2005 Volvo XC90

Volvo acknowledged a problem affecting some subject vehicles involving water seepage into the plenum box area in the engine compartment.When this occurs water may enter into the interior / passenger compartment and track along the wiring harness for the Central Electronic Module (CEM), the device that controls many of the vehicle's electrical functions including wiper operation, lighting, and transmission operation.If the water reaches the CEM connector electrical faults may result.In response to such faults the CEM, a microprocessor controlled device, will attempt to reset by temporarily shutting down (for 100 milliseconds, or 0.1 seconds) and restarting; this effects various CEM functions including the instrument panel (IP) display, gauges, wipers and also the transmission gear (if it is in the overdrive range).During the reset owners may experience temporarily loss of the IP displays and an abnormal 'jerking' in the transmission/drivetrain.If the problem persist for 6 consecutive restart attempts, the CEM will enter a 'Limp Home' mode that disables non-essential electrical functions yet maintain safety critical functions such as low-beam headlights, low-speed wiper operation, brake lights, and non-overdrive transmission operation.Warning and error messages will also be illuminated in the IP display.Consumers reported experiencing conditions consistent with CEM resetting and the limp mode operation in their reports to both ODI and Volvo.No reports or allegations of crash or injury associated with possible CEM failures have been reported by Volvo or otherwise identified by ODI.Volvo revised the design of the wiring grommet (sealing device) and the plenum cover starting in May 2005 and October 2005 production dates respectively, the occurrence of the condition effectively ended after these changes.A technical service bulletin (TNN 37-35) has been published to diagnose and repair earlier production vehicles using the improved wiring grommet and/or new plenum cover.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstances.

DURING PE05-057 AND EA06-006 ODI IDENTIFIED TWO CONDITIONS INVOLVING THE POSITIVE BATTERY CABLE IN MODEL YEAR (MY) 2005 VOLVO XC90 SPORT UTILITY VEHICLES THAT COULD RESULT IN A VEHICLE FIRE:(1) POSITIVE BATTERY CABLE GROUNDING TO THE STARTER SOLENOID HOUSING; AND (2) MISPLACED JACK CRANK HANDLES UNDER THE BATTERY BRACKET AFTER BATTERY SERVICE/MAINTENANCE.DURING PE05-057 VOLVO INITIATED A SAFETY RECALL TO CORRECT THE FIRST CONDITION IN APPROXIMATELY 10,529 MY 2005 XC90 AND S80 VEHICLES EQUIPPED WITH SIX-CYLINDER ENGINES (NHTSA RECALL NO. 05V-529).IN A MAY 18, 2007 LETTER, VOLVO NOTIFIED NHTSA THAT IT WOULD BE CONDUCTING A SERVICE CAMPAIGN TO ADDRESS THE SECOND CONDITION IN APPROXIMATELY 42.211 MY 2005 XC90 VEHICLES BY INSPECTING THE JACK CRANK HANDLE FOR PROPER POSITIONING AND AFFIXING A WARNING LABEL ON THE BATTERY BRACKET TO WARN OPERATORS NOT TO PLACE THE HANDLE BETWEEN THE BATTERY AND BATTERY BRACKET (NHTSA RECALL NO. 07V-221). THE ACTIONS BY VOLVO ADDRESS BOTH CONDITIONS THAT POSE A RISK OF BATTERY CABLE FIRE IN THE SUBJECT VEHICLE POPULATION.THE AVAILABLE EVIDENCE DOES NOT INDICATE THAT THE OTHER BATTERY CABLE CONDITIONS REVIEWED DURING EA06-006 PRESENT HAVE RESULTED IN ANY FIRES IN THE SUBJECT VEHICLE POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN ANY ONE OF THE ISSUES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.

THE MANUFACTURER NOTIFIED NHTSA BY LETTER DATED APRIL 21, 2006, THAT A SAFETY RECALL HAS BEEN INITIATED FOR CORRECTION OF THIS PROBLEM ON CERTAIN MODEL YEAR 2003 - 2006 VOLVO XC90 VEHICLES. THE RECALL AFFECTS APPROXIMATELY 122,400 SUBJECT VEHICLES PRODUCED BETWEEN AUGUST 2002 AND OCTOBER 2005.NHTSA HAS ASSIGNED NO. 06V-144 TO THIS RECALL ACTION.THE CORRECTIVE ACTION WILL CONSIST OF REPLACING THE EXISTING WINDSHIELD WIPER ARMS WITH A NEW REINFORCED DESIGN.BASED ON THIS ACTION, THE SUBJECT PE HAS BEEN CLOSED.

THE OFFICE OF DEFECT INVESTIGATIONS OPENED A PRELIMINARY EVALUATION, PE05-057 BASED ON EARLY WARNING DATA SUBMITTED TO ODI BY VOLVO. THE DATA CONTAINED FIELD REPORTS OF THERMAL FAILURES OF THE POSITIVE BATTERY CABLE. ON NOVEMBER 17, 2005, VOLVO NOTIFIED ODI THAT IT HAD IDENTIFIED A SAFETY DEFECT IN THE POSITIVE BATTERY CABLES IN APPROXIMATELY 9,000 MY 2005 VOLVO XC90 VEHICLES WITH SIX CYLINDER ENGINES THAT COULD RESULT IN A FIRE.VOLVO RECALLED THE AFFECTED VEHICLES TO ADDRESS THE POTENTIAL GROUNDING CONDITION (NHTSA RECALL #05V-529).THERE WERE 13 COMPLAINTS, INCLUDING 4 FIRES, AND 10 WARRANTY CLAIMS RELATED TO THE CONDITION ADDRESSED BY 05V-529.DURING PE05-057, VOLVO ALSO PROVIDED ODI WITH INFORMATION REGARDING THREE OTHER ISSUES RELATED TO THE BATTERY CABLE/TERMINALS IN MY 2005 XC90 VEHICLES:1) UNDER TORQUED BATTERY CABLE ATTACHING FASTENERS TO THE STARTER ALLEGEDLY CAUSING ENGINE STALLS AND MELTED PARTS IN THE ENGINE COMPARTMENT (APPLICABLE TO V8 ENGINES ONLY).2) THE JACK HANDLE MAY BE CRITICALLY MISPOSITIONED AGAINST THE POSITIVE BATTERY CABLE/POST ALLEGEDLY CAUSING FIRES IN SOME VEHICLES (APPLICABLE TO ALL XC90 VEHICLES).3) A POTENTIAL CHAFFING CONDITION OF THE POSITIVE BATTERY CABLE TO A SHARP EDGED SHEET METAL FLANGE IN THE REAR STORAGE COMPARTMENT. (APPLICABLE TO ALL XC90 VEHICLES).THE PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-006) TO ASSESS THE SCOPE, FREQUENCY AND POTENTIAL SAFETY CONSEQUENCES OF EACH OF THESE ISSUES.

I was getting off the highway and made a left turn. As I was accelerating the motor gentle cut off.. (You wouldnt even notice if you wasnt driving) Full Traffic was behind me, so luckily I was able to get out of the way and pull to shoulder. It was the day before Christmas and car hasn't ran since. Upon investigation I found the CEM was effected. When the car died I was in left hand lane and I had to make my way to right, the shoulder. Yes the problem was diagnosed by myself. However I did investigation and researched using all data at library. It has not been inspected by anyone else. There where no warning lamps or messages prior to the failure. It happened all of a sudden in the middle of traffic when I was getting off the highway.

NHTSA ID

11646424

Incident

Dec 24, 2024

I’ve had to change my fuel injection pump and catalytic convert twice on one year.

NHTSA ID

11532420

Incident

Jul 15, 2023

ADAS, AIR BAR Warning lights/urgent and High Gas fumes coming out from the rear seats when fully filled gas. We had called 800-458-1552 and guided us to plug in our VIN [XXX] on www.volvocars.com and nothing showed as far as recall and told us that these recalls expired and our 2005 Volvo are not eligible. 2005 Volvo XC90 that relates to NHTSA Campaign Number: 09V483000, Make: VOLVO Model: XC90 Model Year: 2005 Manufacturer: VOLVO CARS OF N.A. LLC. Mfr's Report Date: DEC 17, 2009 NHTSA CAMPAIGN ID Number: 09V483000 NHTSA Action Number: PE09039 Component: FUEL SYSTEM, GASOLINEELIVERY:FUEL PUMP Potential Number of Units Affected: 136100 Summary: VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE. Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE. Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JANUARY 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552. My wife and I had purchased our Volvo XC90 in 2005, here in CA. Six months ago everytime we filled up the gas tank, we would smell a heavy fumes of gas as it was coming from the inside of the vehicle. We had called the Volvo 800 number above and guided us to plug in our VIN [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA

NHTSA ID

11525043

Incident

May 29, 2023

Water is leaking from the windshield into the driver and passenger side inside on the window obstructing my view while driving. Cannot drive the vehicle while it’s raining. Serious safety problem! Please recall and fix all Volvos with this problem.

NHTSA ID

11502170

Incident

Jan 5, 2023

I HAD FILLED AN EARLIER COMPLAINT AND THIS TO BE ADDED TO THE EARLIER FORM THAT I HAD FILLED NEEDS TO GO TO THE ENGINEERING DEPARTMENT. SEE PHOTO THE ELECTRICAL COMPLAINT FROM THE MAGNETIC ELECTRICAL BEINGS IN ME AND IN THIS PICTURE I BELIEVE IS ABOUT DESIGN OF THE FUSES IN VEHICLE AND WHAT THEY ARE TRYIN TO COMMUNICATE HERE I BELIEVE WOULD BE THE DISTANCE BETWEEN THE POSITIVE AND NEGATIVE CONNECTIONS LIKE WHAT IT IS DOING TO THEM AS IT GOES THROUGH THOSE TYPES OF FUSES. WHAT I BELIEVE TO BE WHAT HAPPENS TO THEM IN THOSE PLASTIC FUSES AND WOULD LIKE THEM THE FUSE TO BE DESIGNED FURTHER APART A LITTLE BIT BIGGER THAN A PENNY AND WITH THE CONNECTION STRAIGHT ACROSS AND NOT GOING UP AND DOWN AND BACK THROUGH IT SELF. THE MAGNETIC BEINGS WOULD LIKE TO SEE THE CONNECTIONS STRAIGHT ACROSS SO THAT THEY DON'T INTERFERE WITH EACH OTHER WHILE TRAVELING THROUGH THE SUBSTRAIGHT. NOT SURE BUT YOU WERE THIS TYPE OF BEING YOU WOULD TRY AND COMMUNICATED THESE THINGS AND DESIGN WELL JUST LOOK AND IF YOU WOULD LIKE THEY LIKE THE OLDER GLASS FUSE WITH THE STAINLESS STEEL DESIGN. IF YOU COULD THEY ARE ASKING THAT YOU THE NTSB GO BACK REDESIGN A FUSE THAT DON'T GO BACK INTO ITSELF THEY LIKE STRAIGHT ACROSS THE CONNECTIONS TO GIVE THEM BETTER FLOW. REMINDER THIS GOES TO THE EARLIER FORM THAT I WROTE TO YOU IT AN ADDITION INFORMATION CAUSE THEY ARE IMPORTANT PART OF THIS WORLD I AM REFERRING TO THE MAGNETIC BEINGS IN ELECTRICITY IN EVERY VEHICLE MADE AND NEED TO BE TAKEN INTO MORE CONSIDERATION ESPECIALLY WHEN MAKING SYSTEMS THAT HEAVILY RELY ON THE ENTITIES. THEY THE BEINGS ARE ASKING THIS OF YOU THENTSB TO TAKE THEM MORE INTO CONSIDERATION AS WE US THEM RELY ON THEM THE INVISIBLE MAGNETIC ELECTRICAL BEINGS MORE AND TO DEVELOP FRIENDLIER AND HEAVIER SYSTEM FOR THEM BECAUSE THE DESIGN NOW IS MAKING THEM SICK AND THEY ARE I AM ASKING FOR THE ENTITIES THAT YOU MAKE HEALTHYELECTRICITY

NHTSA ID

11340785

Incident

Oct 10, 1990

Mileage

138 mi

WHEN CRANKING IT STALLS AND CUTS OFF AND AFTER DOING IT AROUND 10 TIMES IT FINALLY CRANKS THEN I HAVE TO HURRY TO PUT IN DRIVE TO GET THE MOTOR GOING IN ORDER TO KEEP HER CRUNK AND COUPLE WEEKS AGO BECAUSE THIS PROBLEM SHE STALLED OUT AND I HIT A HOLE IN THE ROAD AND BUSTED THE OIL PAN SO SHE HAS BEEN PARKED EVERY SINCE CAUSE I HAD MY DAUGHTER IN THE CAR AND THAT WASN'T A PRETTY SIGHT SINCE THE HIT MADE HER NERVOUS NOW CAN'T GET HER TO GET IN THE CAR SO I NEED MY CAR FIXED AND I SEE IT HAS SEVERAL RECALLS AND ALL AND IT WAS ON A COUNTY STREET ONCE I GOT IT CRUNK BACK UP IT SMOKED BADLY TILL I TURNED IT OFF AND IT TOOK FOUR HOURS FOR ME TO GET IT OUT THE ROAD

NHTSA ID

11340041

Incident

Jul 2, 2020

BOUGHT CAR AND BEEN HAVING PROBLEMS EVERY SINCE I HAVE HAD PROBLEMS I KEEP FUEL INJECTION IN IT SO I CAN MOVE THE CAR TO POINT A AND B

NHTSA ID

11319436

Incident

Mar 2, 2020

Mileage

216,000 mi

THE KNOWN VOLVO BALANCE SHAFT FAILURE IN THE 05 XC90 V8 B8444S ENGINES SN UP TO 6833.VOLVO HAS KNOWN THE V8 ENGINE ON THE 2005 XC90 IS FAULTY SINCE 2005.SPECIFICALLY, THE COUNTERBALANCE SHAFT BEARING FAILING DUE TO WATER INTRUSION & HUMIDITY.MINE HAS NOT FAILED YET.I WILL BE LUCKY IF IT FAILS WHILE AT IDLE.BERGERON VOLVO IN METAIRIE, LA, SOLD ME A TICKING TIME BOMB TO DRIVE MY 4 YEAR OLD SON AROUND IN.THERE WAS NO DISCLOSURE OF THE KNOWN CB SHAFT BEARING FAILURE!I WOULD NOT HAVE PURCHASED THIS FOR ME & MY LITTLE BOY!MY ENTIRE ENGINE WILL EVENTUALLY SEIZE UP & MY OTHERWISE BEAUTIFUL CLEAN CAR WILL BE A LARGE & USELESS PAPERWEIGHT.IF THIS HAPPENS WHILE THE CAR IS MOVING AT SPEED,IT COULD CAUSE A HORRIBLE ACCIDENT!UNLESS VOLVO ACTIVELY (AND, I AM ONE OF THEM #1868) FINDS THE REMAINING AFFECTED ENGINES IN SERVICE & FIXES THIS PROBLEM, IT REMIANS A RISK REGARDLESS OF THE MILEAGE.MY CAR CURRENTLY HAS ONLY 72K MILES ON IT! I AM TRYING TO PREVENT THIS FORM HAPPENING, AND NEEDS TO BE PAID FOR BY VOLVO.THIS IS SOMETHING THAT IS IMPOSSIBLE FOR ME TO PREVENTATIVELY MAINTAIN! APPROPRIATELY,THEY SHOULD ALSO REIMBURSE ANYONE WHO WAS AFFECTED BY THIS PROBLEM SINCE THEY LEARNED ABOUT IT BACK IN 2005. THE BERGERONVOLVOCARS.COM SITE STATES MR. DENIS BERGERON HAS AN OPEN DOOR POLICY, WHEREBY CUSTOMERS CAN CONTACT HIM DIRECTLY,I EMAILED MR. BERGERON MY CONCERN LAST WEEK AND HAVE YET TO HEAR BACK FROM HIM. I WOULD LIKE A CALL BACK & SIT DOWN WITH MR. BERGERON TO HAVE THIS ENGINE DEFECT FIXED BEFORE I AM IN A HORRIBLE ACCIDENT OR LEFT WITHOUT A CAR.SOME WEBSITES FOR REFERENCE: HTTPS://WORKSHOP-MANUALS.COM/VOLVO/XC90_AWD/V8-4.4L_VIN_85_B8444S/ENGINE_COOLING_AND_EXHAUST/ENGINE/TIMING_COMPONENTS/BALANCE_SHAFT_BEARING/COMPONENT_INFORMATION/SERVICE_AND_REPAIR/ ; HTTPS://BLOG.FCPEURO.COM/THE-DARK-SIDE-OF-VOLVOS-EXCELLENT-V8 ; HTTPS://WWW.MATTHEWSVOLVOSITE.COM/FORUMS/VIEWTOPIC.PHP?F=10&T=87848

NHTSA ID

11228807

Incident

Jun 25, 2019

This is a Technical Journal: Text plus 2 PDFs and 1 .PNG Oil Consumption test. Perform the test. Follow service procedure
 Description and Service sections updated to clarify that vehicle reports are not required.

This is a TJ text only - The purpose of this TJ is to be a master reference list to easily identify any components that are on prior approval. This TJ will be regularily updated as items are added or removed from prior approval.
 Current items under prior approval are listed in the "Service" section

This is a Technical Journal. Vehicle type and platform identification.

This is a Technical Journal: Remote connection, BOMGAR application. Before joining a remote session:
 •Connect a suitable battery maintainer/charger and verify that the battery voltage indicated in VIDA is between 12.5V and 14.9V.
 •Connect to the vehicle over a wired connection using a VOE (Volvo OBD to Ethernet) adapter and perform a NEW vehicle readout.

Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action S10303 on certain model year 2025 EX90 vehicles.
 Volvo Car Investigations have identified that there is a pairing issue with the key fob.
 As a result, there is a possibility that the customer’s key fob is not paired to the vehicle.
 The corrective action is to download SP Software.
 S10303 affects 151 vehicles in the U.S and 5 in Canada.

Volvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has decided to launch Service Action S10303 on certain model year 2025 EX90 vehicles.
 Volvo Car Investigations have identified that there is a pairing issue with the key fob.
 As a result, there is a possibility that the customer’s key fob is not paired to the vehicle.
 The corrective action is to download SP Software.
 S10303 affects 151 vehicles in the U.S and 5 in Canada.