1993 Nissan Quest

PERIODIC EXPOSURE TO LIQUID GASOLINE MAY RESULT IN EXTRACTION OF ANTIDEGRADANTS FROM THE SUBJECT FUEL TANK VENT HOSE.HOSES WHICH HAVE SUFFERED LOSS OF ANTIDEGRADANT CAN DEVELOP CRACKS IN AREAS OF HIGH STRAIN.FUEL MAY SPRAY OR DRIP FROM CRACKED VENT HOSES FOLLOWING TANK FILL.STARTING AT JOB#1 1998 MY (CALIFORNIA EMISSIONS VEHICLES) AND JOB#1 1999 MY (FEDERAL EMISSIONS VEHICLES), THE SUBJECT VENT HOSE COMPOSITION CHANGED FROM NITRILE RUBBER HOSES WITH CHLOROPRENE RUBBER COVERS (NBR/CR) TO FLUORACBON RUBBER HOSES WHICH AN OUTER LAYER BLEND OF NBR/PVC.THE CHANGES WER MADE TO IMPROVE HYDRACARBON RESISTANCE FOR COMPLAINCE WITH NEW EVAPORATIVE EMISSIONS REGULATIONS.THE MODIFIED HOSES ARE ALSO SIGNIFICANTLY MORE RESISTANT OT DEGRADATION AND CRACIKING. IN A LETTER DATED DECEMBER 14, 2000, NISSAN NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL CAMPAIGN TO REPLACE THE SUBJECT VENT HOSE IN AFFECTD VEHICLES WITH THE REDESIGNED HOSE.NISSAN WILL BEGIN NOTIFYING OWNERS OF THE AFFECTED VEHICLES ON FEBRUARY 5, 2001.NISSAN WILL FINISH ITS OWNER MAILINGS ON SEPTEMBER 10, 2001.OWNERS WILL BE NOTIFIED IN REVERSE ORDER OF VEHICLE AGE.

There is no summary currently available

STEEL BRAKE LINES TO REAR BREAKS RUSTED THROUGH IN SEVERAL PLACES - TWO LINES TO REAR THAT PASS UNDER THE FLOOR AND ALONG THE DRIVER SIDE RAIL AND OVER THE REAR LEFT WHEEL AXLE, AND ALSO AT THE AREA IMMEDIATELY BEFORE EACH REAR WHEEL CYLINDER. *TR

NHTSA ID

10318214

Incident

Dec 15, 2009

Mileage

162,000 mi

TL*THE CONTACT OWNS A 1993 NISSAN QUEST. THE CONTACT STATED THAT THE PASSENGER FRONT LAP BELT WILL NOT REMAIN SECURE INTO THE BUCKLE. AS A CONSEQUENCE, IN THE EVENT OF THE CRASH THE OCCUPANTS MAY NOT BE PROPERLY RESTRAINED, WHICH CAN CAUSE SERIOUS INJURY. HE TOOK THE VEHICLE TO THE DEALER AND A TECHNICIAN STATED THAT NO PARTS ARE AVAILABLE TO PROPERLY REMEDY THE FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 170,000. UPDATED 10/06/09. *LJ THE CONSUMER STATED THE VEHICLE HAS FINALLY BEEN REPAIRED. THE DEALER ORDERED AND REPLACED THE BELT BUCKLE FREE OF CHARGE UNDER WARRANTY. UPDATED 10/06/09

NHTSA ID

10282911

Incident

Aug 24, 2009

Mileage

175,000 mi

TL*THE CONTACT OWNS A 1993 NISSAN QUEST. THE CONTACT STATED THAT THE VEHICLE BURNED A LOT OF FUEL. THE MECHANIC INSPECTED THE VEHICLE AND STATED THAT THERE ARE NO LEAKS. IN ADDITION, THE CONTACT HEARD A SCRAPING NOISE WHEN MAKE A LEFT OR RIGHT TURN. THE MECHANIC WAS UNABLE TO DIAGNOSE THE FAILURE. THE CURRENT MILEAGE WAS 200,050 AND FAILURE MILEAGE WAS 200,00. UPDATED 04/08/08. *LJ THE SEAT BELTS DID WOULD NOT GO UP OR DOWN AND THERE WAS A PROBLEM WITH THE UPPER AND LOWER BALL JOINTS. THE CONSUMER ALSO STATED THE VEHICLE CUTS OFF. UPDATED

NHTSA ID

10222179

Incident

Mar 1, 2007

Mileage

200,000 mi

TL*THE CONTACT OWNS A 1993 NISSAN QUEST. AFTER PARKING THE VEHICLE, THE CONTACT NOTICED SMOKE COMING FROM THE VENT ON THE OUTSIDE OF THE VEHICLE. AFTER A COUPLE OF MINUTES, THE SMOKE CLEARED. SHE TURNED THE KEY IN THE IGNITION AND FLAMES APPEARED UNDER THE GLOVE COMPARTMENT. THE FIRE AND POLICE DEPARTMENTS ARRIVED AT THE SCENE AND A FIRE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE DEALER STATED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER 00V419001 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY); HOWEVER, THE CONTACT NEVER RECEIVED A RECALL NOTICE. THE CURRENT AND FAILURE MILEAGES WERE 200,000.

NHTSA ID

10208452

Incident

Nov 5, 2007

Mileage

200,000 mi

TL*THE CONTACT OWNS A 1993 NISSAN QUEST. THE CONTACT STATED THAT HER VEHICLE WAS SQUEAKING AND THAT SHE HAD TO HOSE OFF HER FRONT ROTORS WHEN THEY OVERHEATED. HER VEHICLE WAS ALSO EXPERIENCING LONG STOPPING DISTANCES. THE FAILURES HAVE OCCURRED ON NUMEROUS OCCASIONS. RECENTLY, THE SERVICE BRAKE LIGHT ILLUMINATED FOR A COUPLE OF DAYS AND THEN DIMMED. SAFETY RECALL # 92V32001 (SERVICE BRAKES, HYDRAULIC: FOUNDATION COMPONENTS: MASTER CYLINDER) WAS FOUND. THE FREE PORTION OF THE SAFETY RECALL NO LONGER APPLIES TO THIS VEHICLE. THE POWERTRAIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 200,000.

NHTSA ID

10194847

Incident

Jun 27, 2007

Mileage

200,000 mi

EXHAUST MANIFOLD BOLTS BROKEN NISSAN REPLACED BOLTS 1800.00 20,000 MILES LATER SAME PROBLEM NISSAN SAYS NOT RESPONSIBLE BECAUSE IT HAD BEEN LONGER THAN 20,000 MILES AS FAR AS I CAN TELL NISSAN DID NOT USE THE NEW IMPROVED MANIFOLD BOLTS FOR THIS REPAIR.*AK

NHTSA ID

10075189

Incident

Jan 15, 2001

Mileage

18,000 mi

AS HAS HAPPENED TO CLOSE TO 100% OF QUEST/MERCURY VILLAGER OWNERS, I HAVE CRACKED MANIFOLDS, MISSING MANIFOLD STUDS, AND SEVERAL BROKEN MANIFOLD STUDS. THIS RESULTS IN POOR STARTS, EXHAUST LEAKS, AND A NOTICEABLE "CLACKING" (EXHAUST LEAK) UPON ACCELERATION. MY VEHICLE HAS 118K MILES. I UNDERSTAND THE LABOR FOR A COMPLETE FIX CAN RUN OVER $1000, WHILE PARTS RUN UNDER $100. I HAVE CONTACTED 1-800-NISSAN1 WITH THIS ISSUE AND THE OPERATOR WAS AWARE OF THIS VERY COMMON, SERIOUS PROBLEM AND AFFIRMED THAT I WOULD BE CONTACTED WITH ANY POSSIBLE COMPENSATION.

NHTSA ID

10070669

Incident

Aug 15, 2003

Mileage

118,000 mi

FRONT DRIVERS AUTOMATIC SEAT BELT IS STUCK IN ONE STATIONARY POSITION. CONSUMER CAN HEAR MOTOR RUNNING BUT NO MOVEMENT OF SEATBELT. *AK

NHTSA ID

10022959

Mileage

70,000 mi

DIAGNOSIS OF VEHICLE PULL (DRIFT) AND/OR STEERING WHEEL OFF-CENTER This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

SILICONE-BASED LUBRICANT OR GREASE CAN DAMAGE ELECTRICAL COMPONENTS SERVICE INFORMATION Do not apply Silicone-based lubricants or grease to, or around, any interior electrical components. To avoid the risk of death or severe personal injury, do not directly spray Silicone-based lubricant or grease, or inadvertently overspray Silicone-based lubricant or grease onto any interior electrical components. These types of lubricants can be detrimental to the proper operation of electrical components.

12 VOLT BATTERY TESTING FOR IN-SERVICE VEHICLES SERVICE INFORMATION The following Service Information lists NNA procedural recommendations for establishing good connections while performing 12V battery testing. These recommendations are expected to promote uniformity during the connection process, therefore reducing the number of incorrect “Test with DCA” and “Replace” results. HINT: If 12 volt batteries are allowed to discharge for a prolonged period of time, battery life may be drastically reduced. This condition may lead to premature battery replacement and customer dissatisfaction. IMPORTANT:  CPX-900 is now an accepted testing tool to use along with or in place of the DSS-5000  CPX-900 operating instructions are found at: https://nissancpx900.midtronics.com/  DSS-5000 operating instructions are found at: https://nissandss5000.midtronics.com/  DCA-8000 is now a required testing tool to be used for all warranty replacement decisions. The DCA-8000 is also a more efficient charger than previously available, and will charge any available 12 volt lead acid battery safely and accurately as long as all precautions and inputs are made correctly. The DCA-8000 operating instructions are found at: https://nissandca8000.midtronics.com/

VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

INTELLIGENT KEY REPLACEMENT OR SWAPPING BETWEEN VEHICLES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Discard all previous versions of this bulletin.

WINDSHIELD CRACKING This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.