2009 Nissan Quest

On May 8, 2014, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE14-012 to investigate allegations of inaccurate fuel tank fill level while driving resulting in the vehicle running out of fuel in model year (MY) 2007 Nissan Quest vehicles.During this investigation, Nissan identified a condition in the subject vehicles that may result in the fuel gauge falsely indicating more than the actual amount of fuel remaining in the gas tank. According to Nissan, the combination meter voltage divider circuit for the sender unit may have one of two resistors open or lifted resulting in a fuel gauge malfunction and inaccurate fuel level reading.When this condition occurs, the fuel gauge in the combination meter will continue to track the actual amount of fuel in the gas tank down to approximately one quarter of a tank.However, the fuel gauge will not go any lower which may cause drivers to run out of fuel unexpectedly.Additionally, ODI analyzed complaint data provided by Nissan as well as complaints submitted to ODI from consumers. In total, ODI identified 136 unique complaints indicating an inaccurate fuel level reading while driving in the subject vehicles. Seventy (70) fuel gauge related stalls were identified, resulting in a complaint rate of 1.85 incidents per thousand vehicles after approximately 8 years in service. In addition, analysis of warranty and combination meter part sales data provided by Nissan indicate a claim rate of less than 1% for all part replacements involving fuel gauge malfunctions.During PE14-012, Nissan developed a remedy procedure and issued Service Campaign PC 335 on approximately 68,003 MY 2007 through 2009 Nissan Quest vehicles.Owners of the affected vehicles will receive preliminary notification by mail recommending owners to keep fuel level above ? tank at all times until repair parts become available.Once the remedy kits become available, Nissan plans to send another letter to affected customers to take their vehicle to a Nissan dealer who will install an external amplifier box with jumper harness in the combination meter to bypass the electric circuit and ensure accurate fuel level indication.The bulletin was sent to dealers on December 19th, 2014 and the owner letter mailing began on December 31st, 2014. See the investigative file for copies of Nissan's dealer communication and owner letter. Based on the relatively low rate of engine stall incidents for vehicles that have been in service for 8-9 years, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect and take further action in the future if warranted.The following VOQ numbers are associated with the issues discussed in this closing resume:10503555, 10505390, 10513356, 10525325, 10549839, 10551187, 10552937, 10559300, 10565794, 10567557, 10568302, 10574869, 10575303, 10588121, 10588843, 10594370, 10595029, 10597201, 10598275, 10608182, 10610671, 10615104, 10615697, 10617309, 10618457, 10621549, 10622551, 10627963, 10632742, 10633833, 10637512, 10638279, 10640959, 10641050, 10643726, 10643791, 10643933, 10644085, 10649107, 10649598, 10652109, 10660231, 10661351, 10662656, 10662666.

The contact owned a 2009 Nissan Quest. The contact stated while driving 40 MPH, she did not notice that the traffic light had turned red and continued driving. Another oncoming vehicle made a left turn in front of her. The contact stated that she swerved and the front end of the vehicle hit a pole. The contact saw smoke coming from underneath the hood. The air bags failed to deploy. The contact hit her chest against the steering wheel. Bystanders assisted the contact out of the vehicle. The contact was transported to the local hospital. The contact was then transported to the Trauma unit of another hospital. The contact sustained a broken sternum and broken left and right ribs. The contact stated that she spent 10 days in the trauma unit, and she also received home health assistance. The vehicle was towed to a tow lot, where it was totaled. A police report was filed. The contact later received notification of NHTSA Campaign Number: 23V067000 (Air Bags) that she related to the failure. The dealer and the manufacturer were not notified of the failure. The failure mileage was unknown.

NHTSA ID

11561191

Incident

Aug 25, 2023

The contact owns a 2009 Nissan Quest. The contact stated that the passenger's side rear sliding door inadvertently opened while the vehicle was locked. Additionally, there was water build-up in the passenger's side rear sliding door track and an unknown burn mark on the floorboard. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was 116,521.

NHTSA ID

11482086

Incident

Aug 30, 2022

Mileage

116,521 mi

Power window motor repeatedly goes out on the driver's side. The passenger door that opens automatically by the button has a motor that does not stay working.

NHTSA ID

11436236

Incident

Aug 31, 2021

STEERING LOCKS UP AT LOW/HIGH SPEEDS. RACK AND PINION COMES APART INTERNALLY. CAN CAUSE ACCIDENT/DEATH. FIRST STEERING WILL BE SLOW IN COLD WEATHER MAKING NOISE SECOND METAL SHOWS UP IN POWER STEERING RESIVORE THIRD A DRAGGING POPPING NOISE FROM STEERING FORTH FAILURE STEERING SYSTEM. COULD BREAK LEAVING TIRES TO SEPARATE IN THE V PATTERN OR LOCK UP CAUSING LOSS OF STEERING. THIS VEHICLE LOCKED UP UNEXPECTEDLY ON A SIDE STREET AT LOW SPEEDS. WHILE TURNING RIGHT. ABLE TO FREE UP TO AVOID GOING THROUGH A GARD RAIL (WITH A 60FT DROP OFF) ONLY TO HAVE LOCK UP AGAIN WHILE CORRECTING THE SUDDEN JAR AND GETTING OUT OF ONCOMING TRAFFIC. TO END UP IN A BUSINESS PARKING LOT.

NHTSA ID

11173844

Incident

Feb 3, 2019

AFTER COMPLETELY FUELING THE TANK, THE CAR RUNS FOR ABOUT 2 TO 3 MILES AND THEN BECOMES TO SAY THAT THAT FUELING TANK IS EMPTY. ITS BEEN OCCURRING FOR THE PAST 4 YEARS. WE'VE TRIED CHANGING THE FUEL PUMP AND THE FUEL CAP, BUT IT STILL CONTINUES TO SHOW THAT THE FUEL TANK IS EMPTY. WHILE DRIVING ON THE CITY STREETS, THE CAR WILL START GOING SLOW AND STOP BY ITS SELF AFTER SHOWING THAT THERE IS NOW GASOLINE. AFTERWARDS, IT WILL COMPLETELY SHUT DOWN AND AFTER A FEW MINUTES, IT STARTS TO RUN NORMALLY. THIS HAPPENS ABOUT EVERY 2 TO 3 DAYS.

NHTSA ID

11100089

Incident

May 27, 2018

Mileage

120,000 mi

WHEN I PUT MY CAR INTO REVERSE, THE CAR 'REVED UP' AND BEGAN MOVING FORWARD. WITH ALL OF MY MIGHT, I PUSHED DOWN ON THE BRAKES. THE CAR WAS STILL MOVING FORWARD, SO I THEN PUT THE CAR INTO 'PARK'. AT THAT POINT, IT MADE A HIDEOUS GRINDING NOISE, SO I IMMEDIATELY TURNED THE CAR OFF. ABOUT 30 SECONDS LATER, I STARTED THE CAR AND IT SOUNDED FINE. I THEN DROVE THE CAR HOME, (ABOUT 5 MILES), WITHOUT INCIDENT.

NHTSA ID

10979756

Incident

Apr 20, 2017

Mileage

111,600 mi

WHEN OUR VEHICLE WAS HIT ON THE DRIVERS SIDE THE DRIVERS SEAT RECLINED BACK CAUSING SERIOUS INJURIES. CURRENTLY THERE ARE ONLY RECALLS ON THE 2008 NISSAN QUEST PAWL SYSTEM. I DO NOT HAVE IMAGES BECAUSE EMS PUSHED THE SEATS FORWARD. THE VEHICLE WAS IN MOTION WHEN ANOTHER VEHICLE RAN A STOP SIGN AND HIT US AT A SPEED OVER 70 MPH.

NHTSA ID

10849657

Incident

Mar 3, 2016

Mileage

119,000 mi

ALL FOUR MOTOR MOUNTS HAVE GONE OUT WITHIN THE YEAR. DURING ONE INSTANCE 3 MOUNTS WENT OUT AT ONCE. I WAS DRIVING DOWN THE HIGHWAY WHEN I HEARD CLANKING NOISE. I IMMEDIATELY TOOK THE CAR INTO THE SHOP. WHILE THERE I WAS TOLD THIS IS A COMMON PROBLEM WITH THIS MODEL.

NHTSA ID

10809175

Incident

Dec 1, 2015

Mileage

86,000 mi

CERTIFICATION LABEL AND VIN PLATE REPLACEMENT SERVICE INFORMATION Because of collision damage or other vehicle repair, a replacement “Certification Label” or “VIN Plate/Label” may be needed. HINT: Certification Label = FMVSS (Federal Motor Vehicle Safety Standards) label. These items may be available from Nissan by request if certain criteria are met. This bulletin lists the criteria and provides an application form for such replacements. · The “VIN Plate/Label” (metal plate or vinyl label) is attached to the instrument panel or body on the driver side at the base of the windshield (see Figure 1). · The “Certification Label” (vinyl adhesive label) is located on the lower area of the driver side B-Pillar (see Figure 1).

CERTIFICATION LABEL AND VIN PLATE REPLACEMENT SERVICE INFORMATION Because of collision damage or other vehicle repair, a replacement “Certification Label” or “VIN Plate/Label” may be needed. HINT: Certification Label = FMVSS (Federal Motor Vehicle Safety Standards) label. These items may be available from Nissan by request if certain criteria are met. This bulletin lists the criteria and provides an application form for such replacements. · The “VIN Plate/Label” (metal plate or vinyl label) is attached to the instrument panel or body on the driver side at the base of the windshield (see Figure 1). · The “Certification Label” (vinyl adhesive label) is located on the lower area of the driver side B-Pillar (see Figure 1).

VOLUNTARY SAFETY RECALL CAMPAIGN 2004-2012 ARMADA, TITAN, AND 2004-2009 QUEST; DRIVER AIR BAG COVER CAMPAIGN ID #: PC944, PC946, PC947, PC949 APPLIED VEHICLES: 2004-2012 Armada (TA60) 2004-2009 Quest (V42) 2004-2012 Titan (A60) Check Service COMM or Dealer Business Systems (DBS) National Service History to confirm campaign eligibility. INTRODUCTION Nissan is conducting this voluntary safety recall campaign on certain specific model year 2004-2012 Armada, 2004-2012 Titan, and 2004-2009 Quest vehicles, to inspect and if necessary, replace the driver Air Bag Cover. This service will be performed at no charge to the customer for parts or labor. IDENTIFICATION NUMBER Nissan has assigned identification numbers PC944, PC946, PC947 and PC949 to this campaign. The vehicle specific number must appear on all communication and documentation of any nature dealing with this campaign. DEALER RESPONSIBILITY It is the dealer’s responsibility to check Service COMM or Dealer Business Systems (DBS) National Service History for the campaign status on each vehicle falling within the range of this voluntary safety recall which for any reason enters the service department. This includes vehicles purchased from private parties or presented by transient (tourist) owners and vehicles in a dealer’s inventory. Federal law requires that new vehicles in dealer inventory which are the subject of a safety recall must be corrected prior to sale. Failure to do so can result in civil penalties by the National Highway Traffic Safety Administration. While federal law applies only to new vehicles, Nissan strongly encourages dealers to correct any used vehicles in their inventory before they are retailed. This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

CAN COMMUNICATION CODES – DIAGNOSTIC TIPS AND GUIDELINES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

CAN COMMUNICATION – NETWORK DIAGNOSTIC FLOW CHART This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.