2020 Volvo XC90

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

My 2020 Volvo XC90 T8 plug-in hybrid has been out of service for 78+ days due to a hybrid battery defect covered under an active manufacturer warranty (Claim Type XXX, valid through XXX). The vehicle was towed to Volvo Cars Arrowhead (Glendale, AZ) on XXX after a hybrid battery failure. The dealer confirmed in writing on XXX that multiple hybrid components require replacement and that parts are on extended backorder, and that Volvo Cars USA had authorized a rental vehicle because a loaner could not be offered "for an indefinite period of time." On approximately XXX, my service advisor advised me by phone that more than 700 vehicles nationally are waiting on the same backordered part and that the repair has no estimated completion date. I sent a formal written demand to Volvo Car USA ([XXX]) on XXX requesting repair by a firm date, a replacement vehicle, or repurchase. Volvo did not respond within the stated 14-day deadline or at any point thereafter. The defect appears related to NHTSA's existing recall action on 2020–2022 Volvo plug-in hybrid vehicles for high-voltage battery thermal runaway risk. I am filing this complaint to add to the federal record on this recall and to document Volvo's failure to repair an affected vehicle within a reasonable time or provide any remedy despite formal demand. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11752094

Incident

May 4, 2026

This is my daughters vehicle. She was driving home from work with my [XXX] and [XXX] grandchildren in the car. The car suddenly wouldn't drive at a safe speed and was chugging along. She almost got into an accident because she couldn't go faster than about 12 mph. She as finally able to pull over in a safe location and called AAA. My son in law met her and picked her and the children up. The vehicle was towed to VOLVO in Buffalo NY. The diagnosis was a known leak in the sunroof that causes the drains to become blocked. Water then runs down and burned out the ECR module that is located beneath the drivers side foot well. Volvo is aware of the problem and is currently checking all vehicles for the blocked drains. They were given a 5000.00 estimate for repairs. Today VOLVO refused to repair it at their expense. There should be a full recall on this issue. I am a Fire/Explosion Investigator who has investigated numerous car fires related to Control modules catching fire. This could have caused a fire and trapped my grandchildren in the rear seat. The dealership reported 2 other vehicles in for the same issue. Please review and respond to me- [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11743304

Incident

May 26, 2026

The rear a/c evaporator coil has failed, leaking UV dyed green oil into the main battery pan. The a/c vents in the car in the driver and middle rows are now blowing hot air. This is a very commonly known problem with Volvo SPA XC90s from 2016-2021. It’s incredibly expensive to repair($3500 +). There should be a recall to replace/repair this problem in these relatively new and expensive cars.

NHTSA ID

11737179

Incident

May 9, 2026

I was driving when a turtle popped up on my dashboard I pulled over to Google what that meant and popped the hood cause I seen a little smoke within 3 sec the car busted in flames I ran back and grab my daughter out the back seat we were almost locked in due to the car melting the wire and flames started coming inside the car

NHTSA ID

11735004

Incident

Apr 3, 2026

SUPPLEMENTAL TO NHTSA COMPLAINT #11713668. This is a supplemental filing regarding the 2020 Volvo XC90 T8 Inscription, VIN [XXX] . The hybrid battery cell module failed in December 2025, disabling the vehicle's hybrid propulsion system, all-wheel drive, and electric-only mode. As of this filing, the vehicle has been without hybrid functionality for over four months. The replacement part remains unavailable. Since the original complaint, the owner initiated civil proceedings against Volvo Car USA LLC and Volvo Car North America LLC in the State Court of Gwinnett County, Georgia (Case No. [XXX]). Through that litigation, the following facts have been established as deemed admissions under Georgia law, which neither Defendant contested: 1.This vehicle is excluded from Recall 25V-179, yet experienced a catastrophic hybrid battery cell module failure. 2.Battery failures in 2019-2022 XC90 T8 vehicles are not exclusively caused by the "LG supplier process deviation" identified in Recall 25V-179. 3.Volvo is aware of battery failures in 2019-2022 XC90 T8 vehicles outside the Recall 25V-179 population. 4.Volvo possesses internal engineering data showing the battery defect affects vehicles outside the population reported to NHTSA in Recall 25V-179. 5.Volvo has not issued a recall for the specific failure mode affecting this vehicle. 6.Expanding Recall 25V-179 to cover the full 2019-2022 XC90 T8 population would cost Volvo tens of millions of dollars. These facts were established against both Volvo entities through separate sets of Requests for Admission that went unanswered within the statutory deadline. The owner requests that NHTSA evaluate whether Recall 25V-179 is adequate to protect the full population of affected vehicles. Supporting documentation, including copies of the deemed admissions and service records, is being submitted by mail to the Office of Defect Investigation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11733717

Incident

Dec 17, 2025

The contact owns a 2020 Volvo XC90. The contact stated that while driving 35-40 MPH, the message "Vehicle Not in Park" was displayed intermittently, and the vehicle stalled. The contact was able to pull over to the side of the road. The vehicle was restarted after several attempts and was driven to the residence. The vehicle was then taken to the dealer, where the contact was informed that no failure was found. The vehicle was not diagnosed or repaired. While investigating the failure online, the contact became aware that it was a common failure, and that the dealers were unable to duplicate the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 79,000.

NHTSA ID

11727942

Incident

Mar 25, 2026

Mileage

79,000 mi

My tire somehow got a nail in it. I drove straight to Volvo when noticing the issue around 730am on 3/13/26. At 745am I spoke with [XXX] at Schumacher Volvo, he advised that they were too busy today to assist me. I advised I was afraid to drive with this and needed help and he told me to buy a tire lock kit and I could do it at another tire store. When I went to the parts department they advised the brake lock would not work and the only way to fix my tire would be to have Volvo remove the special lock nuts or replace them with common ones. Of course x they had no time to do this so they left me with zero options or ability to fix my car. I was forced to drive 30+ minutes home with zero solution. Completely unsafe and unfair I have absolutely no way to resolve this issue with my car. Unacceptable and scary considering Volvo claims they are all about safety but no concerns letting a single mother and her 2 children drive in a tire with a nail. XXX, INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11724311

Incident

Mar 13, 2026

Vehicle: 2020 Volvo XC90 Mileage at first incident: ~60,000 miles Mileage at second incident: ~70,000 miles In July 2025, while my wife was driving our 2020 Volvo XC90 the vehicle experienced a sudden and complete loss of braking. The brake pedal did not provide stopping power, and the vehicle had to be steered off the roadway in order to come to a stop and avoid a serious accident. The incident created a serious safety risk. The vehicle was taken to an Wynn Volvo PA dealer and the brake booster and master cylinder were replaced at our expense (approximately $2,500). After the repair, the brake pedal initially felt abnormally soft and required a return visit for correct repair. Approximately six months later, in January 2026, while my teenage son was driving the same vehicle, the vehicle again experienced a complete loss of braking. Braking performance was lost without warning. He narrowly avoided a serious accident. The vehicle was brought to Wynn Volvo in PA and the hydraulic control unit (brake control module) was diagnosed as failed. Repair cost is approximately $3,000. This vehicle has now experienced two separate complete brake failures involving different hydraulic braking components within six months -- with both my wife and son narrowly avoiding serious accidents. Given that this is a safety-critical braking system failure with repeat occurrence, I am filing this complaint for investigation.

NHTSA ID

11717769

Incident

Jan 19, 2026

This is a Technical Journal: Text plus 1 .jpg attachment - If remote control key is not detected by the car and shows message in DIM "Car key not found" or if functions such as lock/unlock are not working, please follow advice for detecting key

This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp

This is a Technical Journal: Intermittent knocking noise during acceleration. If the sound corresponds to attached sound file, change front drive shafts to the below part numbers.

This is a Technical Journal: Panoramic sunroof, sealing strip has a gap

This is a Technical Journal: Text plus 2 PDFs and 1 .PNG Oil Consumption test. Perform the test. Follow service procedure
 Description and Service sections updated to clarify that vehicle reports are not required.

This is a TJ text only - The purpose of this TJ is to be a master reference list to easily identify any components that are on prior approval. This TJ will be regularily updated as items are added or removed from prior approval.
 Current items under prior approval are listed in the "Service" section