RoadVitals

1996 Toyota Tacoma

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
253
Latest Mar 20, 2023
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
6
Latest May 11, 2009
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
22
14 injuries, 2 deaths reported

Overview

Our database contains 253 NHTSA owner-reported complaints for the 1996 Toyota Tacoma, most frequently naming the suspension, body & structure and tires & wheels categories. 6 safety recalls have been issued covering this model year; 1 NHTSA investigation names it; and 63 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

6 campaigns cover this model year

View all 6

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
09E025000

EXTERIOR LIGHTING:HEADLIGHTS

May 11, 2009
42,540 units potentially affected
The defect: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
The risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
The remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
DOPE, INC.View on NHTSA.gov
09E012000

EXTERIOR LIGHTING

Apr 7, 2009
16,270 units potentially affected
The defect: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
The risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
The remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
SABERSPORTView on NHTSA.gov
06E049000

EXTERIOR LIGHTING

May 24, 2006
27,176 units potentially affected
The defect: CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
The risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
The remedy: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
CK MOTORSPORT, INC.View on NHTSA.gov

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect.

EA97015ClosedEngineering Analysis

TURN SIGNAL FAILURES

Opened Jul 22, 1997
Closed Sep 21, 1998

There is no summary currently available

EXTERIOR LIGHTING

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 253
Body & structureSuspension
Filed Mar 20, 2023

Rear passenger frame rusted/rotted, rear passenger shock mount completely torn off frame at rust area and rear passenger leaf spring assembly cracked. Vehicle is not drivable and completely unsafe. This vehicle was recalled in May 2008 for inspection of frame rust and passed the inspection with only surface frame rust found and no rust perforation. Vehicle was recalled again in January 2012 for Limited Service Campaign for New York vehicles for Frame Rust Corrosion, which it failed with substantial corrosion and rusted through holes in the frame. This vehicle was included in this second recall, however the terms of the recall for repair or buyback only extended for 15 years from vehicle’s ‘in service date’, which in this case meant this vehicle was 5 months outside the recall window. So, Toyota included the vehicle in the recall (actually mailed the recall letter), found it had unsafe frame corrosion issues upon inspection 3 weeks after receipt of recall letter, then washed their hands and walked away indicating the ‘in service date’ was 5 months outside the recall window. Makes zero sense and terrible customer service and warranty management.

NHTSA ID
11512855
Incident
Feb 14, 2012
Body & structureSuspension
Filed Mar 15, 2021

I PURCHASED TRUCK IN 2005 FROM TOYOTA OF NICHOLASVILLE KY I HEARD THERE WAS A RECALL NEVER RECEIVED RECALL NOTICE TOOK TRUCK TO HAVE BRAKES DONE MECHANIC REFUSED TO WORK ON IT BECAUSE OF DANGEROUS FRAME HOLES RUST CAN PUSH IN SIDES OF FRAME WITH FINGERS AND MAKE A HOLE MECHANIC SAID IT WAS VERY DANGEROUS TO DRIVE!

NHTSA ID
11403041
Incident
Mar 15, 2021
Suspension
Filed Dec 30, 2020

TL* THE CONTACT OWNS A 1996 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING, THE REAR PASSENGER'S SIDE OF THE VEHICLE STARTED TO LOWER. AFTER STOPPING TO INSPECT THE VEHICLE, THE CONTACT DISCOVERED THE REAR CENTER LEAF SPRING HAD FRACTURED AND HAD ALSO PUNCTURED THE FUEL TANK CAUSING THE FUEL TO LEAK FROM THE VEHICLE. THE CONTACT INDICATED THAT THE FRACTURED LEAF SPRING WAS SEVERE RUSTED. AN UNKNOWN DEALER WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED OR INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000. THE VIN WAS NOT AVAILABLE.

NHTSA ID
11385620
Incident
Oct 1, 2020
Mileage
130,000 mi
Body & structure
Filed Aug 19, 2019

TL* THE CONTACT OWNS A 1996 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE'S FRAME WAS CORRODED WITH HOLES NEAR THE REAR PASSENGER SIDE WHEEL. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER FOR THE MANUFACTURER WARRANTED FRAME REPAIR. WHEN THE CONTACT ARRIVED AT THE DEALER, THE CONTACT WAS INFORMED THAT THE FRAME WAS NOT CORRODED AND THE VEHICLE DID NOT QUALIFY FOR THE BUY BACK PROGRAM. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 115,310. *TT*JB

NHTSA ID
11244911
Incident
Aug 16, 2019
Mileage
115,310 mi
Body & structure
Filed Jun 30, 2018

THE FRAME ON THE PASSAGER SIDE OF THE TRUCK HAS RUSTED OUT? WILL NOT PASS STATE INSPECTION.

NHTSA ID
11104864
Incident
May 16, 2018
Mileage
261,000 mi
Filed Oct 13, 2017

RECALL INFO, CAN'T SELL WITHOUT PAPERWORK ON FRAME AND NEW COMPANY IN OUR CITY WON'T OR CAN'T GIVE ME PROOF THAT FRAME IS OK

NHTSA ID
11033195
Incident
Oct 12, 2017
Body & structure
Filed Aug 27, 2017

ONLY 114,000 MILES, FRAME RUSTED THROUGH. UNSAFE.

NHTSA ID
11019932
Incident
Aug 1, 2017
Suspension
Filed Jul 10, 2017

TL* THE CONTACT OWNS A 1996 TOYOTA TACOMA. THE CONTACT STATED THAT THE PASSENGER SIDE SUSPENSION SUPPORT WAS DAMAGED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 96V129000 (SUSPENSION); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE FOLSOM LAKE TOYOTA DEALER WAS CONTACTED AND REFUSED TO DO THE REPAIR BECAUSE THE FAILURE ALREADY OCCURRED ON THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 278,000. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID
11004095
Incident
Jul 3, 2017
Mileage
278,000 mi

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

TSB003220

AIR BAGS; EQUIPMENT; VEHICLE SPEED CONTROL

TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2023 model year vehicles may be available provided the requests meet the criteria listed in this Service Bulletin. Follow the Procurement Procedure in this bulletin to request a replacement certification label or VIN plate.

TTT063620

BACK OVER PREVENTION; SERVICE BRAKES, HYDRAULIC

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions

Toyota PRO19-02

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; TIRES; WHEELS

POL: This consolidated Tire Warranty Guide contains the complete warranty terms for all brands of ground and spare tires currently in use by Toyota. This information must be kept near the point of vehicle sale and be available to any customer that requests it. Customers can find this information on the Owner?s section of Toyota.com. Dealers can locate a copy of this guide on the Claims Processing & Resource Center in Dealer Daily as well.

T-TT-0636-20 Rev

BACK OVER PREVENTION; SERVICE BRAKES

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

T-SB-0032-20 Rev

EQUIPMENT

TSB: Replacement certification labels (the vinyl label installed on the driver door or door post) and VIN plates (the metal plate riveted to dashboard) (see Figure 1) for most 1979 ? 2021 model year vehicles may be available provided the requests meet the criteria listed in this Service Bulletin. Follow the Procurement Procedure in this bulletin to request a replacement certification label or VIN plate.

T-TT-0636-20

SERVICE BRAKES, HYDRAULIC

TT: Some Toyota vehicles installed with Toyota Complete Maintenance Care (TCMC) brake pads may exhibit a groan or squeak noise in various driving conditions.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Toyota Tacoma by model year
YearComplaintsRecallsInvestigationsIssue Index
2026500—
2025794060.5
20241424054.2
2023514060.7
2022573060.2
2021780049.5
2020861047.4
20192124156.4
20182023156.9
20172375160.6
20163234153.8
20151004165.0
2014934160.9
20131246164.8
20122947154.9
20111849055.9
201029113054.1
200951813054.2
200844511057.7
200754010161.5
200678211158.7
200570710052.5
20044145052.9
20033595054.2
20023335052.6
20013966056.3
20002105057.4
19992495056.6
19983005056.2
19971314054.4
1996Viewing2536156.5
19951776161.0

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.