2009 GMC Yukon

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Transmission problems

NHTSA ID

11714087

Incident

Aug 16, 2025

The dashboard cracked

NHTSA ID

11681191

Incident

Aug 17, 2025

MANUFACTURER SAFETY RECALL ISSUED -NHTSA #21V050 - TRANSPORT CANADA #20591 - RECALL # N212328760 FRONT PASSENGER AIRBAG TAKATA INFLATOR-PRIORITY GROUP 6

NHTSA ID

11639154

Incident

Feb 5, 2021

My 2009 GMC Yukon Denali has a major safety issue. The hard plastic dash has multiple cracks, which is a huge safety concern in the case of an accident. The dash could explode inside the vehicle causing injury to me and/or other passengers. The dashboard could also interfere with the operation of the airbag due to multiple cracks being around the passenger air bag. I have reached out to GM customer service twice and both time they advised me that a manager will reach out to me but they never did. I’m hoping this report will make GM accountable for the vehicle defect they made and pay to fix/repair the dash.

NHTSA ID

11486882

Incident

Sep 28, 2022

Cracks in dashboard including crack up to passenger airbag. Truck has been garage kept since new,

NHTSA ID

11480539

Incident

Jul 18, 2022

I was driving around 55 miles per hour and applied the brakes. I had little to no brakes and had to use the emergency brake to stop the vehicle. Luckily there was no car in front of me or a collision would have occurred. I had multiple ABS light, service stabiltrak, service brake lights engage. It happened once more going to the next light. I pulled over and removed the negative battery cable and waited 2 minutes and re attached it. The brakes feel spongy. I have researched the forums for the electric hybrid models and there were multiple other vehicles with the same symptoms as mine. Dealership says there are no recalls for the vehicle, even though multiple other hybrids are having the same issues and wanted to charge me $135 diagnostic fee to check the brake system. This is a safety hazard and should be investigated by GMC

NHTSA ID

11476468

Incident

Jul 29, 2022

Since I've owned the hybrid yukon, I've had nothing but issues. GMC only made a limited amount of the hybrid models but due to the issues discontinued manufacturing them. why weren't the vehicles taken off the market? started with the jolting from a stop, to not wanting to go into reverse, check engine light, to hybrid battery not shifting into gear, last power steering locked while driving then not starting at all. had sat at the dealership for 4 weeks now sitting at another hybrid shop awaiting for the inverter converter control to be delivered and put in. have spent thousands in the last 2 months repairing trying to figure out issues.

NHTSA ID

11475340

Incident

Jul 1, 2022

Takata recall. The contact owns a 2009 GMC Yukon. The contact received notification of NHTSA Campaign Number: 21V052000 (Air Bags). The dealer had been notified on multiple occasions about the recall; however, the contact was informed by the dealer that the parts were not yet available. The manufacturer had been notified of the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11435990

Incident

Feb 1, 2021

New Vehicle Monitoring Programs Section in IVH

This Preliminary Information communication provides information to the technician about vehicles that have an intermittent no crank, no start, or start stall concern with the security light coming on. Technician may find Diagnostic Trouble Codes B3055, B3060, B3935, C0750, C0755, C0760, C0765, and/or C0775.

This PI communicates the requirement to provide a pico file to receive diagnostic assistance from TAC.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.

This Preliminary Information communication provides information to the technician about the use of J-35616-64B and Mini 50 terminal test probe, replacement terminals, and terminated leads.