2011 Kia Sedona

The Office of Defects Investigation (ODI) opened PE18-003 on 3/16/18 to investigate incidents involving crashes, resulting in significant collision related damage, where the frontal airbags failed to deploy. ODI reviewed complaint data, available design, test, and field data on the model year (MY) 2011 Hyundai Sonata, MY 2012-2013 Kia Forte and Forte Koup vehicles. ODI also evaluated data from the automotive air bag system supplier, ZF-TRW (ZF), to review vehicles that may contain the same air bag control unit (ACU) used in the subject vehicles. Hyundai Motor America (HMA) issued recall No. 18V-137 for MY 2011-2013 Sonata and MY 2012 Sonata Hybrid vehicles. Kia Motors America (KMA) issued recall No. 18V-363 for MY 2010-2013 Kia Forte and Forte Koup, MY 2011-2013 Optima, MY 2011-2012 Optima Hybrid, and MY2011-2012 Sedona vehicles. The two recalls address vehicles containing ACUs manufactured without adequate circuit protection by installing a wire harness filter kit to prevent internal damage to the ACU. In the event of a crash, ACU damage may result in the disablement of the vehicle's airbags. Each respective manufacturer has mailed letters to affected vehicle owners informing them of the remedy and its availability. ODI plans to evaluate the susceptibility of the subject ACU to electrical signals, as well as other vehicle factors that can either lead to, or reduce the likelihood of, an electrical overstress event in other vehicles manufactured with the subject ZF ACU.Accordingly, this Preliminary Evaluation has been upgraded to an Engineering Analysis (EA19-001), to expand the scope of the investigation to include the Tier-one supplier and any manufacturers who installed the subject ACU in production vehicles. Additional information is available with the closing resume available at NHTSA.gov (see Associated Documents).The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 10781050, 10849839, 11099038, 11080341.

My fuel rail assembly in my 2011 kia sedona is cracked and leaking causing a gas smell. I'm confused why only some of the kias from 2011 got recalled when it seems like a lot more have this issue.

NHTSA ID

11748681

Incident

Sep 17, 2025

The sliding doors do not latch/close all the way. The light on the dash does not show the doors are not closed. The doors have opened while driving with children in the back seat. The same for the trunk.

NHTSA ID

11743442

Incident

May 20, 2026

In getting the ACU recall fixed, it was found that the Airbag Module is not responding. The ACU cannot be fixed unless the airbag module is fixed. It is my understanding that this is the part before the ACU. This is at a cost of $959 and not covered under the current recall.

NHTSA ID

11743437

Incident

Jun 11, 2026

Recall appointment was set with Ken Ganley Kia auto iNew Port Richey , FL. It was set for two weeks out. They told us what the recall was before we got there. They didn’t order the part to fix it. Now It’s been since March 23rd and we have never heard from them. I feel they’ve had ample opportunity to get the part required to fix it. Since this is a safety issue I am very aggravated . On top of that, my husband wasted an entire day and they gave us a $10,000 estimate on a car worth maybe $1000. It is my opinion they have done nothing required by law to fix this. Since it is regarding a safety concern I wanted to report this issue..

NHTSA ID

11732212

Incident

Mar 23, 2026

The contact owns a 2011 Kia Sedona. The contact stated while driving 60 MPH, the hood latch fractured, and the hood unexpectedly flew open and crashed into the front windshield. The contact stated that the hood was wrapped around the vehicle. There were no reported injuries. The driver was able to pull over safely. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that the vehicle was previously repaired under NHTSA Campaign Number: 16V389000 (Latches/Locks/Linkages). The failure mileage was 116,102.

NHTSA ID

11674060

Incident

Jul 11, 2025

Mileage

116,102 mi

PURCHASE A 2011 KIA VAN FROM AUTO CONNECTION NORFOLK VIRGINIA THE VAN STARED HAVING ISSUES WITH THE ELECTRICAL SLIDING DOOR WOULD NOT SHUT UP PROPERLY SOMETIMES IT WOULD TAKE 10 to 15 TO SHUT UP STEERING WHEEL LOCKING UP WAS TOLD BY A LOCK SMITH THAT THE VAN HAD SOME MAJOR ELECTRICAL ISSUES START LEAKING BRAKE FLUID ADDING A QUART A DAY TOOK IT TO SEVERAL REPAIR SHOP WAS INFORMED THE VAN BRAKE LINES WAS IN BAD SHAPE ALSO THE VAN HAD A BUSTED CV JOINT ON FRONT DRIVERS SIDE THE VAN ALSO HAD A STRONG ODOR OF BLACK MOLD LIKE IT HAD BEEN IN A FLOOD ASK DEALERSHIP TO TRADE ME OUT WAS TOLD THEY COULD NOT DO THAT ASK THEM FOR A LOANER THEY SAY THEY COULD NOT DO THAT EITHER THE VAN IS SITTING IN THERE REPAIR SHOP THEY ARE DEMANDING MONEY TO START WORKING ON THE VAN I BELIEVE THE VAN WAS NOT PROPERLY INSPECTED HAVE REPORTED THIS TO THE BBB THE ATTORNEY GENERAL OFFICE ALSO THE FTC THE DEALERSHIP IS PUTTING VEHICLES ON THE LOT FOR SALE WITHOUT PROPER STATE INSPECTION PLACE NEEDS TO BE INVESTIGATED THEY HAVE A GUY IN THE REPAIR SHOP THAT PUT THE INSPECTION STICKERS ON HIS NAME IS KEVIN PLACE IS RIPPING POOR WORKING CLASS FOLKS OFF WORSE CUSTOMER SERVICE EVER

NHTSA ID

11568497

Incident

Dec 14, 2023

First, the fuel pump was acting up was told the relay was going bad replaced the relay, Than we have "ESC" and ABS light come one for a bout a week took it to get the code read and they said all four wheel sensors (abs) were not transmitting signals ans that my steering angle sensor was bad which I dont think it is equipped with one now today as of 1/6/2024 ESC, ABS and BRAKE all light up and solid at the same time and tI lost my brakes. no we had no inspections we had warning lights the ESC ABS & BRAKE with a warning alarm

NHTSA ID

11563973

Incident

Jan 6, 2024

I had no prior knowledge of this problem. When backing my van out of the garage my front driver side tire blew out. This was caused by the strut spring breaking and poking a hole through the sidewall of the tire. I also discovered that the bottom control arm needed immediate replacement as it has rusted so much that a failure was imminent. I also discovered that the sun-frame mount for mounting the control arm to the sub-frame so badly rusted that it was unsafe to attempt a repair, as it would break away in short order if I were to replace the control arm and drive the van. While deciding what to do with the van I was storing it in my barn. Within a few weeks, I discovered the front passenger tire was flat. It too was impaled when the strut spring broke and poked a hole in the sidewall. I was really lucky that I was driving on a road, as serious crash could have occurred. If this failed while driving, loss of control would have occurred. I consider this a major safety issue and may be present in other Sedonas without the owners' knowledge. I contacted the dealer that I purchased the vehicle from and was told they could do nothing.

NHTSA ID

11536638

Incident

Jul 31, 2023

TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION CYLINDER PROTECTOR AND DECAL INSTALLATION (CS2312) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 20, which may not have been equipped with an immobilizer and whose Integrated Body Control Unit (IBU) / Body Control Module (BCM) did receive the Anti-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.

TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION CYLINDER PROTECTOR AND DECAL INSTALLATION (CS2312) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 20, which may not have been equipped with an immobilizer and whole Integrated Body control Unit (IBU) / Body Control Module (BCM) did receive the Ant-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.

TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: THEFT DETERRENT IGNITION CYLINDER PROTECTOR AND DECAL INSTALLATION (CS2312) - This bulletin provides information to install a Theft Deterrent Ignition Cylinder Protector on certain 2010-2022MY Kia vehicles outlined on page 19, which may not have been equipped with an immobilizer and whose Integrated Body Control Unit (IBU) / Body Control Module (BCM) did receive the Anti-Theft Software Logic upgrade under CS2301/02/03/04/05/06/07/08/09 TSBs. In an effort to help prevent thefts of Kia vehicles, a protective cover will be permanently affixed to the ignition cylinder. This Theft Deterrent Ignition Cylinder Protector prevents the removal of the key lock cylinder thereby preventing access to the ignition tumbler.

CUSTOMER SATISFACTION CAMPAIGN: OWNER NOTIFICATION (CS2312) - This document is the owner notification advising that Kia is conducting Customer Satisfaction Campaign. A software upgrade that addresses the social media theft method has been made available to owners of eligible Kia model vehicles free of charge at authorized Kia dealers since 2023. In addition to the anti-theft software, a new zinc-reinforced ignition cylinder protector hardware upgrade has been developed and can be installed at the ignition cylinder location to provide additional protection against the social media theft method. Because the subject Kia vehicles were not factory-equipped with an engine immobilizer and were previously eligible for the software upgrade, these vehicles are eligible until March 31, 2027, to have the ignition cylinder protector installed—if requested—at no cost through an authorized Kia dealership. (Mailing of these notifications to vehicle owners will be completed from December 17, 2025 through February 27, 2026)

TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, and the transmission oil cooler is transferred to the new transmission.

TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2308) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to upgrade the software logic of the In-Panel Module (IPM) or Body Control Module (BCM) system on certain 2011-2014MY Sedona (VQ) vehicles produced from March 3, 2010 through April 4, 2014 and certain 2015-2021MY Sedona (YP) vehicles produced from July 29, 2014 through July 8, 2020, which may not be equipped with an immobilizer. This logic upgrade will add anti-theft ignition start logic to the vehicle's system operation which activates when the vehicle is locked with the use of the key fob.