2011 Nissan Armada

The contact owns a 2011 Nissan Armada. The contact stated that while driving at various speeds, there was an abnormal burning odor coming from the vehicle. The contact stated that one day, upon exiting the vehicle with the engine running, there was heavy black smoke coming from the front passenger’s seat. The contact alerted the business at her location about the failure and obtained buckets of water to assist the contact. The contact used a knife to cut out parts of the seat and poured water directly on the smoke. Once the Fire Department arrived at the scene, the smoke was extinguished, and the vehicle was inspected to ensure that there was no presence of a fire. No injuries were reported. The contact was not informed if a fire report was filed. The contact stated that the driver’s side seat warmer was activated at the time of the failure; however, the passenger’s side seat was not occupied, and the seat warmer should not have been activated. Despite the failure, the contact resumed normal operation of the vehicle. The contact called the dealer and was referred to the NHTSA Hotline. The manufacturer was not notified of the failure. The vehicle was not diagnosed or repaired; however, the front passenger’s seat was removed from the vehicle. The failure mileage was 200,000.

NHTSA ID

11649223

Incident

Nov 27, 2024

Mileage

200,000 mi

The rear crossmember subframe on my vehicle is completely rusted out which caused serious suspension issue and cause the control arm to be in contact with the fuel tank. It didnt go through the tank because i found the issue on time and stopped driving the vehicle but it caused damage to the tank. If I didnt stop driving the car it was just a matter of time before the control arm perforated the tank, which could have been a lot worse with a risk of fire. This looks to be a common issue with Nissan cars so I’m not sure how there is no recall for it. I keep the vehicle maintained properly and bring it to the dealer for repairs. The dealer also performed a lot of work on the rear suspension of my car a couple of years ago but never mentioned anything to me about this major rust on the crossmember subframe.

NHTSA ID

11577091

Incident

Mar 2, 2024

My 2011 Nissan Armada started shaking very badly 8 months ago. Around that same time I had all 4 tires replaced. I took the car back to the place that put my new tires on (National Tire and Battery) and was told that the rack and pinion assembly needed to be replaced. They wanted $800-900 for the repair and to leave my car for 3 days which I could not do due to having only one vehicle. I took my car to a mechanic that dealt with electrical issues as well (Motions Automotive). They did what I felt like was a quick fix because the owner told the mechanic what he needed to do but the mechanic did a ride along with me, vocally stated what he wanted to do and reassured me he would do his best but the owner took precedence. Something was done to my air compressor(s) and it lasted a little over a week then went back to violently shaking every time I hit a bump or pot hole as well as the car taking a while to come to a complete stop. That happened from the beginning and I took it to the Nissan dealership twice and was told that’s normal. I have to stop far off from a stop sign or light to stop in time or just fly through. All of the recalls that the 2010 Armada has is all of the same issues I’m having which are very dangerous and life threatening. My suspension, rack and pinion, and brakes are all severely affected. I have 3 children and we love that car but as a single mother it fit my budget and family needs perfectly. I forgot to add that no warning lights are on nor were they ever on which worried me the most. I hope that someone can add the 2011 Nissan Armada to the 2010 Nissan Armada recalls. Thank you for your time!

NHTSA ID

11574145

Incident

Feb 1, 2022

On a short drive back home on a sunny warm day and was going relatively slow (~20 MPH) and tried to slow down to make a turn. The pedal went to the ground and braking was ineffective (slowed down 2 or 3 mph every time I hit the brakes). Seems like the ABS was kicking in, even though we were not sliding. I was just trying to slow down. I was finally able to slow down and stop the vehicle and I pulled off the side of the road to inspect. The "BRAKE" light was illuminated even though the parking brake was off, so I thought there must be a trouble code. I had my code reader with me. I read the code reported from the vehicle. Which was C1179, a malfunction with the delta sensor. I looked over the vehicle and brake fluid looked good. Brakes were not hot, no signs of any brake problems. I did not clear any codes or reset anything but the car drove normally the rest of the way home. No problems the next day either. This issue must be intermittent but it is scary. If these brakes had failed at a higher speed or on a mountain pass it could have been much worse!

NHTSA ID

11538350

Incident

Aug 12, 2023

This is a structural issue. The panel on the side between the windshield and the front door windows are too wide. It causes a blindspot. If pedestrians are standing a just the right position of where this panel blocks the pedestrians can not be seen. Every time before turning I have to physically lean forward to lean back to see if someone is in the blindspot. On 3 occasions, I came very close to hitting pedestrians who were in the blindspot and I could not see. One of which were 3 people one being a child. I am not able to see them until I begin my turn and then have to slam on the brakes once they are in my view.

NHTSA ID

11509778

Incident

Mar 1, 2023

Cracked exhaust manifolds, as a safety issue, Exhaust gasses can enter the drivers compartment. Nissan has know about this issue for years, it is a defect, it is a very big issue with a very large percent of vehicles with this issue. Please issue a recall, so the manufacture pays for it and not the owner.

NHTSA ID

11484519

Incident

Mar 1, 2022

The Electrical components went out in the steering wheel. 1st the radio and controls went out and then the horn eventually stopped working, had to pay $300 for the part itself and even the dealership didnt have it I had to order from a specialty shop. Took all day to repair. The airbag light is constantly on but there is nothing wrong with the air bag and has been reset but it stays on. The driver side window wont roll up half the time the electrical component has went out. Sometimes it rolls down by itself. Headlights have water in them and hard to keep out after replacing them. After only having it a few months had to replace the engine bc it kept smoking. Thank goodness for warranties and at 1st they wasnt going to replace it.

NHTSA ID

11419900

Incident

Dec 25, 2020

TL* THE CONTACT OWNS A 2011 NISSAN ARMADA. THE CONTACT STATED THAT THE HEADLAMP WAS NOT PROPERLY SEALED ALLOWING MOISTURE AND WATER TO ENTER THE HEADLAMP HOUSING. THE VEHICLE WAS TAKEN TO #1 COCHRAN NISSAN OF SOUTH HILLS (3200 W. LIBERTY AVE, PITTSBURGH, PA 15216, (412) 245-4540) WHERE IT WAS DIAGNOSED WITH NEEDING THE FRONT HEADLIGHT ASSEMBLIES TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 51,000.

NHTSA ID

11399898

Incident

Dec 1, 2016

Mileage

51,000 mi

CERTIFICATION LABEL AND VIN PLATE REPLACEMENT SERVICE INFORMATION Because of collision damage or other vehicle repair, a replacement “Certification Label” or “VIN Plate/Label” may be needed. HINT: Certification Label = FMVSS (Federal Motor Vehicle Safety Standards) label. These items may be available from Nissan by request if certain criteria are met. This bulletin lists the criteria and provides an application form for such replacements. · The “VIN Plate/Label” (metal plate or vinyl label) is attached to the instrument panel or body on the driver side at the base of the windshield (see Figure 1). · The “Certification Label” (vinyl adhesive label) is located on the lower area of the driver side B-Pillar (see Figure 1).

CERTIFICATION LABEL AND VIN PLATE REPLACEMENT SERVICE INFORMATION Because of collision damage or other vehicle repair, a replacement “Certification Label” or “VIN Plate/Label” may be needed. HINT: Certification Label = FMVSS (Federal Motor Vehicle Safety Standards) label. These items may be available from Nissan by request if certain criteria are met. This bulletin lists the criteria and provides an application form for such replacements. · The “VIN Plate/Label” (metal plate or vinyl label) is attached to the instrument panel or body on the driver side at the base of the windshield (see Figure 1). · The “Certification Label” (vinyl adhesive label) is located on the lower area of the driver side B-Pillar (see Figure 1).

VOLUNTARY SAFETY RECALL CAMPAIGN 2004-2012 ARMADA, TITAN, AND 2004-2009 QUEST; DRIVER AIR BAG COVER CAMPAIGN ID #: PC944, PC946, PC947, PC949 APPLIED VEHICLES: 2004-2012 Armada (TA60) 2004-2009 Quest (V42) 2004-2012 Titan (A60) Check Service COMM or Dealer Business Systems (DBS) National Service History to confirm campaign eligibility. INTRODUCTION Nissan is conducting this voluntary safety recall campaign on certain specific model year 2004-2012 Armada, 2004-2012 Titan, and 2004-2009 Quest vehicles, to inspect and if necessary, replace the driver Air Bag Cover. This service will be performed at no charge to the customer for parts or labor. IDENTIFICATION NUMBER Nissan has assigned identification numbers PC944, PC946, PC947 and PC949 to this campaign. The vehicle specific number must appear on all communication and documentation of any nature dealing with this campaign. DEALER RESPONSIBILITY It is the dealer’s responsibility to check Service COMM or Dealer Business Systems (DBS) National Service History for the campaign status on each vehicle falling within the range of this voluntary safety recall which for any reason enters the service department. This includes vehicles purchased from private parties or presented by transient (tourist) owners and vehicles in a dealer’s inventory. Federal law requires that new vehicles in dealer inventory which are the subject of a safety recall must be corrected prior to sale. Failure to do so can result in civil penalties by the National Highway Traffic Safety Administration. While federal law applies only to new vehicles, Nissan strongly encourages dealers to correct any used vehicles in their inventory before they are retailed. This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

CAN COMMUNICATION CODES – DIAGNOSTIC TIPS AND GUIDELINES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

CAN COMMUNICATION – NETWORK DIAGNOSTIC FLOW CHART This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.