2003 Subaru Outback

The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field failures was found in vehicles produced by these five additional manufacturers.Nonetheless, at ODI's insistence, all 10 vehicle manufacturers initiated a regional recall within approximately two weeks of the opening of the investigation.The regions recalled initially included Florida, Puerto Rico, Hawaii, and the U.S. Virgin Islands, areas with high absolute humidity and climatic conditions believed to be a significant factor in the inflator ruptures.As part of the recall actions, inflators removed from remedied vehicles are to be returned to Takata for testing.Takata's initial test results on passenger inflators from remedied vehicles indicated a much higher than anticipated rupture frequency for inflators returned from Florida.Accordingly ODI requested all 10 manufacturers expand the regional recalls for passenger inflators to include other geographic areas where high absolute humidity conditions exist, including the Gulf States and other coastal areas.Takata's testing of the passenger inflators to date continues to indicate this geographic area as having the highest risk, with no ruptures occurring from inflators returned from outside the expanded recall regions.During PE14-016 four additional passenger inflator field events occurred, all in vehicles from the same expanded geographic region.Also during PE14-016 four additional driver inflator field events occurred including two in vehicles from regions not known for high absolute humidity, specifically California and North Carolina.Accordingly, ODI requested all five of the affected vehicle manufacturers currently using the subject Takata driver inflators expand to nationwide recalls.Significantly, neither of the affected vehicle manufacturers or Takata provided any explanation to account for these two driver air bag inflator ruptures outside the area of high absolute humidity.Takata testing of returned driver inflators indicates a lower rupture frequency as compared to passenger inflator testing.All test ruptures reported by Takata to date have occurred on inflators returned from high absolute humidity areas.The investigation now includes all manufacturers and vehicles known to be affected at this time.ODI's investigation will focus on, among other things, root cause analysis, other potential defect consequences, identification of affected vehicles scope, and adequacy of the remedy.The five ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10537899, 10568848, 10585224, 10605877, 10651492

The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field failures was found in vehicles produced by these five additional manufacturers.Nonetheless, at ODI's insistence, all 10 vehicle manufacturers initiated a regional recall within approximately two weeks of the opening of the investigation.The regions recalled initially included Florida, Puerto Rico, Hawaii, and the U.S. Virgin Islands, areas with consistently high absolute humidity and climatic conditions believed to be a significant factor in the inflator ruptures.As part of the recall actions, inflators removed from remedied vehicles are to be returned to Takata for testing.Takata's initial test results on passenger inflators from remedied vehicles indicated a much higher than anticipated rupture frequency for inflators returned from Florida.Accordingly, ODI requested all 10 manufacturers expand the regional recalls for passenger inflators to include other geographic areas where high absolute humidity conditions exist, including the Gulf States and other coastal areas.Takata's testing of the passenger inflators to date continues to indicate this geographic area as having the highest risk, with no ruptures occurring from inflators returned from outside the expanded recall regions.During PE14-016, four additional passenger inflator field events occurred, all in vehicles from the same expanded geographic region.Also during PE14-016, four additional driver inflator field events occurred including two in vehicles from regions not known for high absolute humidity, specifically California and North Carolina.Accordingly, ODI requested all five of the affected vehicle manufacturers currently using the subject Takata driver inflators expand to nationwide recalls.Significantly, neither of the affected vehicle manufacturers or Takata provided any explanation to account for these two driver air bag inflator ruptures outside the area of high absolute humidity.Takata testing of returned driver inflators indicates a lower rupture frequency as compared to passenger inflator testing.All test ruptures reported by Takata to date have occurred on inflators returned from high absolute humidity areas.The PE is now closed/upgraded to an Engineering Evaluation (EA15-001) to include all manufacturersand vehicles known to be affected at this time.ODI's EA investigation will focus on, among other things, root cause analysis, other potential defect consequences, identification of affected vehicles scope, and adequacy of the remedy.The recalls related to this PE are: 14V343, 14V344, 14V348, 14V351, 14V353, 14V655, 14V700, 14V701, 14V752, 14V763, 14V770, 14V773, 14V787, 14V802 and 14V817.The number of vehicles affected are an estimate since some vehicles may have both the driver and passenger side inflators recalled. The five ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10537899, 10568848, 10585224, 10605877, 10651492

MY COMPLAINT IS MY HEADLIGHTS' THEY'RE CLOUDY. ON NOV. 29, 2018 THE INSTITUTE OF HIGHWAY SAFETY RELEASED A REPORT THAT SAID THAT 'MOST BASE MODEL CARS HAVE POOR-QUALITY HEADLIGHTS. MY COMPLAINT IS THE CAR MANUFACTURERS CREATED THIS PROBLEM WHEN THEY DECIDED DECADES AGO THAT PLASTIC WAS A BETTER SHIELD OVER THE HEADLIGHTS THAN GLASS. MY SUGGESTION IS TO MAKE THE CAR MANUFACTURERS GO BACK TO INSTALLING GLASS OVER THEIR HEADLIGHTS OR U.S. DRIVERS ARE ALWAYS GOING TO HAVE CLOUDY HEADLIGHTS. EVEN WHEN WE BUFF THEM OUT AND MAKE THEM SHINE AGAIN, IT ONLY LAST 6 OR 7 YEARS. THIS IS RIDICULOUS AND THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION SHOULD CHANGE THIS FLAW IN AUTO MANUFACTURING BY MAKING IT A LAW TO USE GLASS WHEN THEY BUILD THEIR HEADLIGHTS IN THE FUTURE.

NHTSA ID

11161929

Incident

Dec 17, 2018

Mileage

80,000 mi

2003 SUBARU OUTBACK. CONSUMER WRITES IN REGARDS TO DEFECTIVE FRONT PASSENGER SIDE AIRBAG. *LD THE CONSUMER REFUSED TO HAVE THE RECALL REPAIR COMPLETED DUE TO BEING AFRAID OF ENTERING AN INTERSECTION LEADING TO THE DEALER'S REPAIR SHOP. *JS

NHTSA ID

11122509

Incident

Aug 24, 2018

TAKATA RECALL. THE CLOSEST SUBARU DEALERSHIP IS 125 MILES AWAY. WHEN I CALLED SUBARU WE WERE TOLD THAT THE CAR MUST BE REPAIRED AT A SUBARU DEALERSHIP. THIS CONSTITUTES A HARDSHIP FOR US TO HAVE A MANUFACTURER DEFECT REPAIRED FOR A NUMBER OF REASONS. 1) I AM HANDICAPPED AND HAVE TROUBLE SITTING IN A CAR FOR THAT LONG. 2) THERE IS 3 FEET OF SNOW ON THE GROUND 3) THIS IS OUR ONLY MODE OF TRANSPORT.

NHTSA ID

11056102

Incident

Dec 22, 2017

PRIMEWELL TIRES DEVELOPED WAVE AND INTENSE ROAD NOISE EVEN AT 50% TREAD.. HAVE BEEN BALANCED/ALIGNED REGULARLY

NHTSA ID

11052243

Incident

Aug 1, 2015

ON OR ABOUT OCT 23, 2017, RECEIVED 3RD NOTICE OF AIRBAG RECALL. APPT WITH SUBARU MISSOULA, MT FOR RECALL. AT 9:45 ON FRI NOV 3, 2017 INFORMED THAT THE MANAGER "JUST A FEW MINUTES AGO" RECEIVED, RECALL OF RECALL" AND NO PARTS THERE. MY 2003 "MAY NOT NEED A REPLACEMENT." SAID WOULD DO A CHECK TO SEE. UNDER PROTEST I SIGNED, AFTER 1 AND HALF HOURS, REQUESTED ANOTHER SIGNATURE WHICH ALSO UNDER PROTEST I SIGNED. "IT WON'T COST YOU ANYTHING." 85 YEAR OLD SINGLE WOMAN. 50 MILES NEAREST SUBARU DEALER. NOTHING SAID ABOUT RESULT OF TEST. KEYS RETURNED TO ME.

NHTSA ID

11044260

Incident

Nov 3, 2017

Mileage

74,221 mi

MY 2003 SUBARU OUTBACK HAD A BAD AIRBAG INFLATOR AND HAS ALSO BLOWN THE HEAD GASKET SEVERAL TIMES, REQUIRING IT TO BE REBUILT THREE TIMES. WHILE I LOVE MY OUTBACK, I WONDER IF I WILL WANT TO BUY ANOTHER ONE. BEING STRANDED BY MY CAR AND HAVING TO TAKE THE BUS IN THE WINTER TIME WAS VERY DIFFICULT AS WAS HAULING GROCERIES ON THE BUS IN A ROLLING SUITCASE WHILE AWAITING REPAIRS.

NHTSA ID

11032558

Incident

Sep 15, 2016

Mileage

131,000 mi

I RECENTLY HAD MY OUTBACK TOWED BECAUSE MY CAR WOULDN'T SHIFT OUT OF PARK. 1ST I CHECK THE NEUTRAL SAFETY SWITCH, GOOD TO GO NO PROBLEM. THEN MOVE ON TO MY FUSES, OKAY GREAT. INVESTIGATE SOME MORE TO FIND OUT THE WIRING ON THE OUTBACK HAS SOME DEFAULTS, I LOOK MORE INTO IT AND IT SEEMS IT'S NOT JUST ME WITH THE PROBLEM. MY CAR IS OLD AND CARRIES A LOT OF MILES, KEEP IN MIND THIS CAR IS MADE FOR THAT, BUT PEOPLE SEEM TO HAVE THE SAME PROBLEM AS ME WITH LOWER MILES. THE CARS LIFTGATE WIRE HARNESS IS A HUGE WEAKNESS ON THIS CAR. I REALLY HOPE YOU GUYS WILL LOOK MORE INTO THIS AND RECALL IT. I LOVE MY SUBY AND HAVE GREW UP IN IT AND NOW HAVE THE HONOR OF OWNING IT. WE STILL HAVE MANY MORE YEARS OF DRIVING TOGETHER SO PLEASE LOOK INTO THIS SO I CAN KEEP HER AS LONG AS POSSIBLE. TEMP FIX IT TO REMOVE BRAKE #4 HARNESS AND UNPLUG TO KEEP FROM BLOWING AND SMOKING. KEEP IN MIND ONLY LEAVES ME WITH 3 BRAKE LIGHTS. (THE ONE UNPLUGGED IS THE ONE ON THE HATCHBACK RIGHT SIDE) THIS IS VERY UNSAFE TO NOT HAD STABLE WIRING IN THE BRAKE LIGHTS, MY CAR WAS SMOKING. I CURRENTLY DO HAVE A 30 FUSE IN THAT SEEMS TO BE ABLE TO HOLD BETTER.

NHTSA ID

11023309

Incident

Aug 12, 2017

WE RECEIVED A POSTCARD ABOUT THE TAKATA PROBLEM FROM COCHRAN SUBARU OF BUTLER COUNTY PA. PER INSTRUCTIONS, WE CALLED. THEY TOLD US PARTS WERE NOT AVAILABLE AND WE WOULD BE CONTACTED WHEN PARTS BECAME AVAILABLE. WE HAVE NOT HEARD FROM THE DEALER OR FROM SUBARU USA. WHERE DOES THAT LEAVE US?

NHTSA ID

11013000

Incident

Mar 5, 2016

This announcement is requesting retailer staff to retain the EyeSight protective hood covers from Generation 4 EyeSight cameras.

This bulletin contains additional information for recommended materials listed in the Service Manuals for individual models.

This announcement provides information on the remanufactured CVT transmission program.

This Service Information Bulletin was developed to provide interim guidance for vehicles exhibiting DTC B2A20.

This bulletin announces the service manual correction regarding clutch master cylinder reservoir service procedures.

This bulletin contains additional information for recommended materials listed in the Service Manuals for individual models.