2006 Nissan Armada

ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.

Breaks suddenly went out and I couldn't stop. I had our kids in the car.

NHTSA ID

11725415

Incident

Aug 17, 2025

Earlier in the year the brake light (some times with slip and ABS) came on the dash and suddenly braking was diminished. There was a horrid grinding sound plus vibration under the pedal. I was on highway 17 (a dangerous mountain freeway in CA) going downhill and it was extremely scary as has a car full of friends kids and hardly any brakes. I braked as much as it would allow, down shifted and pulled to the side (which again if you google that highway people die all the time from idiot drivers/speeders/tight corners). I instinctively turned off the car and got out to check off something had gotten caught in my wheel but nothing. I turned the car on and the problem had gone so drove to the nearest garage but he couldn't find anything wrong. I called Nissan but they said they knew of no problems with breaking systems on the Armada and said to bring it in and pay for an expensive diagnosis. When I got home I googled it and found 100s of similar experiences with all sorts of repairs at Nissan that hadn't worked. Some say brake booster, others sensor, other reset or upgrade hardware. Not one actually fix so far but I did find a couple of lawsuits for the same reason so don't understand how this is not a recall. The second time I was in town so it wasn't too bad but hard to stop at the crossing for a pedestrian and today it went again going back up the mountain but luckily don't need to brake much going in that direction. If it can't be fixed and it involves brakes then surely this is a serious safety violation. I also noticed that others are having a similar problem with newer Armadas with a newly upgraded braking system from Nissan and another lawsuit is on file. How is this being ignored? My car is 20 and I was looking into another Nissan but if they don't stand by and honor their mistakes then I really have no faith in them

NHTSA ID

11684631

Incident

Sep 2, 2025

Once in awhile when the brakes are applied there is a loud sound that sounds like ache large can being crushed, and the brakes don't work properly. The car sort of lurches to a stop rather than coming to a smooth stop. If the engine is shut off and turned back on nine times out of 10 the brakes will begin to work again but occasionally it takes a few times of restarting the vehicle. I contacted Nissan and they said that they would contact me back and they had a lawyer call me who really just wanted to interrogate me more than offer any kind of solutions or answers. I was able to look up online and see that there is or was a class action lawsuit and that it's a known problem with many Nissan armadas being the master solenoid. This seems to be a continuing safety issue and if someone were to have to come to a quick stop there's no warning that this is going to happen beforehand and would negate any kind of safety stop. This has been going on for many years and is extremely expensive to fix. Which puts it right out for most families to be able to afford fixing this and just having to lope along hoping that it isn't one of those times when the brakes are going to give out in an emergency. Given that Nissan contacted me with a lawyer shows me that they are afraid of what could happen but not yet concerned enough that enough people have died for it to be worth their while cost-wise.

NHTSA ID

11636093

Incident

Jan 15, 2025

Brakes. Went out with no warning For second time

NHTSA ID

11589202

Incident

May 15, 2024

The contact owns a 2006 Nissan Armada. The contact stated while driving at an undisclosed speed and attempting to slow the vehicle, the contact heard an abnormal sound emanating from the brake pads, requiring increased effort to slow the vehicle. The vehicle returned to normal functionality, but the failure became a regular occurrence. The ABS warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

NHTSA ID

11579520

Incident

Mar 26, 2024

The contact owed a 2006 Nissan Armada. The contact stated that while driving at an undisclosed speed, the contact noticed fire and smoke coming from the front passenger side underneath the glove compartment area. The contact stopped and parked the vehicle. The contact exited the vehicle and noticed the vehicle was on fire. The fire department arrived on the scene and extinguished the fire. A fire report was filed. There were no injuries sustained. The vehicle was left on the shoulder of the road. The contact stated the local police authorities later placed a sticker on the disabled burned vehicle because it was left on the shoulder of the road and had to be removed. The contact stated that the vehicle was junked. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 200,100.

NHTSA ID

11559927

Incident

Nov 30, 2023

Mileage

200,100 mi

While driving the brake light came on and when I attempted to stop pedal goes almost to the floor and loud grinding noise is heard. I was able to barely stop the vehicle, I then shut off the vehicle, checked around the vehicle as well as engine compartment not finding any noticeable issue. Restarted the vehicle and brake light was off able to stop with no issue and no grinding noise was heard. Mentioned this to dealer when it was brought in for oil change and they indicated that there was no notice of a recall for this issue. They checked the vehicle and could not find any issues. This has happened several more times where brake light goes on, issue with trying to stop and loud grinding noise. The remedy seems to be to get the vehicle stopped, barely, shut off the vehicle, wait for a short moment and then restart the vehicle. This is very concerning if this happens when needing to make an immediate stop as it takes a bit to get the vehicle to stop when this occurs. Nothing in particular is being done while driving to cause this to happen and I have not been able to replicate.

NHTSA ID

11557123

Incident

Oct 11, 2023

Several times when driving, my brake light will come on and when pressing the brake, it does not engage. When you press on the pedal you hear a loud grinding sound. It does not slow down the vehicle at all and the grinding is loud and seems to be damaging internal parts. When you turn the engine off, and restart it the problem goes away. I have read so many similar issues with 2006 nissan armada about the brake light. How is this not a safety recall especially when I’m on the freeway driving 65 MPH and all of a sudden brake light comes on! I have to pull over safely and hard to do especially when the brake does not engage at all when the light is on. This is a huge safety concern for me due to the fact that I never know when this is going to happen again. What if it happens while I need to come to a quick emergency stop?! This is a major safety concern that needs to be looked into!!

NHTSA ID

11483616

Incident

Sep 8, 2022

CERTIFICATION LABEL AND VIN PLATE REPLACEMENT SERVICE INFORMATION Because of collision damage or other vehicle repair, a replacement “Certification Label” or “VIN Plate/Label” may be needed. HINT: Certification Label = FMVSS (Federal Motor Vehicle Safety Standards) label. These items may be available from Nissan by request if certain criteria are met. This bulletin lists the criteria and provides an application form for such replacements. · The “VIN Plate/Label” (metal plate or vinyl label) is attached to the instrument panel or body on the driver side at the base of the windshield (see Figure 1). · The “Certification Label” (vinyl adhesive label) is located on the lower area of the driver side B-Pillar (see Figure 1).

CERTIFICATION LABEL AND VIN PLATE REPLACEMENT SERVICE INFORMATION Because of collision damage or other vehicle repair, a replacement “Certification Label” or “VIN Plate/Label” may be needed. HINT: Certification Label = FMVSS (Federal Motor Vehicle Safety Standards) label. These items may be available from Nissan by request if certain criteria are met. This bulletin lists the criteria and provides an application form for such replacements. · The “VIN Plate/Label” (metal plate or vinyl label) is attached to the instrument panel or body on the driver side at the base of the windshield (see Figure 1). · The “Certification Label” (vinyl adhesive label) is located on the lower area of the driver side B-Pillar (see Figure 1).

VOLUNTARY SAFETY RECALL CAMPAIGN 2004-2012 ARMADA, TITAN, AND 2004-2009 QUEST; DRIVER AIR BAG COVER CAMPAIGN ID #: PC944, PC946, PC947, PC949 APPLIED VEHICLES: 2004-2012 Armada (TA60) 2004-2009 Quest (V42) 2004-2012 Titan (A60) Check Service COMM or Dealer Business Systems (DBS) National Service History to confirm campaign eligibility. INTRODUCTION Nissan is conducting this voluntary safety recall campaign on certain specific model year 2004-2012 Armada, 2004-2012 Titan, and 2004-2009 Quest vehicles, to inspect and if necessary, replace the driver Air Bag Cover. This service will be performed at no charge to the customer for parts or labor. IDENTIFICATION NUMBER Nissan has assigned identification numbers PC944, PC946, PC947 and PC949 to this campaign. The vehicle specific number must appear on all communication and documentation of any nature dealing with this campaign. DEALER RESPONSIBILITY It is the dealer’s responsibility to check Service COMM or Dealer Business Systems (DBS) National Service History for the campaign status on each vehicle falling within the range of this voluntary safety recall which for any reason enters the service department. This includes vehicles purchased from private parties or presented by transient (tourist) owners and vehicles in a dealer’s inventory. Federal law requires that new vehicles in dealer inventory which are the subject of a safety recall must be corrected prior to sale. Failure to do so can result in civil penalties by the National Highway Traffic Safety Administration. While federal law applies only to new vehicles, Nissan strongly encourages dealers to correct any used vehicles in their inventory before they are retailed. This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

CAN COMMUNICATION CODES – DIAGNOSTIC TIPS AND GUIDELINES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

CAN COMMUNICATION – NETWORK DIAGNOSTIC FLOW CHART This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.