2015 Toyota Camry Hybrid

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

The contact owned a 2015 Toyota Camry Hybrid. The contact stated that while driving forward towards the end of a driveway, the brake pedal was depressed, but the vehicle experienced a sudden and unintended acceleration as if the accelerator pedal was depressed down to the floorboard. There was no warning light illuminated. Additionally, the contact noticed that there was smoke coming out of the steering wheel, and the contact blacked out for a couple of seconds. The contact stated that upon regaining consciousness, the contact noticed that the vehicle had turned around with the front end facing the driveway. The contact noticed that all the air bags had deployed, which required the contact to slide underneath the driver's side curtain air bags to exit the vehicle. The contact stated that the front of the vehicle, the hood, and the front driver's side of the vehicle were damaged; however, the damage did not extend to the driver's side door. The contact stated that the cause of the damage was unknown because there was no collision. A bystander advised the contact to call 911. The ambulance arrived, and the contact was sited down in hope that the severity of her headaches would reduce. The contact's friend transported the contact to the residence, and the contact was then transported to the Emergency Room, where the contact underwent a CT scan. The contact sustained severe headaches. bruised left hand with swollen index finger, soreness of the shoulders and a rib, nausea, difficulty breathing, fever, body ache while standing up and sitting down and while turning to the side. A police report was filed. The vehicle was towed and totaled by the insurance company. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 37,000.

NHTSA ID

11706577

Incident

Dec 5, 2025

Mileage

37,000 mi

The contact owns a 2015 Toyota Camry Hybrid. The contact stated while driving 70 MPH and attempting to slow the vehicle, the contact became aware that the brake pedal required increased effort to depress to slow the vehicle. The ABS, stability control, and check engine warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed failures with the brake booster and brake booster pump assembly. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21TE03. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 124,000.

NHTSA ID

11604698

Incident

Jul 26, 2024

Mileage

124,000 mi

THE AIR BAG , HORN , POWER STEERING ALL LOCATED ON THE STEERING WHEEL DO NOT WORK. CAR IS ONE OWNER AND HAS NOT BEEN INVOLVED IN ACCIDENT. I WAS TOLD BY TOYOTA DEALERSHIP CLOCK SPRING WAS BAD. CLOCK SPRING ON PRIOR YEAR WAS ON RECALL. HOWEVER RECALL HAD NOT BEEN TO THIS VEHICLE. I NEED HORN AND AIR BAG.

NHTSA ID

11229473

Incident

May 16, 2017

Mileage

68,000 mi

DRIVING DOWN A FAMILIAR INTERSTATE, I-96, BETWEEN HOWELL AND BRIGHTON, MICHIGAN, THE SUNROOF SUDDENLY EXPLODED.

NHTSA ID

11206319

Incident

Mar 22, 2019

Mileage

65,000 mi

I WAS DRIVING MY 2015 TOYOTA CAMRY LE AFTER DROPPING OFF MY SON AT DAY CARE ON JULY 13, 2018. I EXPERIENCED A SEIZURE WHILE ON THE HIGH WAY TRAVELING AT A SAFE SPEED WITH THE FLOW OF TRAFFIC. I BECAME UNCONSCIOUS, AND WAS AWAKENED BY A NURSE WHO KINDLY GAVE ME MEDICAL CARE TO PREVENT FURTHER INJURY. THE POLICE OFFICER STATED THAT MY VEHICLE BEGAN TO SLOW DOWN AND VEER TO THE LEFT, HITTING GUARD WIRES ON THE SIDE OF THE HIGH WAY. MY DRIVERS SIDE WINDOW WAS SHATTERED, AND THE LEFT AND RIGHT QUARTER PANELS WERE DEMOLISHED. THE ROOF WAS CAVED IN AND BODY WAS DESTROYED. MY AIRBAGS ON THE 2015 TOYOTA CAMRY NEVER DEPLOYED. I WAS TAKEN TO THE LOCAL HOSPITAL BY AN AMBULANCE AND TREATED WITH IMAGING ORDERED BY THE PHYSICIAN, THEN DISCHARGED.

NHTSA ID

11184980

Incident

Jul 13, 2018

Mileage

65,000 mi

TAKATA INFLATORS - ON JULY 13, 2018 THE VEHICLE WAS IN MOTION, ON A HIGH WAY TRAVELING IN THE LEFT HAND SIDE LANE ACCELERATING WITH TRAFFIC WHEN THE DRIVER SUFFERED A SEIZURE. THE VEHICLE'S AIR BAGS DID NOT DEPLOY AFTER COLLIDING WITH ANOTHER VEHICLE, AND HITTING THE GUARD WIRES. THE VEHICLE WAS TOTALED. SEAT BELTS WERE WORN. INJURIES WERE SUSTAINED. DRIVER WAS TAKEN VIA EMS TO THE LOCAL HOSPITAL AND TREATED. VEHICLE WAS TOWED TO LOCAL FACILITY. TITLE WAS TURNED OVER TO TOWING COMPANY. SAFETY RISK- DRIVERS SIDE FRONT AIRBAGS NOT DEPLOYED DURING CRASH. *DT*JB

NHTSA ID

11184432

Incident

Jul 13, 2018

Mileage

1 mi

MAINTENANCE LIGHT CAME ON AND GAVE IT FOR SERVICE AT TOYOTA DEALERSHIP IN FREMONT ON 11/12/2017. THEY PERFORMED A 60,000 MILES MAJOR SERVICE. THREE DAYS LATER, MAJOR BREAK FAILURE ON 11/15/17. TOYOTA DEALERSHIP AND TOYOTA MANUFACTURER REFUSED TO TAKE RESPONSIBILITY. THIS IS CAUSED BY REPLACING THE BREAK FLUID AND THIS IS NOT NECESSARY AT 60,000 MILES SERVICE. THE CAR IS AT THE TOYOTA DEALERSHIP AND THEY ARE ASKING FOR $4,000 TO FIX IT. I READ THE CONSUMER REPORT AND THIS IS A KNOWN PROBLEM. TOYOTA SHOULD TAKE FULL RESPONSIBILITY TO FIX THIS PROBLEM.

NHTSA ID

11052524

Incident

Nov 15, 2017

Mileage

63,000 mi

THE SUNROOF GLASS SPONTANEOUSLY EXPLODED WITHOUT BEING HIT BY ANY OBJECT.

NHTSA ID

10983580

Incident

May 3, 2017

Mileage

23,770 mi

OBSOLETE NOTICE February 13, 2026: This bulletin is now obsolete. Please see T-SB-0009-26.

This bulletin includes basic procedures for performing a rescue charge on Ni-MH high voltage (HV) batteries. This bulletin should be used in conjunction with the applicable model and model year Repair Manual while performing a rescue charge. The GRX-5100 should be used wherever the Repair Manual references the Toyota Hybrid System (THS) charger.

Some 2005 – 2026 Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Service Bulletin is to provide general guidelines and procedures for odor remediation. This Service Bulletin provides a guide on how to prepare and treat the interior of the vehicle for odor remediation. Refer to the applicable model and model year Repair Manual and the EPA (Environmental Protection Agency) website for the most up-to-date safety and precautionary guidelines.

The air conditioning dye injection tool kit has been developed to aid in identifying the location of air conditioning refrigerant leaks. The procedures outlined in this Service Bulletin aid in locating, inspecting, and repairing refrigerant leaks.

Acid rain results from rainwater or other airborne moisture that become acidic due to industrial chemical impurities in the atmosphere. If these acidic compounds settle on an exposed vehicle, especially the horizontal areas such as the hood, roof, and decklid, significant damage to the painted surfaces can occur. Acid rain damage can typically be identified on vehicles by the presence of stains on the paint surface that resemble hard water spots. Unlike water spots however, acid rain damage cannot be removed by regular washing procedures. Also, because acid rain can etch and soften the paint, normal buffing or polishing repair procedures should not be attempted. This can cause further damage and result in visible depressions in the paint surface. The following are the three major categories of acid rain damage: •Minor damage: requires only buffing to repair. •Moderate damage: usually requires neutralizing, color sanding, and buffing. •Severe damage: extending beyond 1/2 mil of clearcoat on a pearl, metallic, or solid color, requires neutralization, sanding, and repainting. In cases where acid rain damage is minor, neutralization and buffing with a liquid-type paint finessing product may provide an adequate repair. Only specially formulated products outlined in this bulletin should be used for that purpose. Unfortunately, other than minor damage, there is no simple method of determining the actual extent (depth) of acid penetration other than color sanding a representative affected area until there is no visible etching or depressions, followed by measuring the amount of paint removed with either a magnetic or digital-type film thickness gauge. The procedures in this bulletin are intended for use by qualified body/paint technicians and should not be attempted by inexperienced personnel. It is the dealer’s responsibility to protect and maintain the quality of the vehicle’s paint finish after receipt at the dealership prior to the first sale. Perform frequent vehicle washing, as often as daily, during high heat and humidity periods to minimize the potential for paint damage due to acid rain exposure. This is especially important in geographical areas known for high frequency and concentration of acid rain and industrial fallout.

To prevent brake rotor rust from forming during transportation and storage, wheel film will be used instead of a cardboard type of anti-rust cover. The purpose of the wheel film is to shield the disc brake rotor from weather elements and initial rust before the vehicle is delivered to the customer. Consequently, the film should remain on the wheel for as long as possible.