acceleration. This unresolved issue also affects my ability to pass vehicle inspections if the check engine light remains on. I am requesting assistance in resolving this ongoing issue and receiving proper diagnosis and repair support from Hyundai so that the vehicle can be repaired correctly.

NHTSA ID

11728698

Incident

Feb 1, 2024

Daytime and night time running lights turn off and on randomly with brights engaging random as well. Turn signals not operating but intermittently and wipers not turning on intermittently. This Started in Nov 2025. First time dealership could get it in was Jan 2026, stated Multifunction switch was bad and covered under warranty, now not covered after getting it in 3.5 months later. Due to the this being a known safety concern for Hyundai Genesis with extended warranty put in place, would love a review on Elantra as well because there are several spots in threads stating the same issue. Thank you for your time and consideration.

NHTSA ID

11726986

Incident

Nov 20, 2025

Some vehicles may exhibit difficulty starting in cold weather. This bulletin provides the procedure to perform an inspection on the starter magnetic switch for potential freezing and, if necessary, replace the starter magnetic switch (solenoid) assembly.

The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts. These dangerous inflators have ruptured during deployment, posing a serious risk of injury or death due to metal fragments entering the vehicle cabin. To date, Hyundai is aware of three people who have died while driving a Hyundai vehicle with one of these substandard replacement airbag inflators that deployed in what likely would have been a survivable crash. NHTSA has issued a public advisory urging vehicle owners and service professionals to have vehicles inspected if there is reason to believe that a non-genuine replacement airbag may have been installed. Vehicles with salvage or rebuilt titles, prior airbag deployments, or unknown repair histories may present a higher risk. NHTSA strongly cautions against self-inspection by vehicle owners and recommends inspection by trained technicians.

The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or non‑certified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious injuries and fatalities. Please see attached announcement, provided by NHTSA, for more details.

Some 2019MY and newer vehicles equipped with a front view camera may illuminate certain warning lights and trigger DTC C272246 fault code for the front camera. In the following cases, the front camera auto-calibration range may be exceeded while driving: • If the front camera is not properly installed and is completely or partially detached. • In case of excessive changes affecting the vehicle's balance (e.g., loading excessively heavy cargo in a specific location of the vehicle, or significant under-inflation of the tires). • Specific road conditions affecting the vehicle's balance (e.g., excessive road crown) This TSB provides instructions on how to service the vehicle when the front camera related warning light(s) are triggered due to system out of calibration (DTC_C272246).

In response to this trend, we engineered a software upgrade that addresses the social media theft method and made it available to owners of eligible models free of charge at authorized Hyundai dealers since early 2023. In addition to the anti-theft software, we’ve developed a new zinc-reinforced ignition cylinder protector hardware upgrade that can be installed at the ignition cylinder location to provide additional protection against the social media theft method. Because your Hyundai vehicle with the VIN listed above (“Subject Vehicle”) was not factory-equipped with an engine immobilizer and was previously eligible for the software upgrade, you are now eligible until March 31, 2027 to have the ignition cylinder protector installed — if you request it — at no cost to you through an authorized Hyundai dealership.

Some Elantra (CN7, CN7A), Kona (OS, SX2), and Sonata Hybrid (DN8 HEV) vehicles equipped with 2.0L engines may illuminate a warning lamp for DTC P218100 (Cooling System Performance) related to the Integrated Thermal-Management Module (ITM). Follow the service procedure in this bulletin to install a spring onto the thermostat within the ITM, in order to prevent premature opening, and perform an ECU software update on affected vehicles.